MIL-STD-1553 (T4240/T4160/T4080) 12/8/4 2 PMC/XMC 2.0 WWDT, ETR, RTC, 4 GB DDR3

Transcription

1 Rugged 6U VME Single-Slot SBC Freescale QorIQ Multicore SOC 1/8/4 e6500 Dual Thread Cores (T440/T4160/T4080) Altivec Unit Secure Boot and Trust Architecture.0 4 GB DDR3 with ECC 56 MB NOR Flash Memory 16 GB SATA Flash Drive Versatile Board I/O USB Serial SATA Discrete GbE MIL-STD-1553 PMC/XMC Slots WWDT, ETR, RTC, Temp. Sensors VxWorks, Linux, INTEGRITY Support Conduction and Air-Cooled Versions Vibration and Shock Resistant

2 The is 's latest generation VME PC SBC, based on Freescale's new T4 Series QorIQ System-on-Chip (SoC) multi-core, multi-thread processors, with on-chip high speed L1 and L caches, and numerous integrated bus, memory, and I/O controllers. The wide variety of on-board I/O and large memory resources, including on-board mass storage, in combination with the powerful SOC processor, make the the right VME SBC for many applications, right out of the box. The two industry standard PMC/XMC slots provide flexibility and expandability, along with the availability, convenience, and cost benefits of COTS. For improved security assurance in real time/embedded systems, the also includes the latest QorIQ Secure Boot and Trust Architecture.0. The mechanical and electrical designs guarantee its operation over the full range of rugged application environments. Management EPROM Temp Sensor ETR RTC Front Panel Connectors Dual G-LAN USB Dual Micro-D COP DDR3 DDR3 Mem Ctrl #0 Mem Ctrl #1 T4 Series QorIQ SoC S3 PCIe x8 PCIe x8 S FMAN SGMII x DUART x USB I C #1 PCIe 3.0 Switch IFC S1 FMAN MRAM S4 SATAx AURORA SATA x Tsec RGMII NAND Flash x1 PCI x8 x4 PCI-X x8 x4 PCI To Front Panel GbE Quad GbE PHY MUX GbE Serial USB 4 FPGA Discrete 16 NOR Flash SATA x 1553 Controller 1553 PCI Bus 0 66 MHz Serial QUICC II Hi-Speed Serial 4 PMC/XMC Slot PCI Bus 1 33 MHz PMC/XMC Slot 1 PCI to VME P0 and P P1

3 Board Architecture PCIe Bus Freescale QorIQ T4 Series SOC: 1 (T440), 8 (T4160), or 4 (T4080) dual-threaded cores with integrated memory, bus, and I/O controllers. Includes on-chip 3k/3k L1 per core, and MB shared L caches per cluster (cluster = 4 cores). The PCIe Gen3 switch manages connections between the QorIQ SOC, PMC/XMC sites, 1553 controllers, and the VME bridge VMEbus VME64x per VITA 1 Board Resources Memory Resources Watchdog Timers (Windowed + Standard) Secure Boot and Trust Architecture.0 Real Time Clock Elapsed Time Recorder Temperature Sensors 8 Counters/Timers RAM Flash Disk Boot Flash NVRAM 4 GB of DDR3L with ECC operates at 1600 MT/s, configured in dual channels Optional 16 GB SATA Flash Disk 56 MB NOR Flash - 64 MB allocated for Boot; 19 MB available to user 51 kb high speed MRAM with unlimited writes & long term data retention I/O I/O variants offer different combinations/quantities of on-board and PMC/XMC I/O 1 I/O Variant PMC 1 + PMC PMC 1+ XMC XMC 1 + XMC USB.0 (1) 1 (no Vcc) (1) (1) SATA Ethernet - Gigabit: 10Base-T/100Base-TX/1000Base-T 4 () 1 () 4 () Ethernet - Fast: 10Base-T/100Base-TX - 1 () - Serial Ports High speed Multi-protocol synchronous/asynchronous ports supporting common serial communications protocols (UART, USART, SDLC, HDLC, etc.). Software configurable as RS-3/4/485 Serial Ports Standard: RS-3/4 Asynchronous UARTs. Software configurable as RS-3/4. MIL-STD-1553B BC or Multi RT operation with Concurrent Bus Monitor. Controllers support 66 MHz operation & DMA engine Discrete I/O Lines Individually software configurable as input (with optional interrupts) or output, and as SE (1 line per channel) or Diff RS-4 ( lines per channel) PMC 1 I/O Pins Routed per VITA 35 PMC I/O Pins Routed per VITA Up to - see Ordering Information N/A 35 N/A N/A XMC 1 I/O Pins: Diff Pairs + SE N/A N/A XMC I/O Pins: Diff Pairs + SE N/A Front Panel I/O (Air-Cooled only) 1 x USB (1), x Gigabit Ethernet (), x Std. Serial Ports (3) Notes: (1) On air-cooled boards one of the USB interfaces is routed to a front panel connector at the expense of one USB interface at the VME backplane connectors. Vcc is always present at the front panel USB interface. () Up to Ethernet interfaces can be individually routed, under software control, either to a front panel connector or to the VME backplane connectors. All front panel Ethernet interfaces are Gigabit: 10Base-T/100Base-TX/1000Base-T. (3) Wired in parallel to two serial ports at the VME backplane connectors. 3

4 PMC/XMC Slots PMC 1 PMC XMC 1 & 64-bit 33 MHz, supports 5 V PCI I/O signaling levels; includes voltage key 64-bit 133/100/66/33 MHz, universal site supports 3.3 V and 5 V PCI I/O signaling levels; no voltage key Connects to CPU subsystem through PCIe x8 port, supporting x8, x4, x, and x1 bus widths Software Operating Systems Drivers WindRiver VxWorks, Linux, and Green Hills INTEGRITY are supported Operating system specific device drivers for board resources are available Mechanical Form Factor 6U VME per IEEE Std (air-cooled) and IEEE Std (conduction-cooled) Dimensions Air-cooled per IEEE Std ; Conduction-cooled per IEEE Std Weight Air-cooled: < 675 g (1.5 lbs); Conduction-cooled: <1350 g (3.0 lbs) +3.3 V +5.0 V +1 V () -1 V () Total T A 7.1 A 0 A 0 A 40.8 W T A 7.7 A 0 A 0 A 43.5 W T A 8.9 A 0 A 0 A 49.5 W Notes: (1) measured under VxWorks with all CPU cores/threads operating. () ±1V required for PMC/XMC only. (3) Actual power consumption depends on configuration and assembly options. Environmental Specs per VITA 47 Air-Cooled Conduction-Cooled Commercial Rugged Military Rugged Military Operating Temp. AC1 (0 to +55 ºC) () AC3 (-40 to +70 ºC) () AC4 (-40 to +85 ºC) (1, ) CC3 (-40 to +70 ºC) (3) (1, 3) CC4 (-40 to +85 ºC) Non-Operating Temp. C1 (-40 to +85 ºC) C3 (-50 to +100 ºC) C4 (-55 to +15 ºC) C3 (-50 to +100 ºC) C4 (-55 to +15 ºC) Vibration V1 V V V3 V3 Operating Shock OS1 OS1 OS1 OS OS Altitude 15,000 ft. 35,000 ft. 70,000 ft. 35,000 ft. 70,000 ft. Relative Humidity (4) 0-90% 0-100% Conformal Coating N/A Acrylic (Silicone and Urethane Optional) Notes: (1) -55 ºC available, contact an representative for more information () Operating ambient air temperature (with sufficient airflow) (3) Operating card edge temperature (4) Non-condensing

5 Ordering Information L = T GHz U = T GHz V = T GHz A = 4 GB I/O Variant 1-3 = See Variants table above 9 = Custom (Contact sales rep) - A - Ruggedization 1 = Commercial = Rugged 4 = Military Example: 4L-RA1C-00 Cooling A = Air R = Conduction MIL-STD-1553 Ports 0, 1, or SATA Flash Drive 0 = None C = 16 GB Configuration Number To be assigned by Accessories TM10 Rear Transition Module (RTM) providing convenient access to I/O interfaces via standard connectors and to all PMC/XMC I/O via headers. Supports both air and conduction-cooled mounted in commercial air-cooled chassis. Refer to the TM10 datasheet for further information. Contact Contact your sales representative for additional product information, and for inquiries regarding customized configurations of the and additional software support. Defense Systems, Inc. Chatsworth, CA, USA Toll Free: (888) -8 [48-348] Direct: +1 (818) Fax: +1 (818) sales@rugged.com Systems, Ltd. Herzlia, Israel Tel: +97 (9) Fax: +97 (9) sales@rugged.com All names, products, and/or services mentioned are trademarks or registered trademarks of their respective holders. All information contained herein is subject to change without notice. Rev 1.7 Jul 015