OTPC 150/225/260 Amp Transfer Switch

Transcription

1 OTPC 50/5/60 Amp Transfer Switch Printed in U.S.A. 6 08B (Spec A) 5-00

2 This catalog covers models produced under the Cummins /Onan and Cummins Power Generation brand names. To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Cummins Power Generation nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Cummins Power Generation manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Cummins Power Generation equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-

3 Introduction This catalog applies to the Cummins Power Generation OTPC 50/5/60 Amp Transfer Switch. Each illustrated part is identified by a reference number corresponding to the same reference number in the parts list for that group. Parts illustrations are typical. Using the model and spec number from the switch box nameplate, select the parts that apply to your Transfer Switch. Unless otherwise noted in the parts description, parts are interchangeable between models. Feature Options Code Description Code Description A08 -Pole Switch L0 Auxiliary Relay Emergency Position VDC A0 -Pole Switch L0 Auxiliary Relay Normal Position VDC A05 Utility to Generator Set Applications L0 Auxiliary Relay Generator Start VDC A06 Utility to Utility Applications M00 Terminal Block 0 Points A0 Generator Set to Generator Set Applications M00 Load Shed From Emergency A0 One Phase or wire M0 Security Front Panel A0 Three Phase or wire M08 Display Digital A0 Frequency 60 Hz M00 Communications Lonworks A05 Frequency 50 Hz M0 Monitoring Load A06 Listing UL M0 Module Relay Signal A06 Listing UL/NFPA 0 N00 Bus Stubs Connection B00 Cabinet Type N0 Harness Extension B00 Cabinet Type R R00 Voltage 0 B00 Cabinet Type R0 Voltage 08 B00 Construction Open R0 Voltage 0 B00 Cabinet Type R0 Voltage 0 C0 Control Level R0 Voltage 80 C0 Control Level R05 Voltage 6 D00 Meters Bar Graph Display R06 Voltage 80 K00 Battery Charger Amp, /V R0 Voltage 600 K00 Battery Charger 0 Amp, V R05 Voltage 0 K00 Battery Charger 0 Amp, V R08 Voltage 0 L0 Auxiliary Relay VDC Coil S0 Current Rating 50 Amps L0 Auxiliary Relay Emergency Position VDC S050 Current Rating 5 Amps L0 Auxiliary Relay Normal Position VDC S05 Current Rating 60 Amps L0 Auxiliary Relay Generator Start VDC L0 Auxiliary Relay VDC Coil Copyright 00 Cummins Power Generation. All rights reserved.

4 Index Actuator, Linear Transfer Switch, Alarm, Battery Charger, Ammeter DC 0 Amp, Volt Battery Charger, 5 Ammeter DC 0 Amp, Volt Battery Charger, Ammeter DC Amp, / Volt Battery Charger, Arm, Interlock Transfer Switch, Bar, Interlock Transfer Switch, Bar, Neutral Transfer Switch, Barrier Transfer Switch, Barrier, Base Transfer Switch, Base, Mounting Transfer Switch, Block and Contact Assembly Transfer Switch, Block and Cross Bar Assembly Transfer Switch, Block, Hinge Type Cabinet, Block, Lug Mounting Transfer Switch, Block, Terminal, 0 Block, Terminal Battery Charger Alarm, Block, Terminal Network Module, 8 Block, Terminal Transfer Switch, Board, Printed Circuit 0 Amp, Volt Battery Charger, 5 Board, Printed Circuit 0 Amp, Volt Battery Charger, Board, Printed Circuit Amp, / Volt Battery Charger, Board, Printed Circuit Bar Graph Type Cabinet, Board, Printed Circuit Bar Graph Type R and Cabinet, 5 Board, Printed Circuit Bar Graph Type Cabinet, Board, Printed Circuit Current Transformer Module, Board, Printed Circuit Digital Type Cabinet, Board, Printed Circuit Digital Type R and Cabinet, 5 Board, Printed Circuit Digital Type Cabinet, Board, Printed Circuit Network Module, 8 Board, Printed Circuit Power Module Type Cabinet, Board, Printed Circuit Power Module Type R and Cabinet, 5 Board, Printed Circuit Power Module Type Cabinet, Board, Printed Circuit Relay Module, Bracket, Connector Accessory Control Plate (600 Volt), Bracket, Connector Accessory Control Plate (Less than 600 Volt), 8 Bracket, Door Type Cabinet, Bracket, End Auxiliary Relay, Bracket, End Terminal Battery Charger Alarm, Bracket, End Terminal Network Module, 8 Bracket, Terminal Transfer Switch, Breaker, Circuit Transfer Switch, Bus, Emergency Transfer Switch, Bus, Load Transfer Switch, Bus, Normal Transfer Switch, Cabinet Type, Cabinet Type, 5 Cabinet Type R, 5 Cabinet Type, Capacitor Transfer Switch, Charger, Battery 0 Amp, Volt, 5 Charger, Battery 0 Amp, Volt, Charger, Battery Amp, / Volt, Chute, Arc Transfer Switch, Cover, Arc Chute Transfer Switch, Cover, Charger 0 Amp, Volt Battery Charger, 5 Cover, Charger 0 Amp, Volt Battery Charger, Cover, Charger Amp, / Volt Battery Charger, Cover, Labeled Transfer Switch, Cover, Printed Circuit Board Type Cabinet, Cover, Printed Circuit Board Type R and Cabinet, 5 Cover, Printed Circuit Board Type Cabinet, Cover, Relay Plate Accessory Control Plate (600 Volt), Cover, Relay Plate Accessory Control Plate (Less than 600 Volt), 8 Door, Cabinet Type, Door, Cabinet Type R and Cabinet, 5 Door, Cabinet Type Cabinet, Fuse 0 Amp, Volt Battery Charger, 5 Fuse 0 Amp, Volt Battery Charger, Fuse Amp, / Volt Battery Charger, Gasket, Door Type R and Cabinet, 5 Gasket, Door Type Cabinet, Handle Assembly, Actuator, 0 Handle, Door Type R and Cabinet, 5 Handle, Locking Type Cabinet, Harness, Wiring 0 Amp, Volt Battery Charger, 5 Harness, Wiring 0 Amp, Volt Battery Charger, Harness, Wiring Amp, / Volt Battery Charger, Harness, Wiring Battery Charger, Harness, Wiring Battery Charger Alarm, Harness, Wiring Control Open Construction, 0 Harness, Wiring Current Transformer Module, Harness, Wiring Load Shed, Harness, Wiring Main Type Cabinet, Harness, Wiring Main Type R and Cabinet, 5 Harness, Wiring Main Type Cabinet, Harness, Wiring Network Module, 8 Holder, Fuse 0 Amp, Volt Battery Charger, 5 Holder, Fuse 0 Amp, Volt Battery Charger, Holder, Fuse Amp, / Volt Battery Charger, Insulator, Arc Chute Transfer Switch, Latch, Cam Type Cabinet, Latch, Cam Type R and Cabinet, 5 Lead Type Cabinet, Lead Type R and Cabinet, 5 Lead Type Cabinet, Load Shed, Lug, Solderless Transfer Switch, Lug, Solderless Type Cabinet, Lug, Solderless Type R and Cabinet, 5 Lug, Solderless Type Cabinet, Membrane, Panel Type Cabinet, Membrane, Panel Type R and Cabinet, 5 Membrane, Panel Type Cabinet, Module, Current Transformer, Module, Digital Display Type Cabinet, Module, Digital Display Type R and Cabinet, 5 Module, Digital Display Type Cabinet, Module, Network, 8

5 Index Plate, Accessory Control (600 Volt), Plate, Accessory Control (Less than 600 Volt), 8 Plate, End Terminal Battery Charger Alarm, Plate, End Terminal Network Module, 8 Plate, Handle Mounting Transfer Switch, Plate, Mounting Battery Charger Alarm, Plate, Mounting Current Transformer Module, Plate, Mounting Load Shed, Plate, Open Construction, 0 Plate, Relay Accessory Control Plate (600 Volt), Plate, Relay Accessory Control Plate (Less than 600 Volt), 8 Rail, Terminal Auxiliary Relay, Rail, Terminal Block Battery Charger Alarm, Rail, Terminal Block Network Module, 8 Rectifier, Bridge 0 Amp, Volt Battery Charger, 5 Rectifier, Bridge 0 Amp, Volt Battery Charger, Rectifier, Gate 0 Amp, Volt Battery Charger, 5 Rectifier, Gate 0 Amp, Volt Battery Charger, Relay Accessory Control Plate (600 Volt), Relay Accessory Control Plate (Less than 600 Volt), 8 Relay Load Shed, Relay, Auxiliary, Relay, Control Accessory Control Plate (600 Volt), Relay, Control Auxiliary Relay, Resistor, Fixed Amp, / Volt Battery Charger, Rod, Actuator Transfer Switch, Rod, Roller Type Cabinet, Rod, Roller Type R and Cabinet, 5 Rod End, Actuator Transfer Switch, Spacer, Actuator Transfer Switch, Spacer, Mounting Block Transfer Switch, Spring, Conical Type Cabinet, Standoff, Insulator Transfer Switch, Strap, Jumper Transfer Switch, Strap, Load Transfer Switch, Strip, Marker Transfer Switch, Support, Channel Transfer Switch, Switch Assembly, Auxiliary, Switch, Selector Security, Switch, Toggle Accessory Control Plate (600 Volt), Switch, Toggle Accessory Control Plate (Less than 600 Volt), 8 Transfer Switch Assembly, Transformer 0 Amp, Volt Battery Charger, 5 Transformer 0 Amp, Volt Battery Charger, Transformer Amp, / Volt Battery Charger, Transformer, Current, Transformer, Power Type Cabinet, Transformer, Power Type R and Cabinet, 5 Transformer, Power Type Cabinet, Wrapper, Charger Amp, / Volt Battery Charger, Wrapper, Charger 0 Amp, Volt Battery Charger, 5 Wrapper, Charger 0 Amp, Volt Battery Charger,

6 Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG CSA DC Deg. EFC EIT EPROM ET GFI ID IEC IT kw LPG LT M(meter number) Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Canadian Standard Association Direct Current Degree Electronic Fuel Control External/Internal Tooth Erasable Programmable Read Only Memory External Tooth Ground Fault Interrupter Inside Diameter International Electrotechnical Commission Internal Tooth Kilowatt Liquid Petroleum Gas Left Meter MCM mm MOH NFS NPT OD oz. PCB Ph PMG PT/CT RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT) Metric Circular Mils Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Printed Circuit Board Phase Permanent Magnet Generator Potential Transformer/ Current Transformer Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With

7 5

8 6 Transfer Switch

9 Transfer Switch Transfer Switch Assembly -Pole, Front Connect with Mechanical Lugs 50 Amp VAC VAC /0/0/600* VAC /6 VAC /80 VAC 5 Amp VAC VAC /0/0/600* VAC /6 VAC /80 VAC 60 Amp VAC VAC /0/0/600* VAC /6 VAC /80 VAC -Pole, Front Connect with Mechanical Lugs 50 Amp VAC /0/0/600* VAC /6 VAC /80 VAC 5 Amp VAC /0/0/600* VAC /6 VAC /80 VAC 60 Amp VAC /0/0/600* VAC /6 VAC /80 VAC -Pole, Rear Connect with Bus Stubs 50 Amp VAC VAC /0/0/600* VAC /6 VAC /80 VAC 5 Amp VAC VAC /0/0/600* VAC /6 VAC /80 VAC 60 Amp VAC VAC /0/0/600* VAC /6 VAC /80 VAC -Pole, Rear Connect with Bus Stubs 50 Amp VAC /0/0/600* VAC /6 VAC /80 VAC 5 Amp VAC /0/0/600* VAC /6 VAC /80 VAC 60 Amp VAC /0/0/600* VAC /6 VAC /80 VAC 06 5 Base, Mounting 06 6 Cover, Labeled Nut, Self-Locking (#0 ) Screw, Hex Head Slotted W/IT (#0 x.50) Washer, Flat (#0) Barrier 06 8 Spacer, Actuator Screw, Cap Hex Head (/ 0 x.50) Washer, Lock (/) Washer, Flat (/) 06 Rod, Actuator Screw, Cap Hex Head (5/6 8 x.88) Pole, Front Connect Pole, Front Connect Pole, Rear Connect Pole, Rear Connect Rod-End, Actuator Screw, Cap Hex Head (/ 0 x.5) 5 Washer, Spring Conical (5/6) Pole, Front Connect Pole, Front Connect Pole, Rear Connect Pole, Rear Connect Screw, Round Head Cross Recessed (#6 x.5) 8 Block, Terminal Screw, Hex Head (/ 0 x.50) Screw, Flat Head Cross Recessed (#0 x.50) Nut, Hex W/ET (#0 ) 06 8 Bracket, Terminal 6 80 Lead (80/6/0/80 VAC) 605 Jumper, Terminal Nut, Lock (/8 6) * Switch is actually 08 volts A large transformer in the system reduces the 600 volt system voltage down to 08 volts. Continued...

10 8 Transfer Switch

11 Transfer Switch Continued Strip, Marker Barrier, Base 06 Switch Assembly, Auxiliary (See Separate Page For Components) 8 Screw, Self-Locking Hex Head Thread Forming W/IT (/ 0 x.5) Pole, Front Connect Pole, Front Connect Pole, Rear Connect Pole, Rear Connect Block and Cross Bar Assembly Emergency Pole Pole 0 Strap, Jumper 65 -Pole, Front Connect 65 -Pole, Front Connect and -Pole, Rear Connect Screw, Cap Hex Head (5/6 x.5) Pole, Front Connect Pole, Front Connect Nut, Hex (/ 0) Pole, Rear Connect Pole, Rear Connect Nut, Hex (5/6 8) Pole, Front Connect Pole, Front Connect 06 8 Bar, Interlock Arm, Interlock Screw, Cross-Recessed Round Head W/IT (#8 x.50) Lug, Solderless 08 50/5 Amp Front Connect 0 60 Amp Front Connect 8 Block and Cross Bar Assembly Normal Pole Pole 06 6 Plate, Handle Mounting Handle, Actuator (See Separate Page For Components) Washer, Flat (5/6) -Pole, Front Connect Washer, Lock W/ET (5/6) -Pole, Front Connect 05 Standoff, Insulator -Pole, Front Connect 0 0 Strap, Load Front Connect Strap, Load Front Connect Strap, Load Front Connect 8 Harness, Wiring 8 66 Bar, Neutral (-Pole, Front Connect) 5 Clamp, Cable 50 Actuator, Linear VAC VAC /0/0/600* VAC /6 VAC /80 VAC 5 Breaker, Circuit VAC /08/0/0/600* VAC /6/0/80 VAC 5 Capacitor 00 0 VAC 00 0/08/0/0/600* VAC 00 80/6/0/80 VAC 5 Screw, Cap Hex Head (5/6 8 x.00) Pole, Front Connect Pole, Rear Connect Chute, Arc -Pole Screw, Pan Head Thread Cutting (#0 x.50) -Pole Cover, Arc Chute -Pole Insulator, Arc Chute -Pole Spacer, Mounting Block -Pole Block and Contact Assembly -Pole Support, Channel Rear Connect 6 Bus, Load 0 -Pole, Rear Connect 0 -Pole, Rear Connect 6 Bus, Normal and Emergency 0 6 -Pole, Rear Connect 0 8 -Pole, Rear Connect 6 Screw, Cap Hex Head (/ 0 x.00) Pole, Rear Connect Pole, Rear Connect 6 Washer, Spring Conical (/) Pole, Rear Connect Pole, Rear Connect 65 Screw, Hex Washer Head Thread Forming (/ 0) Pole, Rear Connect Pole, Rear Connect 06 5 Block, Lug Mounting Front Connect (Not Illustrated) Screw, Machine Round Head (/ 0 x.5) (Not Illustrated) Pole, Front Connect Pole, Front Connect Pole, Rear Connect Screw, Thread Forming (/ 0 x.50) -Pole, Front Connect (Not Illustrated) Screw, Thread Forming (/ 0 x.6) -Pole, Front Connect (Not Illustrated) * Switch is actually 08 volts A large transformer in the system reduces the 600 volt system voltage down to 08 volts.

12 Actuator Handle Assembly Handle Assembly, Actuator 06 8 Handle, Switch Left Hand 06 8 Handle, Switch Right Hand 85 0 Screw, Machine Round Head Cross Recessed (#8 x -/) 85 0 Screw, Machine Round Head Cross Recessed (#0 x -/) Nut, Self-Locking (#8 ) Nut, Self-Locking (#0 ) 0

13 Auxiliary Switch Assembly 5 06 Switch Assembly, Auxiliary 06 0 Bracket, Switch Auxiliary 06 5 Barrier, Switch Screw, Cap Hex Head (#6 x -/) Nut, Lock (#6 ) Switch, Snap-Action

14 Cabinet Type

15 Cabinet Type Door, Cabinet /5 Amp Amp Cabinet /5 Amp Amp Harness, Main Level Control All Except 600 VAC VAC Level Control All Except 600 VAC VAC Generator to Generator Applications All Except 600 VAC VAC Module, Digital Display 5 Board, Printed Circuit Power Module Level Control VAC /0/0/0/80 VAC VAC /80/6 VAC Level Control VAC /0/0/0/80 VAC VAC /80/6 VAC Board, Printed Circuit Bar Graph Screw, Pan Head (M x 8) Transformer, Power (600 VAC Only) Screw, Hex Washer Head Thread Forming (/ 0 x.50) Edge, Protection Washer, Lock W/ET (M5) /5 Amp Amp Screw, Cap Hex Head (M5 x 8) /5 Amp Amp 80 6 Standoff, Male Snap 06 5 Cover, Printed Circuit Board 5 Membrane, Panel Level Control Without Digital Display With Digital Display Level Control Without Meters Bar Graph Display 00 5 With Meters Bar Graph Display 6 6 Lug, Solderless (/ ) Edge, Protection 8 Block, Hinge /5 Amp Amp 5 05 Plug, Hole Handle, Locking (Includes Hardware and Keys) Latch, Cam /5 Amp ( Point) Amp ( Point) 5 0 Plug, Hole 06 Rod, Roller (60 Amp) 80 0 Nut, Self-Locking (/ 0) Screw, Cap Hex Head (/ 0 x.50) 6 Lead (Quantity Used as Required) Board, Printed Circuit Digital Level Control Level Control Guide, Rod (60 Amp)

16 Cabinet Type R and

17 Cabinet Type R and Door, Cabinet /5 Amp Amp Cabinet Type R Cabinet /5 Amp Amp Type Cabinet /5 Amp Amp Harness, Main Level Control All Except 600 VAC VAC Level Control All Except 600 VAC VAC Generator to Generator Applications All Except 600 VAC VAC Module, Digital Display 5 Board, Printed Circuit Power Module Level Control VAC /0/0/0/80 VAC VAC /80/6 VAC Level Control VAC /0/0/0/80 VAC VAC /80/6 VAC Board, Printed Circuit Bar Graph Screw, Pan Head (M x 8) Transformer, Power (600 VAC Only) Nut, Hex W/ET (0 ) Standoff, Male Snap 06 5 Cover, Printed Circuit Board Membrane, Panel Level Control 00 5 Without Digital Display 00 5 With Digital Display Level Control 00 5 Without Meters Bar Graph Display 00 5 With Meters Bar Graph Display 6 Lug, Solderless (/ ) Plug, Hole Handle, Door (Includes Key) Key, Replacement Latch, Cam ( Point) 8 Rod, Roller /5 Amp Amp Nut, Self-Locking (/ 0) 0 Lead (Quantity Used as Required) Board, Printed Circuit Digital Level Control Level Control Washer, Rubber Gasket, Door /5 Amp Amp Gasket, Door /5 Amp Amp Guide, Rod 5

18 Cabinet Type

19 Cabinet Type Door, Cabinet /5 Amp Amp Cabinet /5 Amp Amp Harness, Main Level Control All Except 600 VAC VAC Level Control All Except 600 VAC VAC Generator to Generator Applications All Except 600 VAC VAC Module, Digital Display 5 Board, Printed Circuit Power Module Level Control VAC /0/0/0/80 VAC VAC /80/6 VAC Level Control VAC /0/0/0/80 VAC VAC /80/6 VAC Board, Printed Circuit Bar Graph Screw, Pan Head (M x 8) Transformer, Power (600 VAC Only) Nut, Hex W/ET (0 ) Standoff, Male Snap 06 5 Cover, Printed Circuit Board Membrane, Panel Level Control 00 5 Without Digital Display 00 5 With Digital Display Level Control 00 5 Without Meters Bar Graph Display 00 5 With Meters Bar Graph Display 6 Lug, Solderless (/ ) Plug, Hole Nut, Self-Locking (/ 0) 6 Lead (Quantity Used as Required) Board, Printed Circuit Digital Level Control Level Control Washer, Rubber Gasket, Door /5 Amp Amp 0 Gasket, Door /5 Amp Amp 8 0 Screw, Round Head (5/6 8 x.5) Washer, Flat (5/6) 0 6 Bracket, Door Spring, Conical

20 Accessory Control Plate (Less than 600 Volt) CP0 0 0 Plate, Relay 0 Bracket, Connector 0 Relay PDT Switch, Toggle Screw, Phillips/Hex Head GND (M x 0) Screw, Pan Head Crossed Recessed (M x 8) Screw, Pan Head Crossed Recessed (M x ) 8 0 Cover, Relay Plate 8

21 Accessory Control Plate (600 Volt) R0 0 0 Plate, Relay 0 Bracket, Connector 0 Relay PDT Switch, Toggle Screw, Phillips/Hex Head GND (M x 0) Screw, Pan Head Crossed Recessed (M x 8) Screw, Pan Head Crossed Recessed (M x ) 8 0 Cover, Relay Plate 0 Relay, Control Screw, Pan Head Cross Recessed (M x )

22 Plate and Wiring Harness (Open Construction) B00, N0 0 0 Plate, Open Construction Plug, Hole Harness, Control (Optional) 8 With Pin Connector (Includes Parts Marked *) 8 0 With 5 Pin Connector (Includes Parts Marked #) * Plug, Connector ( Pin) (P) 5 5 * Cap, Connector ( Pin) (J) 6 *# Socket, Contact 00 8 Wiring Harness Wiring Harness *# Pin, Contact 8 Wiring Harness Wiring Harness 8 5 # Plug, Connector (5 Pin) (P) 5 # Cap, Connector (5 Pin) (J) * Parts Included in 8 Wiring Harness # Parts Included in 8 0 Wiring Harness 0

23 Wiring Harness Battery Charger (Generator Set to Generator Set) A0 8 0 Rail, Terminal Plate, Mounting 0 8 Relay, Control ( VDC) 88 Bracket, End Screw, Phillips/Hex Head GND (M x 0) 6 0 Mount, Cable Tie 80 0 Nut, Self-Locking (/ 0) Screw, Cap Hex Head (/ 0 x.5) 8 86 Harness, Battery Charger (Includes Parts Marked *) 0 00 * Socket, Contact 606 * Socket, Contact * Pin, Contact 0 * Pin, Contact * Parts Included in 8 86 Wiring Harness

24 Battery Charger Alarm N Rail, Terminal Block Plate, Mounting 86 0 Block, Terminal (Sectional) 8 Bracket, End Terminal 5 8 Plate, End Terminal Screw, Phillips/Hex Head GND (M x 0) 0 Mount, Cable Tie Nut, Self-Locking (/ 0) Screw, Cap Hex Head (/ 0 x.5) Harness, Alarm (Includes Parts Marked *) 0 * Pin, Contact (J) 0 * Housing, Connector (0 Pin) (J) * Parts Included in 8 Wiring Harness

25 Battery Charger Amp, / Volt Wrapper, Charger Battery 0 Cover, Charger Battery Ammeter, DC Screw, Machine Locking Head Slotted (#0 x 5/6) 5 05 Holder, Fuse 6 05 Fuse, Amp 00 6 Board, Printed Circuit 8 Transformer Volt /0/80 Volt /6 Volt Volt 0 00 Resistor, Fixed Resistor, Fixed Washer, Centering (/ ) 8 06 Screw, Machine Round Head (#0 x 6-/) 8 0 Screw, Machine Round Head (#0 x -/) 80 0 Nut, Hex W/ET (#0 ) Screw, Pan Head W/ET (#6 x /8) 6 8 Harness, Wiring (Includes Parts Marked #) 8 *Cap, 6 pin (J6) 8 *Plug, pin (P) A/R *Pin, Terminal 0 00 A/R *Socket, Terminal Nut, Hex W/ET (M5) * Parts Included in 8 Wiring Harness

26 Battery Charger 0 Amp, Volt

27 Battery Charger 0 Amp, Volt 00 Wrapper, Charger Battery 00 Cover, Charger Battery 0 8 Ammeter, DC 0 Holder, Fuse (AC Input) 5 00 Holder, Fuse (DC Output) 6 Fuse 50 Hertz /0 Volt Volt Volt Volt 60 Hertz Volt Volt Volt Volt Volt Volt 0 Fuse (5 Amp) 8 Transformer 50 Hertz Volt /6/0 Volt Volt 60 Hertz /08/0 Volt Volt Volt Volt PCB, Charger Battery Rectifier, Bridge Screw, Machine Locking Head (#0 x 5/6) Screw, Pan Head W/ET (#6 x /8) Rectifier Assembly SCR ( Volt) (Includes Parts Marked *) Screw, Pan Head W/ET (#8 x 5/8) Nut, Hex W/ET (#8 ) *Nut, Insulated (#8) 8 Harness, Battery Charger (Includes Parts Marked #) 8 00 A/R #Socket, Terminal 0 A/R #Pin, Terminal 0 8 #Cap, 6 pin 05 #Plug, 5 pin *Rectifier, Gate (SCR) *Screw, Sheet Metal Round Head (#8 x /) Lead (Quantity Used as Required) Nut, Hex W/ET (M5) # Parts Included in 8 Wiring Harness * Parts Included in Rectifier Assembly 5

28 Battery Charger 0 Amp, Volt

29 Battery Charger 0 Amp, Volt 00 Wrapper, Charger Battery 00 Cover, Charger Battery (Includes Silkscreen) 0 8 Ammeter, DC 0 Holder, Fuse (AC Input) 5 00 Holder, Fuse (DC Output) 6 Fuse 50 Hertz /6/0 Volt Volt Volt 60 Hertz Volt Volt Volt Volt /08 Volt 0 Fuse (5 Amp) 8 Transformer 50 Hertz /6/0 Volt Volt Volt 60 Hertz /08/0 Volt Volt Volt Volt 00 PCB, Charger Battery Rectifier, Bridge Screw, Machine Locking Head (#0 x 5/6) Screw, Pan Head W/ET (#6 x /8) Rectifier Assembly SCR ( Volt) (Includes Parts Marked *) Screw, Pan Head W/ET (#8 x 5/8) Nut, Hex W/ET (#8 ) *Nut, Insulated (#8) 8 Harness, Battery Charger (Includes Parts Marked #) 8 00 A/R #Socket, Terminal 0 A/R #Pin, Terminal 0 8 #Cap, 6 pin 05 #Plug, 5 pin *Rectifier, Gate (SCR) *Screw, Sheet Metal Round Head (#8 x /) Lead (Quantity Used as Required) Nut, Hex W/ET (M5) # Parts Included in 8 Wiring Harness * Parts Included in Rectifier Assembly

30 Network Module M Board, Printed Circuit Network Module 8 0 Rail, Terminal Block 86 0 Block, Terminal (Sectional) 8 Bracket, End Terminal 5 8 Plate, End Terminal Screw, Pan Head (M x 0.5 x 8) 80 0 Standoff, Hex Thread (M) Screw, Phillips/Hex Head GND (M x 0) Harness, Network 0 Battery Lithium (.0V) (Purchase Locally) 6 0 Clip, Battery 8

31 Current Transformer Module M Board, Printed Circuit Current Module Screw, Pan Head (M x 8) Harness, Current Module (Includes Parts Marked *) * Connector, Receptacle (0 Pin) * Socket, Contact 6 Lead (Marked J0, GND) 6 0 (No Markings) 0 Mount, Cable Tie 8 Plate, Mounting 80 0 Nut, Self-Locking (/ 0) Screw, Cap Hex Head (/ 0 x.5) Transformer, Current 50 Amp VAC 0 8 Phase, or Wire 0 8 Phase, or Wire 5 Amp VAC 0 00 Phase, or Wire 0 00 Phase, or Wire 60 Amp 0 0 VAC 0 Phase, or Wire 0 Phase, or Wire * Parts Included in Wiring Harness

32 Terminal Block A0,K00,K00,K Rail, Terminal Block 86 0 Block, Terminal (Sectional) 8 Bracket, End Terminal 8 Plate, End Terminal 0

33 Auxiliary Relay L0,0,0,0,0,0,0,0 8 0 Rail, Terminal Relay, Control 0 8 VDC 0 8 VDC 88 Bracket, End Screw, Phillips/Hex Head GND (M x 0)

34 Load Shed M00,R0 Harness, Load Shed All Except 600 Volt Volt 0 Relay PDT ( VDC) 0 Mount, Cable Tie Screw, Pan Head (M x 8) Board, Printed Circuit Relay Module Screw, Pan Head (M x 8) Plate, Mounting Nut, Self-Locking (/ 0) Screw, Cap Hex Head (/ 0 x.5)

35 Front Panel Security M Switch, Selector Lead 6 0 (Marked S0 J 5) (Marked S0 J )

36 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 6 80, , 5, , , ,, 5, 05 08, 5, , , ,, 5,, 5, 6 0, 6 0, 6 0, 6 0, 00 6, 00 60, 5 00, 00 56,, 5, ,, 5, ,, 5, ,, 5, ,, 5, ,, 5, ,, 5, ,, 5, ,, 5, ,, 5, 00 55,, 5, 00 55, 00 55, ,, 5, , , 00 55, 00 5, 00 5, 5, 00 5, 5, 00 5, 5, 0 6, 0 0, 0, 0 00, 0 080, 0, 0 8, 0 8, 5, 0 005, 0 00, 0 0, , , 06 8, , , 06 8,, , 06 5, 06, , 06,, 06 8, 06 0, 06 6,, , 06 0, 06 0, 06 05, 06 06, 06, 06 8, 06 8, 06 55, , , , 06 5, 06 55, 06 56, 06 58, 06 60, 06 6, 06, , , , , 06 6, , , , , , , , , 06 0, 06 0, 06 0, 06 0, , , , , , , , , , 06 05, 06 05, 06 05, , , , , , , , , , , , 06 06, 06 06, 06 06, 06 06, , , , , , , , 06 0, 06 0, 06 0, , 06 5,, 5, 0 8,, 0 8, 0, 8,, 0, , 8, 08 0, 0 0, 00, 00, 00, , , , , 5 066,, 5, 5 000, , 5 00, , 5 00, , 5 006, , 5 008, , 5 00, 5 5 0, 5 0, 5 5 0, 00, 5, 00, 5,

37 Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 86 0, 8,, 5, ,, 5, 85 05, 865 0, 05, 5, ,, 5, 85 05, 5, 86 0, 5 0, , , 86 0, 5 0, , , 868 0, , , , 80 0, 0,,,, 8 886, , 8 0, 5, 6 000, 5, , 8 0, 605, 06 05, , 8,, 85 0, 05, 06 06, ,, 5, 8 0, 5 8, 06 06, , 0 8 0, , , 85 0, , , 88 0, 0 0, 8, 0, 8, 0, 8,,,,, 0 0, , , 0 060, 00, 5, 0, 5, 05, 05, 0, 5, 00 0, 5, 00 0, , , 5, 00 0, 5, 00 05, 5, 00 06,, 0,, 00, 0,,, 5, 5, 0 5, 0, 0,, 5,, ,, 0 8 0,, 8, 0 8,, 8, 0 8,, 8, 0 88,, 8 0, 8 0, 0, 08, 0, 606,, 6,, 5, 65, 66, 0, 0, 0 0, 0 0, 0 0,, 8, 8, 0 8 0, 0 8, 5, 8 50, 8, 8 86, ,, 5, ,, 5, ,, 5, , 06 0, 06 0, 6 0, , 5, , 508, 5 05, 5 0, 5 066, 5,, , , 56 00, 56 00, ,, ,,,, , , , , , , , , 5, 8 0, 8 0, 8 06, 85 00, 85 06,, 85 00, , 8,,,, 8, , ,, 5,, 8,, , 8, 8 000,, 5, , 85 00, , , , , , ,, 5, 80 0,, 5,, 80 00, 80 0,, 5,,,,, 80 0, 5, 80 05, , 5, 80 08, 80 08, , 80 0, ,, 5, , 5, , 5, , 5, , 5, 5, ,, 5, 85 06, 5

38 Cummins Power Generation 00 rd Avenue N.E. Minneapolis, MN International Use Fax: Cummins is a registered trademark of Cummins Inc.