XTREME ICE MAKER (1230 SERIES)

Transcription

1 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) MODEL NO Distributed By: Commercial Refrigeration Service, Inc. () - () - XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

2 Part # Corrections/Update Document Unit Type/Model # Manual # XTREME 0 00 Page Old Part Desc. New Part Desc. Agent Date Notes - Kit Service front 00 Water & Remote KC //0 Omitted from manual Panel Asy units only 0- Fig Cover Front x 000 Water and Remote KC //0 Omitted from manual 0 units 0- Fig Rail Front Panel 000 Water and Remote KC //0 Omitted from manual Left Units 0- Fig Rail Front Panel 0000 Water and Remote KC //0 Omitted from manual Right Units 0- Screw -0 FLPH 000 For front Cover KC //0 Omitted from manual SS Asy Kit Evap Cvr Med KC //0 Omitted from manual Expansion Valve KC //0 Omitted from manual Distributed By: Commercial Refrigeration Service, Inc. () - () -

3 Turbo Tech Water Condenser The Turbo Tech water condenser differs from the earlier style of coil and cannot be interchanged with previous revision water coils. If your coil differs from this, see page -. The keys to telling them apart are as follows:. Two identical vertical brackets support the T.T. water coil. Part number for the brackets is 00 if.0 tall or 00 if ½ inches tall.. The T.T. water coil has refrigeration lines that turn 0 degrees and are parallel to the water connections. Part number is 00.. The base used with the T.T. water coil requires a different mounting hole pattern than the older revisions. The part number is 00. Distributed By: Commercial Refrigeration Service, Inc. () - () -

4 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) FIGURE. GENERAL ASSEMBLY (AIR CONDENSER SHOWN) 00 Screw TC - HXWS Screw TC - HXWS 0 (Marine) 0000 Grommet Nut 00 Grille 0000 Grille (Marine) 00 Front Panel Ass y (See Figure ) 0 Panel Fnt (Marine) (See Figure ) 000 Cover, Electrical Box 00 Cover, Electrical Box (Marine) 0000 Screw TR 0- PAPH 00 Screw MA 0- HX (Marine) 000 Cover, Top Cover, Top (Marine) 000 Splash Panel XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

5 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) 0 SEE DETAIL B 0 SEE DETAIL A DETAIL B DETAIL A FIGURE. TRIM ASSEMBLY (AIR CONDENSER SHOWN) 0 Thread Cutting Screw, Phil Truss Hd, No. - By /-In. Long 000 Brace, Electrical Box Electrical Box Ass y (See Figure ) 000 Sheet Metal Screw, No. By /-In. Long 00 Panel, Side 000 Washer,.0 I.D. 000 Switch, On/Off 000 Switch, Proximity 000 Cover, Evaporator, Large Fitting, Placeholder 000 Water Distributor Ass y (See Figure ) 000 Spacer, Brace, Electrical Box 000 Screw 00 Recess Panel 00 Grommet 00 Fitting 000 Tube, Vynl Mold 000 Bracket, Vynl Tube 00 Screw 0 00 Clip XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

6 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) SEE DETAIL A DETAIL A FIGURE. BUILD ASSEMBLY (AIR CONDENSER) 00 Wrap, Cabinet 000 Sheet Metal Screw, No. By / Tube,. I.D. (Not Shown) 000 Flange, Bulkhead 000 Fitting, Bulkhead 000 Flange, Bulkhead Condenser Ass y (See Figure ) 000 Pressure Sensor Ass y Water Pump Ass y (See Figure 0) Hex Nut, No Pan, Water Wrap 0 Kit Compressor, 0V 0HZ 00 Kit Compressor, 0V 0HZ 000 Hex Nut, /- 00 Washer,. I.D. 00 Sleeve and Grommet 000 Solenoid Valve 000 Brace, Bulkhead 0000 Tube,. I.D. (Not Shown) Bulkhead Ass y (See Figure ) Screw, SM PHTR 00 Dump Valve 00 Bracket, Water Pan 0000 Base 00 Bracket (Not Shown) 000 Clip 0000 Tube, Vynl 00 Sensor Temp (Not Shown) 00 Clamp, Screw 0000 Service Valve and Bracket Ass y (Not Shown) 0 00 Dryer 00 Expansion Valve 00 Hot Gas Valve 000 Water Pan XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

7 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) SEE DETAIL B DETAIL B 0 0 SEE DETAIL A 0 0 DETAIL A 000 Wrap, Cabinet 000 Sheet Metal Screw, No. By /-In. Long Tube,. I.D. (Not Shown) 000 Flange, Bulkhead 000 Fitting, Bulkhead 000 Flange, Bulkhead 000 Panel, Back 000 Pressure Sensor Ass y Water Pump Ass y (See Figure 0) Hex Nut, No Pan, Water, Wrap 00 Compressor, 0V 0HZ 000 Hex Nut, /- 00 Washer,. I.D. 000 Sleeve, Grommet 000 Grommet 000 Solenoid Valve 000 Brace, Bulkhead 000 Receiver 0 Bulkhead Ass y (See Figure ) FIGURE. BUILD ASSEMBLY (REMOTE) 000 Sheet Metal Screw, Phil Truss Hd, No. By /-In. Long 00 Dump Valve 000 Bracket, Water Pan 0000 Base 0 Mounting Plate, Receiver 00 Washer 0 Hex Nut 00 Bracket (Not Shown) 0 Bracket, Receiver Top Water Pan 0000 Tube, Vynl Button Plug 00 Clamp 0000 Service Valve and Bracket Ass y 00 Dryer 000 Screw 000 Expansion Valve 00 Hot Gas Valve 00 Switch Ass y 0 0 Solenoid Valve XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

8 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) SEE DETAIL B DETAIL B SEE DETAIL A DETAIL A 000 Wrap, Cabinet 000 Screw SM HX Screw TC - HXWS 0 (Marine) Tube,. I.D. 000 Flange, Bulkhead 000 Fitting, Bulkhead 000 Flange, Bulkhead 000 Panel, Back 0000 Panel, Back (Marine) 000 Pressure Sensor Ass y Water Pump Ass y (See Figure 0) Hex Nut, No Pan, Water, Wrap 00 Compressor, 0V 0HZ 000 Hex Nut, /- 000 Hex Nut, /- (Marine) 00 Washer,. I.D. 00 Washer Ft. I.D. (Marine) 000 Sleeve, Grommet 000 Grommet 000 Solenoid Valve FIGURE. BUILD ASSEMBLY (WATER COOLED) 000 Brace, Bulkhead Water Coil Ass y 0 Bulkhead Ass y (See Figure ) 000 Sheet Metal Screw, Phil Truss Hd, No. By /-In. Long 00 Dump Valve 00 Bracket, Water Pan 0000 Base 00 Tube Ass y 0 Tube Ass y, Water Inlet 00 Tube Ass y, Water Outlet 00 Bracket (Not Shown) Button Plug Tube, Vynl 00 Clamp 00 Washer 000 Valve, Water Regulator 000 Washer 00 Clamp, Water Coil 000 Water Pan XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

9 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) Clip Panel, Bulkhead Left Panel, Bulkhead, Right 000 Bulkhead, Rear 000 Sheet Metal Screw, Phil Truss Hd, No. By /-In. Long 000 Pan, Water, Large, Right 000 Pan, Water, Large, Left 000 Plug 000 Frame, Evaporator, Left 000 Frame, Evaporator, Right 000 Deflector, Water 000 Gasket, Frame, Top and Bottom Kit Service Evap Frame Left (Standard Cube) Kit Service Evap Frame Right (Standard Cube) FIGURE. BULKHEAD ASSEMBLY Kit Service Evap Frame Left (Large) Kit Service Evap Frame Right (Large) 000 Gasket, Side, Left 0000 Gasket, Side, Right 000 Hex Nut, No Frame, Evaporator, Bottom 000 Sheet Metal Screw, Hex Hd, No. by / (Not Shown) 0000 Evaporator Line, Upper, Left 000 Evaporator Line, Upper, Right 0000 Evaporator Line, Lower, Left 000 Evaporator Line, Lower, Right 000 Nut 00 Bracket, Evaporator Frame Support 000 Screw XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

10 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) Condenser Coil FIGURE. CONDENSER ASSEMBLY Washer,.0 I.D. 00 Shroud, Condenser 0000 Sheet Metal Screw, Phil Pan Hd, No. By /-In. Long 000 Well Nut, / Fan Blade 000 Bracket, Motor 000 Machine Screw, Hex Hd, /-0 By -In. Long 0 Motor Cond 0V 0HZ 0000 Motor Cond 0V 0HZ 0 0 Machine Screw, Hex Hd, No. - By /-In. Long XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

11 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) 0 FIGURE. ELECTRICAL BOX ASSEMBLY 000 Control Board 0 Thread Cutting Screw, Phil Truss Hd, No. - By /-In. Long 0 Relay, 0/0V 0/0HZ 000 Spacer, Control Board 00 Relay, Start 0V 0HZ 0 Relay, Start (Air) 000 Relay, Start (Remote and Water) 00 Terminal Block 0000 Switch 000 Strap, Capacitor 00 Capacitor, Run 0V 0/0HZ (Air) 000 Capacitor, Run (Remote and Water) 0 0 Capacitor, Start (Air) 000 Capacitor, Start (Remote and Water) 0 Capacitor, Start 0V 0HZ 0 Bushing 000 Wrap, Electrical Box 00 Wrap, Electrical Box (Marine) XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

12 Anoka, MN. 0 Telephone Facsimile Plug 0000 Distributor, Water, Inner 0000 O-Ring,.0 I.D. XTREME ICE MAKER (0 SERIES) 000 Distributor, Water, Inner, Barb 000 Distributor Ass y, Water 000 Tube, Pump to Dump Valve FIGURE. WATER DISTRIBUTOR ASSEMBLY 000 Pump, Water, 0V 0/0HZ 0000 Tube, Pump to Distributor 00 Clamp FIGURE 0. WATER PUMP ASSEMBLY 0000 Cover, Front Air cooled " x 0" 000 Cap, Front Panel 0" 000 Rail, Front Panel, Left " 000 Rail, Front Panel, Right " FIGURE. FRONT PANEL ASSEMBLY AIR COOLED XTREME ICE (0) 0 of Manual Part No Rev; IMI Cornelius Co., 00 0

13 Anoka, MN. 0 Telephone Facsimile XTREME ICE MAKER (0 SERIES) ACCESSORIES/KITS Distributed By: Commercial Refrigeration Service, Inc. () - () - XTREME ICE (0) of Manual Part No Rev; IMI Cornelius Co., 00 0

14