Easy! Smooth! PS-4800 PS-5800W/PS-5700T Replacement Guidebook 1 2nd Edition Mar. 2017 Copyright 2012.9 Digital Electronics Corporation. All Rights Reserved.
Introduction This document introduces the procedures and notes for replacing the PS-4800 with the PS-5800W/PS-5700T. The recommended substitute model is listed below. Equipment in use PS-4800 *1 (Core TM 2Duo model) Model code:pfxpp18********n00 PS-4800 *1 (Atom N270 model) Model code:pfxpp18********n00 Equipment in use PS-4800 *1 (Core TM 2Duo model) Model code:pfxpp18********n00 PS-4800 *1 (Atom N270 model) Model code:pfxpp18********n00 *1 Sales terminate as of March 2017 Recommended substitute model PS-5800W (0/2slot, Core i7 TM model) Model code:pfxpp2lj*******n00 PFXPP2LU*******N00 PFXPP2LW*******N00 PFXPP2LX*******N00 PS-5800W (0/, Celeron model) Model code:pfxpu2lc*******n00 PFXPU2LD*******N00 PFXPU2LQ*******N00 PFXPU2LR*******N00 Recommended substitute model PS-5700T (0/2 スロット Core i7 TM model) Model code:pfxpp27j*******n00 PFXPP27U*******N00 PFXPP27W*******N00 PFXPP27X*******N00 PS-5700T (0/2 スロット Celeron model) Model code:pfxpu27c*******n00 PFXPU27D*******N00 PFXPU27Q*******N00 PFXPU27R*******N00 Safety Information HAZARD OF OPERATOR INJURY, OR UNINTENDED EQUIPMENT DAMAGE Before operating any of these products, be sure to read all related manuals thoroughly. Failure to follow these instructions can result in death, serious injury or unintended equipment damage. Registered trademarks Microsoft and Windows are registered trademarks of Microsoft corporation in the United States and/or other countries. Intel, Celeron,Atom,Core2 Duo and Core i3/7 are registered trademarks of Intel corporation. Product names used in this manual may be the registered trademarks owned by the respective proprietors. 2
Interpreting the PS-5000 Series Model Code A portion of the PS-5000 Series model code differs according to the specification. When purchasing the PS-5000 Series, carefully check the model code to order before making your purchase. P F X P * 2 * * * * * * * * * N 0 0 5 7 8 9 10 11 12 13 14 15 * The gray-shaded cells in the table cannot be selected with the models (PS-4000B) introduced in this document. Character number 5 7 8 9 10 11 12 13 14 15 Base unit Modular PC Celeron U Modular PC Core i7 P Modular panel None B type Modular panel 15" 7 Modular panel W15 J Modular panel W19 L Modular panel W22 N Box type Box Celeron 4 GB-RAM C Box Celeron 8 GB-RAM D Box Celeron 4 GB-RAM 1 x PCI + 1 x PCIe E Box Core i7 8 GB-RAM J Box Core i7 8 GB-RAM 1 x PCI + 1 x PCIe K Box Celeron 8 GB-RAM 1 x PCI + 1 x PCIe P Box Celeron 4 GB-RAM, 2 x PCI Q Box Celeron 8 GB-RAM, 2 x PCI R Box Celeron 4 GB-RAM, 2 x PCIe S Box Celeron 8 GB-RAM, 2 x PCIe T Box Core i7 16 GB-RAM U Box Core i7 16 GB-RAM 1 x PCI + 1 x PCIe V Box Core i7 8 GB-RAM, 2 x PCI W Box Core i7 16 GB-RAM, 2 x PCI X Box Core i7 8 GB-RAM, 2 x PCIe Y Box Core i7 16 GB-RAM, 2 x PCIe Z Box Core i7 16 GB-RAM, conformal coating A Box Core i7 16 GB-RAM, conformal coating 1 x PCI + 1 x PCIe L CPU type Celeron-2980U C Core i7-4650u 7 Celeron-2980U with fan for expansion card above 3 W F Core i7-4650u with fan for expansion card above 3W W Power supply DC D AC A 3
Character number 5 7 8 9 10 11 12 13 14 15 RAM sizes 4 GB 4 8 GB 8 16GB A Operating None 0 system Windows Embedded Standard 7 (WES7P) SP1 64 bits MUI 4 Windows 7 Ultimate SP1 64 bits MUI 6 Windows Embedded 8.1 Industry 64 bits MUI 8 Storage device None N CFast 16 GB A CFast 32 GB X HDD 500 GB J HDD 1 TB K SSD 80 GB L SSD 160 GB M SSD 240 GB P Options None 0 Interface 2 x RS 422/485 isolated 2 Interface 4 x RS 422/485 3 Interface 2 x USB 3.0 4 Interface 2 x RS 232 isolated 5 Interface 4 x RS 232 6 Interface 2 x Ethernet Gigabit PoE LAN 7 Interface 16 x DI / 8 x DO 8 Interface audio C Cellular module D Interface 2 x CANopen G Interface 1 x Profibus DP with NVRAM J Interface 1 x Ethernet Gigabit IEEE1588 LAN K Second storage None N CFast 16 GB A CFast 32 GB X HDD 500 GB J HDD 1 TB K SSD 80 GB L SSD 160 GB M SSD 240 GB P 4
Contents Introduction 2 Interpreting the PS-5000 Series Model Code 3 Contents 5 Chapter 1. Specification Comparison 7 1.1 PS-4800 and PS-5800W(0/) specification comparison 7 1.2 PS-4800 and PS-5700T(0/) specification comparison 10 Chapter 2. Hardware Compatibility 13 2.1 Differences in function locations 13 2.2 Touch Panel 17 2.3 Main memory 17 2.4 Installation 17 2.5 Battery backup UPS 18 2.6 Serial Interface 18 2.7 USB Interface 18 2.8 PCI Slot 18 2.9 Power supply plug 18 2.10 Power consumption 18 Chapter 3. Compatibility with Accessories 19 3.1 Individual accessories 19 3.2 Maintenance accessories 20 Chapter 4. Software Compatibility 21 5
4.1 Supported operating systems and operating system languages 21 4.2 Supported software 22 4.3 Functions supported by System Monitor 23 Chapter 5. Appendix 24 5.1 Uninterruptible power supply (UPS) 24 5.1.1 Overview 24 5.1.2 Specifications 24 5.1.3 Dimensions 25 5.2 Exclusive BTO (build to order) options 26 6
Chapter 1. Specification Comparison 1.1 PS-4800 and PS-5800W(0/) specification comparison Display specifications PS-4800 PS-5800W(0/) Display device TFT color LCD (19-inch) TFT color LCD (18.5-inch) Graphics SXGA(1,280 1,024 pixels) FWXGA(1,366 768 pixels) Display colors/gradation Backlight Brightness adjustment Display device lifespan Backlight lifespan Touch panel 16 million colors 16.7 million colors LED backlight (not user replaceable, send-back type) Step-less adjustment 50,000 hours 50,000 hours or more Type Analog resistive UP! Projected capacitive Resolution 4,096 4,096 CPU Performance specifications PS-4800 Core TM 2 Duo P8400 (2.26GHz) Atom TM N270 (1.6GHz) PS-5800W(0/) UP! Intel Celeron 2980U 1.6 GHz UP! Intel Core i7-4650u 1.7 GHz Cache memory 512KB 3MB 2MB 4MB (3GB s(8 GB UP! 2 スロット (16GB max) max) max) Main memory (DDR3 1,600MHz) (DDR2 (DDR3 Unable to be added See 2.3 533MHz) 1,066MHz) Chipset 945GME GM45 Lynx Point-LP Graphics controller Video memory Video output Analog Digital Intel Graphics Media Accelerator 950 224MB (Allocated from main memory) Intel Graphics Media Accelerator (GMA) 4500MHD 384MB (Allocated from main memory) QXGA(2,048 1,536 pixels) or lower FHD(1,920 1,080 pixels) or lower Intel HD Graphics Intel HD Graphics 5000 UP! 2GB (Allocated from main memory) - NEW! WUXGA(1,920 1,200 pixels)or lower 7
Panel cut dimensions External dimensions Weight Aluminum front bezel AC power supply General specifications PS-4800 W459.5 H359.5 mm [W18.09 x H14.15 in.] W480 H380 W480 H380 D121 mm D136.2 mm [W18.90 x [W18.90 x H14.96 x D4.76 H14.96 x D5.36 in.] in.] W480 H380 W480 H380 D140 mm D155.2 mm [W18.90 x [W18.90 x H14.96 x D5.51 H14.96 x D6.11 in.] in.] W480 H380 W480 H380 D160 mm D175.2 mm [W18.90 x [W18.90 x H14.96 x D6.30 H14.96 x D6.89 in.] in.] PS-5800W(0/) W479.3 H300.3 mm [W18.87 x H11.82 in.] W488.3 H309 D93.2 mm [W19.22 x H12.17 x D3.67 in.] W488.3 H309 D131.2 mm [W19.22 x H12.17 x D5.17 in.] See 2.4 Front bezel material Aluminum/stainless-steel Magnesium approx. 11.5 kg approx. 12.5 kg [25.4 lbs], [27.6 lbs], approx. 11.6 kg approx. 12.6 kg [25.6 lbs], [27.8 lbs], approx. 12.0 kg approx. 13.0 kg [26.5 lbs], [28.9 lbs], Stainless-steel front bezel DC power supply AC power supply DC power supply approx. 11.0 kg [24.3 lbs] approx. 11.5 kg [25.4 lbs] approx. 12.0 kg [26.5 lbs] approx. 12.8 kg [28.2 lbs], approx. 12.9 kg [28.4 lbs], approx. 13.3kg [29.3 lbs], approx. 12.3 kg [27.1 lbs] approx. 12.8 kg [28.2 lbs] approx. 13.3 kg [29.3 lbs] approx. 11.5 kg [25.4 lbs] approx. 12.0 kg [26.5 lbs] approx. 12.5 kg [27.6 lbs] approx. 13.8 kg [30.4 lbs], approx. 13.9 kg [30.6 lbs], approx. 14.3 kg [31.5 lbs], approx. 12.8 kg [28.2 lbs] approx. 13.3 kg [29.3 lbs] approx. 13.8 kg [30.4 lbs] approx. 8.3 kg [18.3 lbs] approx. 9.1 kg [20.1 lbs] 8
Cooling method Power supply See 2.9 Power consump tion AC power supply DC power supply Battery backup UPS Natural air circulation (Fanless) General specifications PS-4800 Forced air cooling by fan DC power supply: 24 V AC power supply: 100 to 240 V 130 W or lower 43.1 W or lower See 2.10 Optional (DC power supply only) See 2.5 PS-5800W(0/) UP! Natural air circulation (Fanless) See 2.4 DC power supply: 24 V AC power supply: 100 to 240 V(Optional) - 48.1 W or lower See 2.10 Serial (9-pin D-sub plug) Interface specifications PS-4800 PS-5800W(0/) 2 x RS-232C - 1 x RS-232C/422/485 (optional) 1 x RS-232C/422/485 See 2.6 Disk SATA Slide-in Disk:1 x (HDD/SSD) Slide-in Slot: 1 x (HDD/SSD/DVD-RW) UP! Slide-in Disk: 2 x (HDD/SSD) 1 x CFast 1 x msata IDE 1 x CF Card (Type-I 4 GB/8 GB) - USB See 2.7 Ethernet USB2.0 5 UP! USB Type-A 5 (Front: 2.0 x1 Box: 2.0x2 3.0x2) 2 x 10BASE-T/100BASE-TX/1000BASE-T auto switching Sound Line input/line output/mic input - DVI 1 x DVI-I NEW! 1 x Display Port Type A PCI 2slot See 2.8 Expansion Slot - mini PCIe x2 9
1.2 PS-4800 and PS-5700T(0/) specification comparison Display specifications PS-4800 PS-5700T(0/) Display device TFT color LCD (19-inch) TFT color LCD (15-inch) Graphics SXGA(1,280 1,024 pixels) XGA(1,024 768 pixels) Display colors/gradation Backlight Brightness adjustment Display device lifespan Backlight lifespan Touch panel 16 million colors 16.7 million colors LED backlight (not user replaceable, send-back type) Step-less adjustment 50,000 hours 50,000 hours or more Type Analog resistive Resolution 4,096 4,096 2,048 2,048 CPU Performance specifications PS-4800 Core TM 2 Duo P8400 (2.26GHz) Atom TM N270 (1.6GHz) PS-5700T(0/) UP! Intel Celeron 2980U 1.6 GHz UP! Intel Core i7-4650u 1.7 GHz Cache memory 512KB 3MB 2MB 4MB UP! 2 スロット UP! 2 スロット Main memory (8GB max) (16GB max) (3GB s(8 GB (DDR3 (DDR3 max) max) 1,600MHz) 1,600MHz) (DDR2 (DDR3 Unable to be Unable to be 533MHz) 1,066MHz) added added See 2.3 See 2.3 Chipset 945GME GM45 Lynx Point-LP Graphics controller Video memory Video output Analog Digital Intel Graphics Media Accelerator 950 224MB (Allocated from main memory) Intel Graphics Media Accelerator (GMA) 4500MHD 384MB (Allocated from main memory) QXGA(2,048 1,536 pixels) or lower FHD(1,920 1,080 pixels) or lower Intel HD Graphics Intel HD Graphics 5000 UP! 2GB (Allocated from main memory) - NEW! FHD(3,200 2,000 pixels) or lower 10
Panel cut dimensions External dimensions Weight Aluminum front bezel AC power supply General specifications PS-4800 W459.5 H359.5 mm [W18.09 x H14.15 in.] W480 H380 W480 H380 D121 mm D136.2 mm [W18.90 x [W18.90 x H14.96 x D4.76 H14.96 x D5.36 in.] in.] W480 H380 W480 H380 D140 mm D155.2 mm [W18.90 x [W18.90 x H14.96 x D5.51 H14.96 x D6.11 in.] in.] W480 H380 W480 H380 D160 mm D175.2 mm [W18.90 x [W18.90 x H14.96 x D6.30 H14.96 x D6.89 in.] in.] PS-5700T(0/) W383.5 H282.5 mm [W15.10 x H11.12 in.] W390.7 H290 D93.2 mm [W15.38 x H11.42 x D36.7 in.] W390.7 H290 D131.2 mm [W15.38 x H11.42 x D5.17 in.] See 2.4 Front bezel material Aluminum/stainless-steel Aluminum approx. 11.5 kg approx. 12.5 kg [25.4 lbs] [27.6 lbs] approx. 11.6 kg approx. 12.6 kg [25.6 lbs] [27.8 lbs] approx. 12.0 kg approx. 13.0 kg [26.5 lbs] [28.9 lbs] Stainless-steel front bezel DC power supply: AC power supply DC power supply: approx. 11.0 kg [24.3 lbs] approx. 11.5 kg [25.4 lbs] approx. 12.0 kg [26.5 lbs] approx. 12.8 kg [28.2 lbs] approx. 12.9 kg [28.4 lbs] approx. 13.3kg [29.3 lbs] approx. 12.3 kg [27.1 lbs] approx. 12.8 kg [28.2 lbs] approx. 13.3 kg [29.3 lbs] approx. 11.5 kg [25.4 lbs] approx. 12.0 kg [26.5 lbs] approx. 12.5 kg [27.6 lbs] approx. 13.8 kg [30.4 lbs] approx. 13.9 kg [30.6 lbs] approx. 14.3 kg [31.5 lbs] approx. 12.8 kg [28.2 lbs] approx. 13.3 kg [29.3 lbs] approx. 13.8 kg [30.4 lbs] approx. 9.7 kg [21.4 lbs] approx. 10.5 kg [23.1 lbs] 11
Cooling method Power supply See 2.9 Power consump tion AC power supply DC power supply Battery backup UPS Natural air circulation (Fanless) General specifications PS-4800 Forced air cooling by fan DC power supply: 24 V AC power supply: 100 to 240 V 130 W or lower 39.9 W or lower See 2.10 Optional (DC power supply only) See 2.5 PS-5700T(0/) UP! Natural air circulation (Fanless) See 2.4 DC power supply: 24 V AC power supply: 100 to 240 V(Optional) - 44.9W or lower See 2.10 Serial (9-pin D-sub plug) Interface specifications PS-4800 PS-5700T(0/) 2 x RS-232C - 1 x RS-232C/422/485 (optional) 1 x RS-232C/422/485 See 2.6 Disk SATA Slide-in Disk:(HDD/SSD) 1 Slide-in Slot:(HDD/SSD/ DVD-RW) 1 UP! Slide-in Disk:(HDD/SSD) 2 CFast 1 msata x1 IDE 1 x CF Card (Type-I 4 GB/8 GB) - USB See 2.7 Ethernet USB2.0 5 UP! USB Type-A 5 (Front: 2.0 x1 Box: 2.0x2 3.0x2) 2 x 10BASE-T/100BASE-TX/1000BASE-T auto switching Sound Line input/line output/mic input - DVI 1 x DVI-I NEW! 1 x Display Port Type A PCI 2slot See 2.8 Expansion Slot - mini PCIe x2 12
Chapter 2. Hardware Compatibility 2.1 Differences in function locations The locations of the various functions differ on the PS-4800 and the PS-5800/PS-5700 as shown below. PS-4800() and PS-5800W ()/PS-5700T() function locations 13
H K I F B D Y 8 5 6 PS-5800 PS-5800 () (2 スロット ) A T 2 N O P 8 M 3 14
H K I F B D Y 8 5 6 PS-5700 (2 (2 スロット slot) ) - C E A T 2 N O P 8 M 3 15
PS-4800 PS-5800W/PS-5700T A Status LED (power supply) Status LED (power supply) B Status LED (disk access) Status LED (disk access) C - Front cover D Da Power supply Db button Reset button Power supply button E USB I/F (excluding stainless-steel front bezel) USB I/F F - Arm installation hole G Power supply switch - H - SMA connector (WiFi outside antenna) I - SMA connector (WiFi outside antenna) J DVD-RW drive (connected to slide-in slot) - K - SMA connector (GPRS outside antenna) L - - M - Optional I/F cover N 4 x USB I/F O Ethernet interface(lan1) P Ethernet interface(lan2) Q Expansion slot PCI - R COM2 Serial I/F (RS-232C) - S COM1 Serial I/F (RS-232C) - T Serial I/F (RS-232C/422/485, optional) Serial I/F (RS-232C/422/485) U - - V Line input - W Speaker output - X Mic input - Y - CFast Card slot Z Cooling fan - 1 CF Card slot - 2a Power supply connector 2 (AC power supply only) 2b Power supply connector Power supply connector (DC power supply only) 3 Heat sink 4 Backup lithium battery Installing the inside 5 Slide-in Disk(HDD/SSD) Slide-in Disk(HDD/SSD) 6 Slide-in Slot(HDD/SSD/DVD-RW) Slide-in Slot(HDD/SSD) 7 UPS interface board - 8 DVI-I interface Display Port interface 16
2.2 Touch Panel For the PS-5800W, a touch screen using projected capacitive type of technology is used. This screen may run incorrectly depending on an environment in which the screen s surface gets wet. Confirm the following descriptions before use. When conductive substances like water attach to a touch screen, touch control gets disabled to prevent incorrect touch input operation. Touch control gets disabled to prevent incorrect touch input operation. If situations that cause disabled touch control are removed, the touch function will automatically get enabled. The touch panel s firmware is automatically initialized during boot of Windows. Please do not touch the touch screen area while the operating system is starting. The touch panel may be affected by noise of connected devices. Be sure to confirm grounding of utilized devices including this product. 2.3 Main memory The memory in the PS-5000 Serise cannot be upgraded by the customer after it is purchased. The amount of memory selected in the built-in shipping options is the maximum amount of memory. For example, models with a maximum amount of memory of 16 GB in their specification cannot be upgraded with additional memory if they have been purchased with 8 GB specified in the built-in shipping options. Please use caution when ordering. Interpreting the PS-5000 Series Model Code 2.4 Installation PS-5000 Series is smaller than PS-4700, but larger space is required than the values shown below for safe installation with adequate air circulation considered. For PS-5000 Series, if PCI or/and Mini PCIe cards are attached and the following conditions are satisfied, a fan unit needs to be connected. Please take note of it. Conditions: 2 cards are attached.:power consumption of PCI or/and Mini PCIe cards is 3W or more 1 card is attached.:power consumption of a PCI or Mini PCIe card is 10W or more Top/Bottom, Back Left/Right 1 :Intake air 2:Emission 17
2.5 Battery backup UPS By equipping the PS-5000 with a UPS battery unit, power can continue to be supplied even when there is a loss of power due to a power failure and running programs can be correctly terminated by the UPS software. 5.1 Uninterruptible power supply (UPS) 2.6 Serial Interface You can add one port for a serial interface compatible with communication types (RS-232/422/485) as an option item to PS-5000 Series. To add it, select a number between 2 and 6, inclusive for the 14 th digit of model code. To add it after purchasing PS-5000 Series, please purchase the option item and mount it. To make RS-422/485 communication via the added serial interface, arbitrary software that can switch the RTS line every time a driver is sent or received is required. It s not automatically switched. 2.7 USB Interface USB Interface of PS-5000 Series has 5 ports in total; USB 2.0 x 3 and USB 3.0 x 2. Use a channel corresponding to a connected device. 2.8 PCI Slot The size of PCI cards that can connect to PS-5000 Series is up to the half size (106.7mm 177.7mm). Please confirm that the previously used PCI card can be used in advance. [inch] [6.99] [4.20] 2.9 Power supply plug Caution: The power line terminal locations for the power supply plug differ between the PS-4800 and the PS-5000. PS-4800 PS-5000 DC power supply DC connector Power supply cable DC connector FG 0V 24V Power supply cable 2.10 Power consumption The power consumption does not include the value of power supplied to devices in the provided expansion slots and to USB devices. The maximum power consumption of the entire product including the value of supplied power is 45 W. 18
Chapter 3. Compatibility with Accessories 3.1 Individual accessories Individual accessories for the PS-4800 and their compatibility are listed below. These have low compatibility. Please be careful. HDD Unit without OS (for Slide in Disk) SSD Unit without OS (for Slide in Disk) CF Card 4GB Product name Model code * 250GB 500GB 32GB 60GB CF Card 8GB (only for Core 2 Duo Pre-installed Model) Adaptor to install an unit (for Slide in Disk to Slide in Slot) DVD multi drive (for Slide in Slot) Disposable, dirt-resistant sheet for the 15-inch screen.(5 sheets/set) Disposable, dirt-resistant sheet for the 19-inch screen.(5 sheets/set) Ultraviolet protection sheet for the 15-inch screen. (1 piece) Front USB cover for PS4000 series Panel type (with hook)(2 pcs) Noise Filter for Marine Certification UPS battery unit PFXZPSSCHDD251 PFXZPSSCHDD501 PFXZPSSCSSD321 PFXZPSSCSSD601 PFXZCBCF41 PFXZCBCF81 PFXZPSSSAD1 PFXZPSSSMD1 CA3-DFS15-01 CA7-DFS19-01 PFXZCFUV151 PFXZPPCVUS2 PFXZFTPNDC1 PFXZPSEUUPB1 PS- 4700 PS- 4800 PS- 5000 OK NG OK NG OK NG OK NG NG Extension cable for attaching to CA5-USBEXT-01 USB port on front panel (1 m) OK OK OK * Please check the model code/global code table at http://www.pro-face.com/trans/en/manual/1003.html. 19
3.2 Maintenance accessories Maintenance accessories for the PS-4800 and their compatibility are listed below. These have low compatibility. Please be careful. Product name Model code * Installation Gasket for Stainless Steel Bezel Model PFXZPTWG151 which provides dust and moisture resistance, when PS4000 series Panel type is installed into a solid panel (1 piece) Installation Fastner to be used to install PS4000 series PFXZPTAF14P1 Panel type (Stainless Steel Bezel) into a solid panel (14 pcs) Installation fasteners used to install PS4000 Series PFXZPPAF18P1 Panel Type into a solid panel. (18 pcs) AC power supply connector (Screw type 5 pcs) PFXZPSCNAC1 PS- 4700 PS- 4800 PS- 5000 DC power supply connector (Screw type 5 pcs) Lithium battery for replacement (for BIOS backup) Front USB cover for PS4000 series Panel type (2 pcs) PFXZPSCNDC1 PFXZPSBTLT1 PFXZPPCVUS1 Replacement FAN kit for PS4000 series Panel type PFXZPP0IUFAN1 with 0/1Slot (3 pcs=1 set) Replacement FAN filter for PS4000 series Panel type PFXZPP0FTFAN1 with 0/1Slot (15 pcs=5 sets) Replacement FAN kit for PS4000 series Panel type PFXZPP2IUFAN1 with 2 Slots (3 pcs=1 set) Replacement FAN filter for PS4000 series Panel type PFXZPP2FTFAN1 with 2 Slots (15 pcs=5 sets) * Please check the model code/global code table at http://www.pro-face.com/trans/en/manual/1003.html. 20
Chapter 4. Software Compatibility 4.1 Supported operating systems and operating system languages The supported operating systems for the PS-4800 and the PS-5000 are listed below. OS PS-4800 PS-5000 Core TM 2 Duo Atom TM Celeron/Core i7 Windows XP Professional Japanese Windows XP Professional Multi-Language Windows Embedded Standard 2009 Windows Embedded Standard 7 OK NG OK Windows 7 Ultimate OK NG OK Windows Embedded 8.1 NG NG OK system languages PS-4800 PS-5000 WinXP WinXP WES ML 2009 WES7 Win7 WES7/Win7/WES81 Arabic Bulgarian Chinese(Simplified) Chinese(Traditional) Croatian Czech Danish Dutch English Estonian Finnish French German Greek Hebrew Hungarian Italian Japanese Korean Latvian Lithuanian Norwegian Polish Portuguese Portuguese(Brazil) Romanian Russian Serbian Latin Slovak Slovenian Spanish Swedish Thai Turkish Ukrainian :Supported, :Not supported, :The language can be used by installing the language pack. 21
4.2 Supported software The software that the PS-5000 supports is listed below. Software WinGP *1 OK Pro-face Remote HMI Server OK Utilities System Monitor/Standalone Agent OK Backlight brightness adjustment *2 OK Touch panel driver *2 OK Keyboard emulator *2 OK Remote shutdown *3 OK EWF Setting Tool *2 OK Language selection Shell update *2 OK *1 An installer is included in the recovery media. *2 In Windows 7 Ultimate, Windows Embedded Standard 7, Windows Embedded 8.1, the function is a standard function. *3 The Remote Control function is included in System Monitor. 22
4.3 Functions supported by System Monitor The System Monitor functions that the PS-5000 supports are listed below. Monitor item Error Action PS- 4000 PS- 5000 Monitor item Error Action PS- 4000 PS- 5000 Device Management Voltage DOUT NG NG Watchdog Timer DOUT NG NG LED NG NG LED NG NG Buzzer NG NG Buzzer NG NG Popup Message NG NG Popup Message NG NG Shutdown NG NG Shutdown NG NG Event Log Hardware NG OK Reset NG NG e-mail NG OK Event Log NG NG Fan DOUT NG NG e-mail NG NG LED OK NG SMART DOUT NG NG Buzzer OK NG LED OK NG Popup Message OK NG Buzzer OK NG Shutdown OK NG Popup Message OK NG Event Log NG OK Event Log NG NG e-mail NG OK e-mail NG NG Temperature DOUT NG NG DIN DOUT NG NG LED OK NG LED NG NG Buzzer OK NG Buzzer NG NG Popup Message OK NG Popup Message NG NG Shutdown OK NG Shutdown NG NG Event Log NG OK Event Log NG NG e-mail NG OK e-mail NG NG Backlight DOUT NG NG Software Event Log NG OK LED NG NG e-mail NG OK Buzzer NG NG Popup Message NG NG Shutdown NG NG Event Log NG NG e-mail NG NG Remote Control Remote Reset NG OK Remote Veiwer NG OK Remote RAS NG NG Remote Screen Shot NG OK 23
Chapter 5. Appendix 5.1 Uninterruptible power supply (UPS) 5.1.1 Overview The uninterruptible power supply (UPS) option can only be used with Modular types. The diagram below shows the PS-5000 Series with an attached UPS. 1: UPS module(model code:pfxzpbeuupb2) 2: UPS cable kit(model code:pfxzpbcbup32) COM port cable 3m / DCpower cable 3m 3: AC Power Supply module(at the time of BTO shipment, possess a box.) Primary features of the UPS option: Rechargeable battery that is maintenance free and lasts a long time Communication over the built-in interface Temperature sensor Over discharge protection 5.1.2 Specifications Output voltage / Output current 24 Vdc / 4.2 A Power failure backup time 15 minutes maximum Battery capacity 55 Wh (2.75 Ah 4S2P) Maximum discharger current 1 A Operating voltage / Charging current 12..16 Vdc / 10 A(120 W) Typical recharge time at low battery 6 h Status indicator DCIN/CHG/RDY/BAT Configuration(Communication port) COM port(rs-232) 24
5.1.3 Dimensions 25
5.2 Exclusive BTO (build to order) options The products introduced below are optional products that can be built-in to the PS-5700 when purchased. The products below can be built-in by specifying the order model code as shown in red. Please note that the options cannot be installed after purchase. P F X P * 2 * * * * * * * * * N 0 0 5 7 8 9 10 11 12 13 14 15 Character number 5 7 8 9 10 11 12 13 14 15 Base unit Modular PC Celeron U Modular PC Core i7 P Modular panel Modular panel 15" 7 type Modular panel W19 J Box type Box Celeron 4 GB-RAM C Box Celeron 8 GB-RAM D Box Celeron 4 GB-RAM 1 x PCI + 1 x PCIe E Box Core i7 8 GB-RAM J Box Core i7 8 GB-RAM 1 x PCI + 1 x PCIe K Box Celeron 8 GB-RAM 1 x PCI + 1 x PCIe P Box Celeron 4 GB-RAM, 2 x PCI Q Box Celeron 8 GB-RAM, 2 x PCI R Box Celeron 4 GB-RAM, 2 x PCIe S Box Celeron 8 GB-RAM, 2 x PCIe T Box Core i7 16 GB-RAM U Box Core i7 16 GB-RAM 1 x PCI + 1 x PCIe V Box Core i7 8 GB-RAM, 2 x PCI W Box Core i7 16 GB-RAM, 2 x PCI X Box Core i7 8 GB-RAM, 2 x PCIe Y Box Core i7 16 GB-RAM, 2 x PCIe Z Box Core i7 16 GB-RAM, conformal coating A Box Core i7 16 GB-RAM, conformal coating L 1 x PCI + 1 x PCIe CPU type Celeron-2980U C Core i7-4650u 7 Celeron-2980U with fan for expansion card above 3 W F Core i7-4650u with fan for expansion card above 3W W Power supply DC D AC A RAM sizes 4GB 4 8GB 8 16GB A Operating None 0 system Windows Embedded Standard 7 (WES7P) SP1 64 bits MUI 4 Windows 7 Ultimate SP1 64 bits MUI 6 Windows Embedded 8.1 Industry 64 bits MUI 8 Storage device None N CFast 16 GB A CFast 32 GB X HDD 500 GB J HDD 1 TB K SSD 80 GB L SSD 160 GB M SSD 240 GB P 26
Character number 5 7 8 9 10 11 12 13 14 15 Options None 0 Interface 2 x RS 422/485 isolated 2 Interface 4 x RS 422/485 3 Interface 2 x USB 3.0 4 Interface 2 x RS 232 isolated 5 Interface 4 x RS 232 6 Interface 2 x Ethernet Gigabit PoE LAN 7 Interface 16 x DI / 8 x DO 8 Interface audio C Cellular module D Interface 2 x CANopen G Interface 1 x Profibus DP with NVRAM J Interface 1 x Ethernet Gigabit IEEE1588 LAN K Second storage None N CFast 16 GB A CFast 32 GB X HDD 500 GB J HDD 1 TB K SSD 80 GB L SSD 160 GB M SSD 240 GB P 27