RAM SERIES ZTR Parts manual RAM, B&S/, RAM 0, B&S/, RAM, HONDA/, RAM MAG, 0 KOH/0, RAM MAG 0, KAW/, RAM MAG 0, O HONDA/, RAM MAG 0, 0 KOH/ Please read the operator s manual carefully and make sure you understand the instructions before using the English
MAIN FRAME REF. 0 0 0 0 0 0
MAIN FRAME... 0...... FRAME W/DECALS... 0...... ZERK... 0...... BATTERY, DRY... 00...... TANK STUD... 0...... SRPING, FUEL TANK... 0...... GROMMET, RUBBER... 0...... GROMMET... 0...... BATTERY HOLD DOWN... 0...... NUT /, PUSH 0... 0...... BOLT, / X /, SPEC... 0...... PUSH MOUNT WIRE CLIP... 0...... BATTERY TRAY... 0...... BEARING, FLANGED... 0...... HEAVY WASHER... 0...... FUEL CAP, ANTISPLASH... 0...... TANK, FUEL, LEFT... 0...... HCS, /- X /, GR... 0...... GUARD, REAR... 0...... FOOT PLATE W/DECALS 0... 0...... STRAP, REAR......... SPRING CAP......... SEAT SPRING......... VALVE, FUEL......... HCS, /- X /, GR... 00...... HCS, /- X /, GR... 00...... HCS, /- X, GR... 0...... RHSNB, /- X /, GR... 0...... NUT, /-, WHIZLK... 0...... HCS, /- X, GR 0... 0...... WASHER, /... 0...... NUT, /-, NYLOC... 0...... BATTERY CABLE, NEG, (NOT SHOWN)... 0...... MAIN WIRE HARNESS, (NOT SHOWN)
DECK LIFT 0 0 0
DECK LIFT... 0...... HCS, /- X /, GR... 0...... BUSHING... 0...... PIN LIFT, / X, W/RING... 00...... REINFORCEMENT BAR... 00...... BLOCK, PILLOW... 00...... CROSS LINK......... STRUT LINKAGE......... LIFT SHAFT, REAR......... LIFT SHAFT, FRONT 0......... PLATE, HEIGHT, OUTER... 0...... SPACER... 0...... PEDAL, FOOT......... FOOT PAD......0... NUT, /-, NYLOC......... WASHER, /, SAE......... PIN HAIR, / X /... 00...... WASHER, /, SAE... 0...... WASHER, /... 0...... HCS, /- X /, GR 0... 0...... PIN COTTER, / X /... 0...... HCS, /- X /, GR... 0...... NUT, /-, NYLOC
CONTROL LEVERS & PARK BRAKE 0 0 0
CONTROL LEVERS & PARK BRAKE... 000...... SWITCH, INTERLOCK... 0...... BUSHING... 0...... LOCKWASHER, /, SPEC.... 00...... DAMPENER... 0...... BUSHING, PLASTIC... 00...... DAMPENER BRACKET... 0...... PIVOT SHAFT......... BRAKE SHAFT......... LINKAGE 0... 0...... BATTERY TRAY......... BRAKE LEVER......... LEVER, DRIVE, RIGHT......... LEVER, DRIVE, LEFT......... GRIP......... GRIP, ADJUSTMENT LEVER......... NUT, /-, NYLOC......... PIN HAIR... 0...... RHSNB, /- X /, GR... 0...... WASHER, / 0... 0...... NUT, /-, WHIZLK... 0...... NUT, /-, WHIZLK... 0...... HCS, /- X /, GR... 0...... HCS, /- X /, GR... 0...... HCS, /- X /, GR... 0...... WASHER, /... 0...... NUT, /-, NYLOC... 0...... SCREW, #0- X /, WASH HD... 0...... CONTROL WELEMENT, RIGHT... 0...... CONTROL WELDMENT, LEFT (NOT SHOWN)... 0...... CONTROL ARM 0... 0...... WASHER......... ZERK... 0...... RIVET, NYLON PUSH-IN... 0...... HCS, /- X /, TPBLT, GR... 0...... NUT, /-, LOCK......... END PLUG, /
CASTER ASSEMBLY 0 0
CASTER ASSEMBLY......... RHSNB /- X /, GR......... CASTER YOKE... 0...... NUT, /-, NYLOC......... CASTER TIRE, COMPLETE......... TIRE, PLY, 0-......... VALVE STEM... 0...... RIM... 000...... ZERK... 0...... BEARING, FLANGED... 00...... ROLLER BEARING, / (NOT SHOWN) 0... 0...... SPACER......... ZERK... 0...... BEARING, FLANGED......... PLUG, CASTER... 00...... HCS, /- X, GR......... CAP, DUST, BEARING......... SPRING, CASTER......... WASHER,.0... 0...... BUSHING, CASTER... 0...... SPACER, /
SEAT ASSEMBLY MODELS:, 0......... PAN, SEAT... 0...... WASHER, /... 0...... LOCKWASHER, /......... NUT, /-, NYLOC... 0...... HCS, /- X /, GR... 0...... NUT, /-, NYLOC... 0...... SEAT ASSEMBLY... 00...... HCS, /- X, GR......... ARM, PROP, SEAT 0... 0...... SEAT SWITCH......... SEAT SLIDE SET (NOT SHOWN)
SEAT ASSEMBLY MODELS:, 0,,, 0......... PAN, SEAT... 0...... WASHER, /... 0...... LOCKWASHER, /......... NUT, /-, NYLOC... 0...... HCS, /- X /, GR... 0...... NUT, /-, NYLOC......... SEAT ASSEMBLY......... ARM, PROP, SEAT... 00...... HCS, /- X, GR 0... 0...... SEAT SWITCH......... SEAT SLIDE SET (NOT SHOWN)
CONSOLE ASSEMBLY MODELS:, 0
CONSOLE ASSEMBLY MODELS:,... 0...... SWITCH......... IGNITION SWITCH... 00...... HOUR METER... 0...... TANK, CONSOLE, RIGHT... 0...... CONTOL PANEL... 0...... PANEL, LIGHT DELETE......... SCREW, #0- X /......... CABLE, THROTTLE......... CHOKE CABLE 0......... NUT, #0-, NYLOC... 0...... SCREW, #0- X /... 0...... DECAL, CONTROL
CONSOLE ASSEMBLY MODELS:, 0,,, 0
CONSOLE ASSEMBLY MODELS:, 0,,,... 0...... SWITCH......... IGNITION SWITCH... 00...... HOUR METER... 0...... TANK, CONSOLE, RIGHT... 0...... PLATE, LIGHT......... SCREW, #0- X /......... CABLE, THROTTLE......... HEADLIGHT......... CHOKE CABLE 0......... NUT, #0-, NYLOC... 0...... SCREW, #0- X /... 0...... CONTROL PANEL... 0...... DECAL, CONTROL... 0...... PIGTAIL HEADLIGHT (NOT SHOWN)
BRIGGS & STRATTON ENGINE ASSEMBLY MODELS:, 0 0 0 REF.
BRIGGS & STRATTON ENGINE ASSEMBLY MODELS:,... 0...... SOLENOID... 0...... INSULATOR, BATTERY... 00...... NUT, /-0, THIN NYLOC... 000...... RHSNB, /-0 X, GR... 00...... CLUTCH WASHER... 00...... OIL DRAIN FITTING... 0...... PULLEY... 0...... FUEL LINE,... 0...... FUEL LINE, 0......... RHSSNB, /-0 X /, GR......... CLUTCH......... CLUTCH TIE DOWN......... MUFFLER......... CLAMP, HOSE......... NUT, /-0, NYLOC... 00...... WASHER, /... 0...... WASHER, /......... HCS, /-0 X, GR......... SPACER, ENGINE PULLEY 0... 0...... SCREW, /-0 S /, THDROLL... 00...... CABLE, POSITIVE (NOT SHOWN)... 0...... PIGTAIL (NOT SHOWN)... 00...... GROUND WIRE (NOT SHOWN)
HONDA ENGINE ASSEMBLY MODELS:, 0 REF. 0 0
HONDA ENGINE ASSEMBLY MODELS:,... 0...... SCREW, /-0 X /, THDROLL... 0...... INSULATOR, BATTERY... 00...... NUT, /-0, THIN NYLOC... 000...... RHSNB, /-0 X, GR... 00...... CLUTCH WASHER......... OIL DRAIN ADAPTER... 0...... PULLEY... 0...... FUEL LINE,... 0...... FUEL LINE, 0 0......... CLUTCH......... HONDA PIGTAIL......... SPACER, ENGINE PULLEY......... MUFFLER......... CLAMP, HOSE......... NUT, /-0, NYLOC... 00...... WASHER, /... 0...... WASHER, /......... HCS, /-0 X, GR......... TIE DOWN, CLUTCH 0... 0...... HCS, /-0 X, GR... 0...... WASHER, /... 0...... CABLE, POSITIVE (NOT SHOWN)... 00...... GROUND WIRE (NOT SHOWN)
KAWASAKI ENGINE ASSEMBLY MODEL: 0 REF.
KAWASAKI ENGINE ASSEMBLY MODEL:... 0...... SOLENOID... 0...... INSULATOR, BATTERY... 0...... OIL DRAIN EXTENSION... 0...... O-RING... 000...... RHSNB, /-0 X, GR... 00...... CLUTCH WASHER... 0...... PULLEY... 0...... FUEL LINE,... 0...... FUEL LINE, 0......... RHSSNB, /-0 X /, GR......... CLUTCH......... CLUTCH TIE-DOWN......... CLAMP, HOSE......... NUT, /-0, NYLOC... 00...... WASHER, /... 0...... WASHER, /......... HCS, /-0 X, GR......... SPACER, ENGINE PULLEY... 0...... SCREW, /-0 X /, THRDOLL... 00...... CABLE, POSITIVE (NOT SHOWN)......... MUFFLER (NOT SHOWN)... 0...... PIGTAIL, KAWASAKI (NOT SHOWN)... 00...... GROUND WIRE (NOT SHOWN)
KOHLER ENGINE ASSEMBLY MODELS: 0, 0
KOHLER ENGINE ASSEMBLY MODELS: 0,... 0...... SCREW, /-0 X /, THDROLL... 0...... INSULATOR, BATTERY... 00...... NUT, /-0, THIN NYLOC......... HCS, /-0 X, GR... 000...... RHSNB, /-0 X, GR... 00...... CLUTCH WASHER... 00...... OIL DRAIN FITTING... 0...... PULLEY... 0...... FUEL LINE, 0... 0...... FUEL LINE,... 0...... WASHER, /......... CLUTCH......... TIE-DOWN, CLUTCH......... SPACER......... MUFFLER......... CLAMP, HOSE......... NUT, /-0, NYLOC... 00...... WASHER, /... 0...... CABLE, POSITIVE (NOT SHOWN)... 00...... GROUND WIRE (NOT SHOWN)... 0...... KOHLER PIGTAIL (NOT SHOWN)
ISO MOUNT 0
ISO MOUNT... 0...... HCS, /- X /, GR... 0...... WASHER, /, EXT STAR......... WASHER, /......... ISO-MOUNT, INSERT......... ISO-MOUNT BUSHING......... ISO-MOUNT PLATE......... ISO-MOUNT BUSHING......... ISO-MOUNT, BRACKET......... HCS, /- X /, GR 0......... HCS, /- X, GR... 0...... NUT, /, WHIZLK... 0...... WASHER, /... 0...... NUT, /-, NYLOC
HYDRAULIC ASSEMBLY 0 0 0 0 0 0 TORQUE TO FT./LBS. TORQUE TO FT./LBS.
HYDRAULIC ASSEMBLY... 0...... NUT, /-0, LUG... 0...... HCS, /- X /, GR... 0...... SPRING... 0...... SPRING EXTENSION... 0...... BELT, PUMP... 0...... NUT, /-... 000...... RHSNB, /-0 X, GR... 0...... PULLEY, IDLER... 0...... NUT, /, NYLOC 0... 0...... SPINDLE, IDLER... 0...... NUT, /-, NYLOC... 0...... HCS, /- X /, GR... 00...... HCS, /-, GR... 0...... IDLER ARM... 0...... HEAVY WASHER... 0...... WASHER, /... 0...... BRAKE SWIVEL... 0...... BRAKE LINKAGE......... ZT00, RIGHT, NON CHARGED,... MODELS:,......... ZT00, RIGHT, MODELS:,... 0,,,... 0... 0...... ZT00, LEFT, NON CHARGED,... MODELS:,......... ZT00, LEFT, MODELS:,... 0,,,............ EXPANSION TANK W/CAP......... CAP......... BYPASS LINKAGE......... 00 CROSS SUPPORT... 0...... IDLER PULLEY PLATE......... SWIVEL, /-......... SPACER......... HCS, /- X /, GR......... NUT, /-0, NYLOC 0......... NUT, /-, NYLOC......... PIN, HAIR,.0 X /... 0...... WASHER, /... 0...... WASHER, /, SAE... 0...... RHSNB, /- X /, GR... 0...... HCS, /- X, GR... 0...... NUT, /-, WHIZLK... 0...... HCS, /- X /, GR... 0...... NUT, /-, NYLOC......... OIL FILTER 0... 0...... DRIVE LINKAGE... 0...... NUT, /-... 0...... NUT, /-, LH... 00...... ROD END, LEFT... 00...... ROD END, RIGHT... 00...... TIRE,COMPLETE... 000...... TIRE... 000...... RIM......... VALVE STEM......... HOSE KIT (NOT SHOWN)
DECAL ASSEMBLY MODELS:, 0... 0...... DECAL, PROP... 0...... DECAL, MOTION CONTROL... 0...... DECAL, EURO DANGER BELT... 0...... DECAL, EURO BATTERY WARNING... 0...... DECAL, WARNING... 0...... DECAL, DO NOT TOW......... DECAL, WARNING......... DECAL, HEIGHT......... DECAL, RAM 0... 0...... DECAL, ZRT......... DECAL, HYDRO GEAR... 0...... DECAL, FLAG... 0...... DECAL, ENGINE, BRIGGS & STRATTON 0
DECAL ASSEMBLY MODELS:, 0,,, 0... 0...... DECAL, PROP... 0...... DECAL, MOTION CONTROL... 0...... DECAL, EURO DANGER BELT... 0...... DECAL, EURO BATTERY WARNING... 0...... DECAL, WARNING... 0...... DECAL, DO NOT TOW......... DECAL, WARNING......... DECAL, HEIGHT... 0...... DECAL, RAM MAG 0......... DECAL, HYDRO GEAR... 0...... DECAL, FLAG... 0...... DECAL, PRO ZTR... 0...... DECAL, ENGINE, KOHLER... 0...... DECAL, ENGINE, KAWASAKI
DECK 0 0 0 0 0 0 0 0 0
... 0...... PIN COTTER, /... X /... 00...... DECAL,... WARNING......... SWIVEL......... L BOLT, S......... L BOLT, L......... DECK... W/DECALS......... IDLER SPACER......... IDLER ARM......... V-BELT 0......... PULLEY, IDLER... 0...... COTTER PIN,... / X /......... RHSNB, /-... X /,GR... 0...... WASHER, /......... HH BOLT, /-... X... 0...... NUT, /-,... THIN NYLOC......... SCREW, #-... X /, TAP......... NUT, /-,... FLANGE L... 0...... DEFLECTOR... SPRING......... HHB, /- X... /, GR 0......... DEFLECTOR... PIN......... DEFLECTOR... BRACKET......... DEFLECTOR... MOUNT... BRACKET......... TRASH GUARD......... IDLER PULLEY......... BLADE BOLT... 0...... SPINDLE......... BLADE, HI LIFT... 00...... SPRING,... DECK BELT... 0...... EYE BOLT, / 0......... BAFFLE......... HINGE......... DEFLECTOR DECK......... PULLEY GUARD......... PULLEY GUARD......... BOLT, / X,... GR... 0...... BLOW-BY... BAFFLE......... BUSHING......... ROLLER......... NUT, /-0,... NYLOC 0......... NUT, /-,... NYLOC... 0...... NUT, /-, GR... 0...... WASHER, /,... SAE... 00...... WASHER, /,... SAE... 0...... RHSNB, /-... X /, GR... 0...... WASHER, /... 00...... HCS, /-0 X /,... GR... 0...... NUT, /-,... NYLOC......... HUB PULLEY... SPACER......... HHB, /-0 X... /, GR 0......... WASHER, /......... GREASE ZERK......... OUTER SHAFT... KEY... 0...... BEARING......... SPACER......... PULLEY... 0...... SHAFT, SHORT... 0...... DECK HUB......... TRASH GUARD......... HHB, /- X... /, GR 0... 0...... NUT, /-0......... HCS, /-0 X,... GR... 0...... DECAL, EURO... SEVERING......... DECAL,......... DECAL,... BELT ROUTING
0 DECK 0 0 0 0 0 0 0 0 0 0
0 DECK... 0...... RHSNB, /-... X, GR... 0...... PIN COTTER, /... X... 0...... WASHER, /......... IDLER PULLEY,... NYLON......... SWIVEL......... L BOLT, S......... L BOLT, L......... SPACER, IDLER......... DECK W/DECALS 0......... SPINDLE... 0...... PULLEY GUARD,... RIGHT... 0...... PULLEY GUARD,... LEFT... 0...... V-BELT......... PULLEY, IDLER... 0...... COTTER PIN, /... X /......... RHSNB, /-... X /, GR... 0...... WASHER, /... 0...... NUT, /-,... NYLOC......... EYE BOLT, / X... / 0......... BOLT, /- X... 0...... NUT, /-,... THIN NYLOC......... SCREW, #-... X /, TAP......... NUT, /-,... FLANGE... 0...... DEFLECTOR... SPRING......... HHB, /- X... /, GR......... DEFLECTOR PIN......... BAFFLE......... DEFLECTOR... BRACKET......... DEFLECTOR... MOUNT BRACKET 0... 0...... HCS, /- X,... GR......... IDLER SPACER......... HHB, /- X... /, GR... 00...... IDLER PULLEY......... TRASH GUARD......... BLADE BOLT......... BLADE, HIGH LIFT......... DECAL, 0 DECK... 00...... SPRING,... DECK BELT......... HINGE 0......... DEFLECTOR......... GUAGE WHEEL......... BOLT, / X..., GR... 0...... BLOW-BY BAFFLE......... BRACKET... 0...... IDLER ARM......... BUSHING......... ROLLER......... NUT, /-0,... NYLOC......... NUT, /-,... NYLOC 0... 0...... NUT, /-,... GR... 0...... WASHER, /,... SAE... 00...... WASHER, /,... SAE... 0...... NUT, /-... 0...... RHSNB, /-... X /, GR... 0...... WASHER, /... 00...... HCS, /-0 X... /, GR... 0...... NUT, /-,... NYLOC... 0...... DECK HUB... 0...... BEARING 0......... SPACER......... PULLEY, METRIC... 0...... SHAFT SHORT......... TRASH GUARD......... HUB PULLEY... SPACER......... WASJER, /......... ZERK, /......... KEY, OUTER... SHAFT......... HHB, /- X... /, GR......... HHBLT, /-0... X / 0... 0...... DECAL, EURO... SEVERING......... DECAL, BELT... ROUTING... 00...... DECAL, WARNING... 0...... NUT, /-,... WHIZLK
WIRING DIAGRAM. Seat unoccupied. Blade switch in OFF position. Brake switch OFF pos. -. Motion control levers OUT. Battery. Accessory outlet. Key switch. To engine pigtail. Hour meter. Seat switch. Run relay. Blade switch. Brake relay 0. Electric clutch. Brake switch. Start relay. Starter solenoid. Left motion control lever. Right motion control lever. Starter. 0 AMP fuse 0.. fuse. Diode 0. Voltage regulator. Fuel shut-off solenoid. Ignition 0