OTPC 50/5/60 Amp Transfer Switch Printed in U.S.A. 6 08B (Spec A) 5-00
This catalog covers models produced under the Cummins /Onan and Cummins Power Generation brand names. To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Cummins Power Generation nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Cummins Power Generation manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Cummins Power Generation equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-
Introduction This catalog applies to the Cummins Power Generation OTPC 50/5/60 Amp Transfer Switch. Each illustrated part is identified by a reference number corresponding to the same reference number in the parts list for that group. Parts illustrations are typical. Using the model and spec number from the switch box nameplate, select the parts that apply to your Transfer Switch. Unless otherwise noted in the parts description, parts are interchangeable between models. Feature Options Code Description Code Description A08 -Pole Switch L0 Auxiliary Relay Emergency Position VDC A0 -Pole Switch L0 Auxiliary Relay Normal Position VDC A05 Utility to Generator Set Applications L0 Auxiliary Relay Generator Start VDC A06 Utility to Utility Applications M00 Terminal Block 0 Points A0 Generator Set to Generator Set Applications M00 Load Shed From Emergency A0 One Phase or wire M0 Security Front Panel A0 Three Phase or wire M08 Display Digital A0 Frequency 60 Hz M00 Communications Lonworks A05 Frequency 50 Hz M0 Monitoring Load A06 Listing UL M0 Module Relay Signal A06 Listing UL/NFPA 0 N00 Bus Stubs Connection B00 Cabinet Type N0 Harness Extension B00 Cabinet Type R R00 Voltage 0 B00 Cabinet Type R0 Voltage 08 B00 Construction Open R0 Voltage 0 B00 Cabinet Type R0 Voltage 0 C0 Control Level R0 Voltage 80 C0 Control Level R05 Voltage 6 D00 Meters Bar Graph Display R06 Voltage 80 K00 Battery Charger Amp, /V R0 Voltage 600 K00 Battery Charger 0 Amp, V R05 Voltage 0 K00 Battery Charger 0 Amp, V R08 Voltage 0 L0 Auxiliary Relay VDC Coil S0 Current Rating 50 Amps L0 Auxiliary Relay Emergency Position VDC S050 Current Rating 5 Amps L0 Auxiliary Relay Normal Position VDC S05 Current Rating 60 Amps L0 Auxiliary Relay Generator Start VDC L0 Auxiliary Relay VDC Coil Copyright 00 Cummins Power Generation. All rights reserved.
Index Actuator, Linear Transfer Switch, Alarm, Battery Charger, Ammeter DC 0 Amp, Volt Battery Charger, 5 Ammeter DC 0 Amp, Volt Battery Charger, Ammeter DC Amp, / Volt Battery Charger, Arm, Interlock Transfer Switch, Bar, Interlock Transfer Switch, Bar, Neutral Transfer Switch, Barrier Transfer Switch, Barrier, Base Transfer Switch, Base, Mounting Transfer Switch, Block and Contact Assembly Transfer Switch, Block and Cross Bar Assembly Transfer Switch, Block, Hinge Type Cabinet, Block, Lug Mounting Transfer Switch, Block, Terminal, 0 Block, Terminal Battery Charger Alarm, Block, Terminal Network Module, 8 Block, Terminal Transfer Switch, Board, Printed Circuit 0 Amp, Volt Battery Charger, 5 Board, Printed Circuit 0 Amp, Volt Battery Charger, Board, Printed Circuit Amp, / Volt Battery Charger, Board, Printed Circuit Bar Graph Type Cabinet, Board, Printed Circuit Bar Graph Type R and Cabinet, 5 Board, Printed Circuit Bar Graph Type Cabinet, Board, Printed Circuit Current Transformer Module, Board, Printed Circuit Digital Type Cabinet, Board, Printed Circuit Digital Type R and Cabinet, 5 Board, Printed Circuit Digital Type Cabinet, Board, Printed Circuit Network Module, 8 Board, Printed Circuit Power Module Type Cabinet, Board, Printed Circuit Power Module Type R and Cabinet, 5 Board, Printed Circuit Power Module Type Cabinet, Board, Printed Circuit Relay Module, Bracket, Connector Accessory Control Plate (600 Volt), Bracket, Connector Accessory Control Plate (Less than 600 Volt), 8 Bracket, Door Type Cabinet, Bracket, End Auxiliary Relay, Bracket, End Terminal Battery Charger Alarm, Bracket, End Terminal Network Module, 8 Bracket, Terminal Transfer Switch, Breaker, Circuit Transfer Switch, Bus, Emergency Transfer Switch, Bus, Load Transfer Switch, Bus, Normal Transfer Switch, Cabinet Type, Cabinet Type, 5 Cabinet Type R, 5 Cabinet Type, Capacitor Transfer Switch, Charger, Battery 0 Amp, Volt, 5 Charger, Battery 0 Amp, Volt, Charger, Battery Amp, / Volt, Chute, Arc Transfer Switch, Cover, Arc Chute Transfer Switch, Cover, Charger 0 Amp, Volt Battery Charger, 5 Cover, Charger 0 Amp, Volt Battery Charger, Cover, Charger Amp, / Volt Battery Charger, Cover, Labeled Transfer Switch, Cover, Printed Circuit Board Type Cabinet, Cover, Printed Circuit Board Type R and Cabinet, 5 Cover, Printed Circuit Board Type Cabinet, Cover, Relay Plate Accessory Control Plate (600 Volt), Cover, Relay Plate Accessory Control Plate (Less than 600 Volt), 8 Door, Cabinet Type, Door, Cabinet Type R and Cabinet, 5 Door, Cabinet Type Cabinet, Fuse 0 Amp, Volt Battery Charger, 5 Fuse 0 Amp, Volt Battery Charger, Fuse Amp, / Volt Battery Charger, Gasket, Door Type R and Cabinet, 5 Gasket, Door Type Cabinet, Handle Assembly, Actuator, 0 Handle, Door Type R and Cabinet, 5 Handle, Locking Type Cabinet, Harness, Wiring 0 Amp, Volt Battery Charger, 5 Harness, Wiring 0 Amp, Volt Battery Charger, Harness, Wiring Amp, / Volt Battery Charger, Harness, Wiring Battery Charger, Harness, Wiring Battery Charger Alarm, Harness, Wiring Control Open Construction, 0 Harness, Wiring Current Transformer Module, Harness, Wiring Load Shed, Harness, Wiring Main Type Cabinet, Harness, Wiring Main Type R and Cabinet, 5 Harness, Wiring Main Type Cabinet, Harness, Wiring Network Module, 8 Holder, Fuse 0 Amp, Volt Battery Charger, 5 Holder, Fuse 0 Amp, Volt Battery Charger, Holder, Fuse Amp, / Volt Battery Charger, Insulator, Arc Chute Transfer Switch, Latch, Cam Type Cabinet, Latch, Cam Type R and Cabinet, 5 Lead Type Cabinet, Lead Type R and Cabinet, 5 Lead Type Cabinet, Load Shed, Lug, Solderless Transfer Switch, Lug, Solderless Type Cabinet, Lug, Solderless Type R and Cabinet, 5 Lug, Solderless Type Cabinet, Membrane, Panel Type Cabinet, Membrane, Panel Type R and Cabinet, 5 Membrane, Panel Type Cabinet, Module, Current Transformer, Module, Digital Display Type Cabinet, Module, Digital Display Type R and Cabinet, 5 Module, Digital Display Type Cabinet, Module, Network, 8
Index Plate, Accessory Control (600 Volt), Plate, Accessory Control (Less than 600 Volt), 8 Plate, End Terminal Battery Charger Alarm, Plate, End Terminal Network Module, 8 Plate, Handle Mounting Transfer Switch, Plate, Mounting Battery Charger Alarm, Plate, Mounting Current Transformer Module, Plate, Mounting Load Shed, Plate, Open Construction, 0 Plate, Relay Accessory Control Plate (600 Volt), Plate, Relay Accessory Control Plate (Less than 600 Volt), 8 Rail, Terminal Auxiliary Relay, Rail, Terminal Block Battery Charger Alarm, Rail, Terminal Block Network Module, 8 Rectifier, Bridge 0 Amp, Volt Battery Charger, 5 Rectifier, Bridge 0 Amp, Volt Battery Charger, Rectifier, Gate 0 Amp, Volt Battery Charger, 5 Rectifier, Gate 0 Amp, Volt Battery Charger, Relay Accessory Control Plate (600 Volt), Relay Accessory Control Plate (Less than 600 Volt), 8 Relay Load Shed, Relay, Auxiliary, Relay, Control Accessory Control Plate (600 Volt), Relay, Control Auxiliary Relay, Resistor, Fixed Amp, / Volt Battery Charger, Rod, Actuator Transfer Switch, Rod, Roller Type Cabinet, Rod, Roller Type R and Cabinet, 5 Rod End, Actuator Transfer Switch, Spacer, Actuator Transfer Switch, Spacer, Mounting Block Transfer Switch, Spring, Conical Type Cabinet, Standoff, Insulator Transfer Switch, Strap, Jumper Transfer Switch, Strap, Load Transfer Switch, Strip, Marker Transfer Switch, Support, Channel Transfer Switch, Switch Assembly, Auxiliary, Switch, Selector Security, Switch, Toggle Accessory Control Plate (600 Volt), Switch, Toggle Accessory Control Plate (Less than 600 Volt), 8 Transfer Switch Assembly, Transformer 0 Amp, Volt Battery Charger, 5 Transformer 0 Amp, Volt Battery Charger, Transformer Amp, / Volt Battery Charger, Transformer, Current, Transformer, Power Type Cabinet, Transformer, Power Type R and Cabinet, 5 Transformer, Power Type Cabinet, Wrapper, Charger Amp, / Volt Battery Charger, Wrapper, Charger 0 Amp, Volt Battery Charger, 5 Wrapper, Charger 0 Amp, Volt Battery Charger,
Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG CSA DC Deg. EFC EIT EPROM ET GFI ID IEC IT kw LPG LT M(meter number) Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Canadian Standard Association Direct Current Degree Electronic Fuel Control External/Internal Tooth Erasable Programmable Read Only Memory External Tooth Ground Fault Interrupter Inside Diameter International Electrotechnical Commission Internal Tooth Kilowatt Liquid Petroleum Gas Left Meter MCM mm MOH NFS NPT OD oz. PCB Ph PMG PT/CT RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT) Metric Circular Mils Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Printed Circuit Board Phase Permanent Magnet Generator Potential Transformer/ Current Transformer Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With
5
6 Transfer Switch 5 6 8 0 8 0 0 5 5 5 5 5 5 5 6 8 6 0 5 6 8 0 5 6 6 8 0 5 6 8 50 5 5 5 5 55 56 5 58 5 6 60 6 6 6 6 65
Transfer Switch Transfer Switch Assembly -Pole, Front Connect with Mechanical Lugs 50 Amp 06 0 0 0 VAC 06 0 0 0 VAC 06 0 0 08/0/0/600* VAC 06 0 0 80/6 VAC 06 0 05 0/80 VAC 5 Amp 06 0 06 0 VAC 06 0 0 0 VAC 06 0 08 08/0/0/600* VAC 06 0 0 80/6 VAC 06 0 0 0/80 VAC 60 Amp 06 0 0 VAC 06 0 0 VAC 06 0 08/0/0/600* VAC 06 0 80/6 VAC 06 0 5 0/80 VAC -Pole, Front Connect with Mechanical Lugs 50 Amp 06 05 0 0 VAC 06 05 0 08/0/0/600* VAC 06 05 0 80/6 VAC 06 05 05 0/80 VAC 5 Amp 06 05 0 0 VAC 06 05 08 08/0/0/600* VAC 06 05 0 80/6 VAC 06 05 0 0/80 VAC 60 Amp 06 05 0 VAC 06 05 08/0/0/600* VAC 06 05 80/6 VAC 06 05 5 0/80 VAC -Pole, Rear Connect with Bus Stubs 50 Amp 06 06 0 0 VAC 06 06 0 0 VAC 06 06 0 08/0/0/600* VAC 06 06 0 80/6 VAC 06 06 05 0/80 VAC 5 Amp 06 06 06 0 VAC 06 06 0 0 VAC 06 06 08 08/0/0/600* VAC 06 06 0 80/6 VAC 06 06 0 0/80 VAC 60 Amp 06 06 0 VAC 06 06 0 VAC 06 06 08/0/0/600* VAC 06 06 80/6 VAC 06 06 5 0/80 VAC -Pole, Rear Connect with Bus Stubs 50 Amp 06 0 0 0 VAC 06 0 0 08/0/0/600* VAC 06 0 0 80/6 VAC 06 0 05 0/80 VAC 5 Amp 06 0 0 0 VAC 06 0 08 08/0/0/600* VAC 06 0 0 80/6 VAC 06 0 0 0/80 VAC 60 Amp 06 0 0 VAC 06 0 08/0/0/600* VAC 06 0 80/6 VAC 06 0 5 0/80 VAC 06 5 Base, Mounting 06 6 Cover, Labeled 80 00 Nut, Self-Locking (#0 ) 85 065 Screw, Hex Head Slotted W/IT (#0 x.50) 5 56 0008 Washer, Flat (#0) 6 06 0 Barrier 06 8 Spacer, Actuator 8 800 00 Screw, Cap Hex Head (/ 0 x.50) 850 000 8 Washer, Lock (/) 0 56 008 8 Washer, Flat (/) 06 Rod, Actuator Screw, Cap Hex Head (5/6 8 x.88) 800 00 8 -Pole, Front Connect 800 00 6 -Pole, Front Connect 800 00 -Pole, Rear Connect 800 00 -Pole, Rear Connect 06 00 0 Rod-End, Actuator 800 0008 Screw, Cap Hex Head (/ 0 x.5) 5 Washer, Spring Conical (5/6) 85 008 -Pole, Front Connect 85 008 -Pole, Front Connect 85 008 -Pole, Rear Connect 85 008 6 -Pole, Rear Connect 6 85 065 6 Screw, Round Head Cross Recessed (#6 x.5) 8 Block, Terminal 8 800 000 Screw, Hex Head (/ 0 x.50) 85 00 Screw, Flat Head Cross Recessed (#0 x.50) 0 80 0 Nut, Hex W/ET (#0 ) 06 8 Bracket, Terminal 6 80 Lead (80/6/0/80 VAC) 605 Jumper, Terminal 80 08 Nut, Lock (/8 6) * Switch is actually 08 volts A large transformer in the system reduces the 600 volt system voltage down to 08 volts. Continued...
8 Transfer Switch 5 6 8 0 8 0 0 5 5 5 5 5 5 5 6 8 6 0 5 6 8 0 5 6 6 8 0 5 6 8 50 5 5 5 5 55 56 5 58 5 6 60 6 6 6 6 65
Transfer Switch Continued... 5 0 Strip, Marker 6 06 55 Barrier, Base 06 Switch Assembly, Auxiliary (See Separate Page For Components) 8 Screw, Self-Locking Hex Head Thread Forming W/IT (/ 0 x.5) 85 066 6 -Pole, Front Connect 85 066 -Pole, Front Connect 85 066 8 -Pole, Rear Connect 85 066 6 -Pole, Rear Connect Block and Cross Bar Assembly Emergency 06 0 0 -Pole 06 080 0 -Pole 0 Strap, Jumper 65 -Pole, Front Connect 65 -Pole, Front Connect and -Pole, Rear Connect Screw, Cap Hex Head (5/6 x.5) 800 000 -Pole, Front Connect 800 000 -Pole, Front Connect Nut, Hex (/ 0) 86 000 -Pole, Rear Connect 86 000 6 -Pole, Rear Connect Nut, Hex (5/6 8) 86 005 -Pole, Front Connect 86 005 -Pole, Front Connect 06 8 Bar, Interlock 5 06 0508 Arm, Interlock 6 85 06 8 Screw, Cross-Recessed Round Head W/IT (#8 x.50) Lug, Solderless 08 50/5 Amp Front Connect 0 60 Amp Front Connect 8 Block and Cross Bar Assembly Normal 06 0 0 -Pole 06 080 0 -Pole 06 6 Plate, Handle Mounting 0 06 8 Handle, Actuator (See Separate Page For Components) 56 00 Washer, Flat (5/6) -Pole, Front Connect 85 006 Washer, Lock W/ET (5/6) -Pole, Front Connect 05 Standoff, Insulator -Pole, Front Connect 0 0 Strap, Load Front Connect 5 0 0 Strap, Load Front Connect 6 0 0 Strap, Load Front Connect 8 Harness, Wiring 8 66 Bar, Neutral (-Pole, Front Connect) 5 Clamp, Cable 50 Actuator, Linear 06 0 0 VAC 06 0 0 VAC 06 0 08/0/0/600* VAC 06 05 80/6 VAC 06 06 0/80 VAC 5 Breaker, Circuit 0 060 0 VAC 0 0608 0/08/0/0/600* VAC 0 0606 80/6/0/80 VAC 5 Capacitor 00 0 VAC 00 0/08/0/0/600* VAC 00 80/6/0/80 VAC 5 Screw, Cap Hex Head (5/6 8 x.00) 800 008 -Pole, Front Connect 800 008 -Pole, Rear Connect 5 06 068 Chute, Arc -Pole 55 85 05 Screw, Pan Head Thread Cutting (#0 x.50) -Pole 56 06 56 Cover, Arc Chute -Pole 5 06 5 Insulator, Arc Chute -Pole 58 06 6 Spacer, Mounting Block -Pole 5 06 58 Block and Contact Assembly -Pole 60 06 60 Support, Channel Rear Connect 6 Bus, Load 0 -Pole, Rear Connect 0 -Pole, Rear Connect 6 Bus, Normal and Emergency 0 6 -Pole, Rear Connect 0 8 -Pole, Rear Connect 6 Screw, Cap Hex Head (/ 0 x.00) 800 000 -Pole, Rear Connect 800 000 6 -Pole, Rear Connect 6 Washer, Spring Conical (/) 85 00 -Pole, Rear Connect 85 00 8 -Pole, Rear Connect 65 Screw, Hex Washer Head Thread Forming (/ 0) 85 06 6 -Pole, Rear Connect 85 06 8 -Pole, Rear Connect 06 5 Block, Lug Mounting Front Connect (Not Illustrated) Screw, Machine Round Head (/ 0 x.5) (Not Illustrated) 85 0656 -Pole, Front Connect 85 0656 6 -Pole, Front Connect 85 0656 -Pole, Rear Connect 85 06 Screw, Thread Forming (/ 0 x.50) -Pole, Front Connect (Not Illustrated) 85 00 Screw, Thread Forming (/ 0 x.6) -Pole, Front Connect (Not Illustrated) * Switch is actually 08 volts A large transformer in the system reduces the 600 volt system voltage down to 08 volts.
Actuator Handle Assembly 6 5 06 8 Handle Assembly, Actuator 06 8 Handle, Switch Left Hand 06 8 Handle, Switch Right Hand 85 0 Screw, Machine Round Head Cross Recessed (#8 x -/) 85 0 Screw, Machine Round Head Cross Recessed (#0 x -/) 5 80 05 Nut, Self-Locking (#8 ) 6 80 08 Nut, Self-Locking (#0 ) 0
Auxiliary Switch Assembly 5 06 Switch Assembly, Auxiliary 06 0 Bracket, Switch Auxiliary 06 5 Barrier, Switch 85 0686 Screw, Cap Hex Head (#6 x -/) 80 00 Nut, Lock (#6 ) 5 0 0 Switch, Snap-Action
Cabinet Type 8 8 0 6 5 0 6 8 5 5 6
Cabinet Type Door, Cabinet 865 0 50/5 Amp 85 0 60 Amp Cabinet 86 0 50/5 Amp 8 0 60 Amp Harness, Main Level Control 8 88 0 All Except 600 VAC 8 85 0 600 VAC Level Control 8 85 0 All Except 600 VAC 8 85 0 600 VAC Generator to Generator Applications 8 85 0 All Except 600 VAC 8 85 0 600 VAC 00 55 Module, Digital Display 5 Board, Printed Circuit Power Module Level Control 00 58 0 0 VAC 00 58 0 08/0/0/0/80 VAC 00 58 0 600 VAC 00 58 0 0/80/6 VAC Level Control 00 5 0 0 VAC 00 5 0 08/0/0/0/80 VAC 00 5 0 600 VAC 00 5 0 0/80/6 VAC 6 00 580 Board, Printed Circuit Bar Graph 85 05 0 6 Screw, Pan Head (M x 8) 8 5 066 Transformer, Power (600 VAC Only) 85 06 Screw, Hex Washer Head Thread Forming (/ 0 x.50) 0 508 Edge, Protection Washer, Lock W/ET (M5) 85 005 8 50/5 Amp 85 005 60 Amp Screw, Cap Hex Head (M5 x 8) 800 000 8 50/5 Amp 800 000 60 Amp 80 6 Standoff, Male Snap 06 5 Cover, Printed Circuit Board 5 Membrane, Panel Level Control 00 585 Without Digital Display 00 586 With Digital Display Level Control 00 586 Without Meters Bar Graph Display 00 5 With Meters Bar Graph Display 6 6 Lug, Solderless (/ ) 508 05 Edge, Protection 8 Block, Hinge 06 080 50/5 Amp 06 080 60 Amp 5 05 Plug, Hole 0 06 080 Handle, Locking (Includes Hardware and Keys) Latch, Cam 06 0 50/5 Amp ( Point) 06 0 60 Amp ( Point) 5 0 Plug, Hole 06 Rod, Roller (60 Amp) 80 0 Nut, Self-Locking (/ 0) 5 800 000 Screw, Cap Hex Head (/ 0 x.50) 6 Lead (Quantity Used as Required) 6 55 0 6.0 6 55 0.0 Board, Printed Circuit Digital 00 56 Level Control 00 5 0 Level Control 8 06 6 Guide, Rod (60 Amp)
Cabinet Type R and 8 5 8 5 6 6 5 0 0
Cabinet Type R and Door, Cabinet 868 0 50/5 Amp 88 0 60 Amp Cabinet Type R Cabinet 86 0 50/5 Amp 8 0 60 Amp Type Cabinet 86 0 50/5 Amp 8 0 60 Amp Harness, Main Level Control 8 88 0 All Except 600 VAC 8 85 0 600 VAC Level Control 8 85 0 All Except 600 VAC 8 85 0 600 VAC Generator to Generator Applications 8 85 0 All Except 600 VAC 8 85 0 600 VAC 00 55 Module, Digital Display 5 Board, Printed Circuit Power Module Level Control 00 58 0 0 VAC 00 58 0 08/0/0/0/80 VAC 00 58 0 600 VAC 00 58 0 0/80/6 VAC Level Control 00 5 0 0 VAC 00 5 0 08/0/0/0/80 VAC 00 5 0 600 VAC 00 5 0 0/80/6 VAC 6 00 580 Board, Printed Circuit Bar Graph 85 05 0 6 Screw, Pan Head (M x 8) 8 5 066 Transformer, Power (600 VAC Only) 80 0 6 Nut, Hex W/ET (0 ) 0 80 6 Standoff, Male Snap 06 5 Cover, Printed Circuit Board Membrane, Panel Level Control 00 5 Without Digital Display 00 5 With Digital Display Level Control 00 5 Without Meters Bar Graph Display 00 5 With Meters Bar Graph Display 6 Lug, Solderless (/ ) 5 066 5 Plug, Hole 5 06 06 Handle, Door (Includes Key) 6 06 06 Key, Replacement 06 55 Latch, Cam ( Point) 8 Rod, Roller 06 56 0 50/5 Amp 06 56 0 60 Amp 80 0 5 Nut, Self-Locking (/ 0) 0 Lead (Quantity Used as Required) 6 55 0 6.0 6 55 0.0 Board, Printed Circuit Digital 00 56 Level Control 00 5 0 Level Control 508 0 6 Washer, Rubber Gasket, Door 85 0 0 50/5 Amp 85 0 05 60 Amp Gasket, Door 85 0 0 50/5 Amp 85 0 06 60 Amp 5 06 6 Guide, Rod 5
Cabinet Type 5 8 5 8 6 0 5 0 6 6
Cabinet Type Door, Cabinet 8 0 50/5 Amp 88 0 60 Amp Cabinet 80 0 50/5 Amp 880 0 60 Amp Harness, Main Level Control 8 88 0 All Except 600 VAC 8 85 0 600 VAC Level Control 8 85 0 All Except 600 VAC 8 85 0 600 VAC Generator to Generator Applications 8 85 0 All Except 600 VAC 8 85 0 600 VAC 00 55 Module, Digital Display 5 Board, Printed Circuit Power Module Level Control 00 58 0 0 VAC 00 58 0 08/0/0/0/80 VAC 00 58 0 600 VAC 00 58 0 0/80/6 VAC Level Control 00 5 0 0 VAC 00 5 0 08/0/0/0/80 VAC 00 5 0 600 VAC 00 5 0 0/80/6 VAC 6 00 580 Board, Printed Circuit Bar Graph 85 05 0 6 Screw, Pan Head (M x 8) 8 5 066 Transformer, Power (600 VAC Only) 80 0 6 Nut, Hex W/ET (0 ) 0 80 6 Standoff, Male Snap 06 5 Cover, Printed Circuit Board Membrane, Panel Level Control 00 5 Without Digital Display 00 5 With Digital Display Level Control 00 5 Without Meters Bar Graph Display 00 5 With Meters Bar Graph Display 6 Lug, Solderless (/ ) 5 066 5 Plug, Hole 5 80 0 5 Nut, Self-Locking (/ 0) 6 Lead (Quantity Used as Required) 6 55 0 6.0 6 55 0.0 Board, Printed Circuit Digital 00 56 Level Control 00 5 0 Level Control 8 508 0 6 Washer, Rubber Gasket, Door 85 0 0 50/5 Amp 85 0 05 60 Amp 0 Gasket, Door 85 0 0 50/5 Amp 85 0 06 60 Amp 8 0 Screw, Round Head (5/6 8 x.5) 56 00 Washer, Flat (5/6) 0 6 Bracket, Door 06 05 Spring, Conical
Accessory Control Plate (Less than 600 Volt) 5 6 6 8 CP0 0 0 Plate, Relay 0 Bracket, Connector 0 Relay PDT 08 006 Switch, Toggle 5 85 055 0 Screw, Phillips/Hex Head GND (M x 0) 6 85 0 0 5 Screw, Pan Head Crossed Recessed (M x 8) 85 060 0 Screw, Pan Head Crossed Recessed (M x ) 8 0 Cover, Relay Plate 8
Accessory Control Plate (600 Volt) 5 0 6 6 8 R0 0 0 Plate, Relay 0 Bracket, Connector 0 Relay PDT 08 006 Switch, Toggle 5 85 055 0 Screw, Phillips/Hex Head GND (M x 0) 6 85 0 0 Screw, Pan Head Crossed Recessed (M x 8) 85 060 0 Screw, Pan Head Crossed Recessed (M x ) 8 0 Cover, Relay Plate 0 Relay, Control 0 85 058 0 Screw, Pan Head Cross Recessed (M x )
Plate and Wiring Harness (Open Construction) 5 6 8 B00, N0 0 0 Plate, Open Construction 5 066 Plug, Hole Harness, Control (Optional) 8 With Pin Connector (Includes Parts Marked *) 8 0 With 5 Pin Connector (Includes Parts Marked #) * Plug, Connector ( Pin) (P) 5 5 * Cap, Connector ( Pin) (J) 6 *# Socket, Contact 00 8 Wiring Harness 00 5 8 0 Wiring Harness *# Pin, Contact 8 Wiring Harness 5 8 0 Wiring Harness 8 5 # Plug, Connector (5 Pin) (P) 5 # Cap, Connector (5 Pin) (J) * Parts Included in 8 Wiring Harness # Parts Included in 8 0 Wiring Harness 0
Wiring Harness Battery Charger (Generator Set to Generator Set) 6 8 0 5 A0 8 0 Rail, Terminal Plate, Mounting 0 8 Relay, Control ( VDC) 88 Bracket, End 5 85 055 0 Screw, Phillips/Hex Head GND (M x 0) 6 0 Mount, Cable Tie 80 0 Nut, Self-Locking (/ 0) 8 800 0005 Screw, Cap Hex Head (/ 0 x.5) 8 86 Harness, Battery Charger (Includes Parts Marked *) 0 00 * Socket, Contact 606 * Socket, Contact * Pin, Contact 0 * Pin, Contact * Parts Included in 8 86 Wiring Harness
Battery Charger Alarm 8 0 6 5 N00 8 0 Rail, Terminal Block Plate, Mounting 86 0 Block, Terminal (Sectional) 8 Bracket, End Terminal 5 8 Plate, End Terminal 6 85 055 0 Screw, Phillips/Hex Head GND (M x 0) 0 Mount, Cable Tie 8 80 0 Nut, Self-Locking (/ 0) 800 0005 Screw, Cap Hex Head (/ 0 x.5) 0 8 50 Harness, Alarm (Includes Parts Marked *) 0 * Pin, Contact (J) 0 * Housing, Connector (0 Pin) (J) * Parts Included in 8 Wiring Harness
Battery Charger Amp, / Volt 6 8 0 8 5 0 5 6 5 0 0 Wrapper, Charger Battery 0 Cover, Charger Battery 0 080 Ammeter, DC 8 000 Screw, Machine Locking Head Slotted (#0 x 5/6) 5 05 Holder, Fuse 6 05 Fuse, Amp 00 6 Board, Printed Circuit 8 Transformer 5 06 0 0 Volt 5 06 0 08/0/80 Volt 5 06 0 80/6 Volt 5 06 0 600 Volt 0 00 Resistor, Fixed 0 0 0 Resistor, Fixed 0 005 Washer, Centering (/ ) 8 06 Screw, Machine Round Head (#0 x 6-/) 8 0 Screw, Machine Round Head (#0 x -/) 80 0 Nut, Hex W/ET (#0 ) 5 85 085 8 Screw, Pan Head W/ET (#6 x /8) 6 8 Harness, Wiring (Includes Parts Marked #) 8 *Cap, 6 pin (J6) 8 *Plug, pin (P) A/R *Pin, Terminal 0 00 A/R *Socket, Terminal 86 006 5 Nut, Hex W/ET (M5) * Parts Included in 8 Wiring Harness
Battery Charger 0 Amp, Volt 8 0 5 0 6 5 6 5 8
Battery Charger 0 Amp, Volt 00 Wrapper, Charger Battery 00 Cover, Charger Battery 0 8 Ammeter, DC 0 Holder, Fuse (AC Input) 5 00 Holder, Fuse (DC Output) 6 Fuse 50 Hertz 00 0 6/0 Volt 00 0 80 Volt 00 0 0 Volt 00 0 0 Volt 60 Hertz 00 0 80 Volt 00 0 80 Volt 00 0 0 Volt 00 0 08 Volt 00 05 0 Volt 00 0 600 Volt 0 Fuse (5 Amp) 8 Transformer 50 Hertz 5 00 80 Volt 5 00 0/6/0 Volt 5 0 0 Volt 60 Hertz 5 000 0/08/0 Volt 5 006 80 Volt 5 008 80 Volt 5 00 600 Volt 00 60 PCB, Charger Battery 0 05 065 Rectifier, Bridge 8 000 Screw, Machine Locking Head (#0 x 5/6) 85 085 8 Screw, Pan Head W/ET (#6 x /8) 05 08 Rectifier Assembly SCR ( Volt) (Includes Parts Marked *) 85 05 6 Screw, Pan Head W/ET (#8 x 5/8) 5 80 0 5 Nut, Hex W/ET (#8 ) 6 80 06 *Nut, Insulated (#8) 8 Harness, Battery Charger (Includes Parts Marked #) 8 00 A/R #Socket, Terminal 0 A/R #Pin, Terminal 0 8 #Cap, 6 pin 05 #Plug, 5 pin 6 000 *Rectifier, Gate (SCR) 80 005 *Screw, Sheet Metal Round Head (#8 x /) 6 55 0 Lead (Quantity Used as Required) 5 86 006 5 Nut, Hex W/ET (M5) # Parts Included in 8 Wiring Harness * Parts Included in 05 08 Rectifier Assembly 5
Battery Charger 0 Amp, Volt 8 0 5 6 0 5 6 5 8 6
Battery Charger 0 Amp, Volt 00 Wrapper, Charger Battery 00 Cover, Charger Battery (Includes Silkscreen) 0 8 Ammeter, DC 0 Holder, Fuse (AC Input) 5 00 Holder, Fuse (DC Output) 6 Fuse 50 Hertz 00 0 80/6/0 Volt 00 05 0 Volt 00 06 0 Volt 60 Hertz 00 0 600 Volt 00 0 80 Volt 00 0 80 Volt 00 05 0 Volt 00 06 0/08 Volt 0 Fuse (5 Amp) 8 Transformer 50 Hertz 5 005 0/6/0 Volt 5 00 80 Volt 5 0 0 Volt 60 Hertz 5 00 0/08/0 Volt 5 00 80 Volt 5 00 80 Volt 5 0 600 Volt 00 PCB, Charger Battery 0 05 065 Rectifier, Bridge 8 000 Screw, Machine Locking Head (#0 x 5/6) 85 085 8 Screw, Pan Head W/ET (#6 x /8) 05 08 Rectifier Assembly SCR ( Volt) (Includes Parts Marked *) 85 05 6 Screw, Pan Head W/ET (#8 x 5/8) 5 80 0 5 Nut, Hex W/ET (#8 ) 6 80 06 *Nut, Insulated (#8) 8 Harness, Battery Charger (Includes Parts Marked #) 8 00 A/R #Socket, Terminal 0 A/R #Pin, Terminal 0 8 #Cap, 6 pin 05 #Plug, 5 pin 6 000 *Rectifier, Gate (SCR) 80 005 *Screw, Sheet Metal Round Head (#8 x /) 6 55 0 Lead (Quantity Used as Required) 5 86 006 5 Nut, Hex W/ET (M5) # Parts Included in 8 Wiring Harness * Parts Included in 05 08 Rectifier Assembly
Network Module 8 6 5 0 M00 00 55 Board, Printed Circuit Network Module 8 0 Rail, Terminal Block 86 0 Block, Terminal (Sectional) 8 Bracket, End Terminal 5 8 Plate, End Terminal 6 85 05 0 Screw, Pan Head (M x 0.5 x 8) 80 0 Standoff, Hex Thread (M) 8 85 055 0 Screw, Phillips/Hex Head GND (M x 0) 8 886 Harness, Network 0 Battery Lithium (.0V) (Purchase Locally) 6 0 Clip, Battery 8
Current Transformer Module 6 0 8 5 M0 00 55 Board, Printed Circuit Current Module 85 05 0 Screw, Pan Head (M x 8) 8 88 0 Harness, Current Module (Includes Parts Marked *) 806 05 * Connector, Receptacle (0 Pin) 5 606 0 * Socket, Contact 6 Lead 6 0 5 (Marked J0, GND) 6 0 (No Markings) 0 Mount, Cable Tie 8 Plate, Mounting 80 0 Nut, Self-Locking (/ 0) 0 800 0005 Screw, Cap Hex Head (/ 0 x.5) Transformer, Current 50 Amp 0 8 0 VAC 0 8 Phase, or Wire 0 8 Phase, or Wire 5 Amp 0 00 0 VAC 0 00 Phase, or Wire 0 00 Phase, or Wire 60 Amp 0 0 VAC 0 Phase, or Wire 0 Phase, or Wire * Parts Included in 8 88 0 Wiring Harness
Terminal Block A0,K00,K00,K00 8 0 Rail, Terminal Block 86 0 Block, Terminal (Sectional) 8 Bracket, End Terminal 8 Plate, End Terminal 0
Auxiliary Relay L0,0,0,0,0,0,0,0 8 0 Rail, Terminal Relay, Control 0 8 VDC 0 8 VDC 88 Bracket, End 85 055 0 Screw, Phillips/Hex Head GND (M x 0)
Load Shed 8 5 6 M00,R0 Harness, Load Shed 8 86 0 All Except 600 Volt 8 86 0 600 Volt 0 Relay PDT ( VDC) 0 Mount, Cable Tie 85 0 0 Screw, Pan Head (M x 8) 5 00 55 Board, Printed Circuit Relay Module 6 85 05 0 Screw, Pan Head (M x 8) Plate, Mounting 8 80 0 Nut, Self-Locking (/ 0) 800 0005 Screw, Cap Hex Head (/ 0 x.5)
Front Panel Security M0 08 0 Switch, Selector Lead 6 0 (Marked S0 J 5) 6 0 6 (Marked S0 J )
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 6 80, 05 065, 5, 06 0 0, 06 0 0, 6 55 0,, 5, 05 08, 5, 06 0 0, 06 0 05, 6 55 0,, 5,, 5, 6 0, 6 0, 6 0, 6 0, 00 6, 00 60, 5 00, 00 56,, 5, 00 5 0,, 5, 00 58 0,, 5, 00 58 0,, 5, 00 58 0,, 5, 00 58 0,, 5, 00 5 0,, 5, 00 5 0,, 5, 00 5 0,, 5, 00 5 0,, 5, 00 55,, 5, 00 55, 00 55, 8 00 580,, 5, 00 585, 00 586, 00 55, 00 5, 00 5, 5, 00 5, 5, 00 5, 5, 0 6, 0 0, 0, 0 00, 0 080, 0, 0 8, 0 8, 5, 0 005, 0 00, 0 0, 06 068, 06 0508, 06 8, 0 06 8, 0 06 6, 06 8,, 0 06 0, 06 5, 06, 06 00 0, 06,, 06 8, 06 0, 06 6,, 5 06 0, 06 0, 06 0, 06 05, 06 06, 06, 06 8, 06 8, 06 55, 5 06 56 0, 5 06 56 0, 5 06 5, 06 5, 06 55, 06 56, 06 58, 06 60, 06 6, 06, 06 0 0, 06 0 0, 06 080 0, 06 080 0, 06 6, 06 0 0, 06 0 0, 06 0 05, 06 0 06, 06 0 0, 06 0 08, 06 0 0, 06 0 0, 06 0, 06 0, 06 0, 06 0, 06 0 5, 06 05 0, 06 05 0, 06 05 0, 06 05 05, 06 05 0, 06 05 08, 06 05 0, 06 05 0, 06 05, 06 05, 06 05, 06 05 5, 06 06 0, 06 06 0, 06 06 0, 06 06 0, 06 06 05, 06 06 06, 06 06 0, 06 06 08, 06 06 0, 06 06 0, 06 06, 06 06, 06 06, 06 06, 06 06 5, 06 0 0, 06 0 0, 06 0 0, 06 0 08, 06 0 0, 06 0 0, 06 0, 06 0, 06 0, 06 0 5, 06 5,, 5, 0 8,, 0 8, 0, 8,, 0, 08 006, 8, 08 0, 0 0, 00, 00, 00, 5 06 0, 5 06 0, 5 06 0, 5 06 0, 5 066,, 5, 5 000, 5 5 00, 5 00, 5 5 00, 5 00, 5 5 005, 5 006, 5 5 00, 5 008, 5 5 00, 5 00, 5 5 0, 5 0, 5 5 0, 00, 5, 00, 5,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 86 0, 8,, 5, 8 85 0,, 5, 85 05, 865 0, 05, 5, 8 85 0,, 5, 85 05, 5, 86 0, 5 0, 8 86 0, 85 065, 86 0, 5 0, 8 86 0, 85 065, 868 0, 5 806 05, 8 88 0, 85 0656, 80 0, 0,,,, 8 886, 8 85 066, 8 0, 5, 6 000, 5, 85 0686, 8 0, 605, 06 05, 85 0 0, 8,, 85 0, 05, 06 06, 5 85 085,, 5, 8 0, 5 8, 06 06, 5 85 0, 0 8 0, 5 86 0, 8 06 080, 85 0, 0 88 0, 5 880 0, 88 0, 0 0, 8, 0, 8, 0, 8,,,,, 0 0, 0 0 0606, 0 0608, 0 060, 00, 5, 0, 5, 05, 05, 0, 5, 00 0, 5, 00 0, 5 00 0, 5 00 0, 5, 00 0, 5, 00 05, 5, 00 06,, 0,, 00, 0,,, 5, 5, 0 5, 0, 0,, 5,, 0 86 0,, 0 8 0,, 8, 0 8,, 8, 0 8,, 8, 0 88,, 8 0, 8 0, 0, 08, 0, 606,, 6,, 5, 65, 66, 0, 0, 0 0, 0 0, 0 0,, 8, 8, 0 8 0, 0 8, 5, 8 50, 8, 8 86, 8 88 0,, 5, 8 85 0,, 5, 8 85 0,, 5, 06 080, 06 0, 06 0, 6 0, 8 508 0, 5, 508 05, 508, 5 05, 5 0, 5 066, 5,, 0 56 0008, 56 008, 56 00, 56 00, 800 000,, 800 0005,,,, 800 000, 800 0008, 800 00, 800 00, 800 008, 800 000, 800 000, 80 005, 5, 8 0, 8 0, 8 06, 85 00, 85 06,, 85 00, 85 055 0, 8,,,, 8, 85 058 0, 85 05 0,, 5,, 8,, 85 060 0, 8, 8 000,, 5, 850 000, 85 00, 85 008, 85 006, 85 005, 86 000, 86 005, 86 006 5,, 5, 80 0,, 5,, 80 00, 80 0,, 5,,,,, 80 0, 5, 80 05, 0 80 06, 5, 80 08, 80 08, 0 80 00, 80 0, 8 80 6,, 5, 85 0 0, 5, 85 0 0, 5, 85 0 05, 5, 85 0 06, 5, 5, 0 8 85 0,, 5, 85 06, 5
Cummins Power Generation 00 rd Avenue N.E. Minneapolis, MN 55-800-888-666 6-5-5000 International Use Fax: 6-5-808 Cummins is a registered trademark of Cummins Inc.