Zone and - and Applications For use in locations where: Hazardous areas are designated as Zone and and A high degree of corrosion resistance is required Protection against dirt, water and moisture is necessary Typical applications include: Oil refineries Petrochemical facilities Food processing plants Waste and water treatment plants Underground tunnels General manufacturing facilities Features Easy to retrofit in same mounting footprint as Appleton s FE series nonmetallic fluorescent luminaires. Full range of lumen outputs, with light distribution equivalent to Appleton s FE series fluorescent luminaires. Corrosion-resistant fiberglass reinforced polyester body and hinged polycarbonate lens. High impact resistance housing ( Joules IK) from - C to +5 C/+55 C ambient temperature and wind profile for use in extreme offshore and onshore environments. 6,+ hour ED life for years of maintenance free operation. ightweight design, hinged cover with captive screws, and terminal block wiring for easy installation and maintenance. Standard screw-type terminal block can accept to 6 mm wire. Contemporary, low profile design suitable for tight spaces Field replaceable ED driver and lens. Industry-leading thermal management for safe, reliable operation over wide temperature range. M plug or M5 plug provided. Universal, high efficiency, drivers cover voltage requirements for - Vac, 5/6 Hz +/- %. High power factor electronic ballast (>.95). Standard KV surge suppression. atch assembly and elastomer gasket seals against water and dust ingress, IP66. Easily accessed for maintenance using Allen key or straight blade screwdriver. Central opening with unique patented release system to prevent damage. Can be horizontally or vertically mounted. Positive safety switch disconnects power to ED s and driver to allow maintenance in hazardous locations. Available in hour emergency version, including built-in monthly self- test. Test results through multi-colored ED Ex e battery with plug-in connector. Options Hours Emergency/Battery Back-Up available ; Add suffix -E to the end of the catalog number. Example: FEED5BDSADE Diffused lens is available; Add suffix -D to the end of the catalog number. Example: FEED5BDSAD Standard Materials Housing: fiberglass reinforced polyester ens: polycarbonate Gasket: elastomer Internal reflector: highly reflective white powder coated aluminum Mounting accessories available in different materials such as gray painted aluminum, zinc plated steel, galvanized steel or 6 stainless steel Certifications and Compliances Certification ATEX/IECEx Certification Type: FEED Gas: Zones and Conforming to ATEX //EU: II G Type of Protection: Ex db eb mb IIC Gb Temperature Class: T6 to T Dust: Zones and Conforming to ATEX //EU: II D Type of Protection: Ex tb IIIC Db Surface Temperature: +78 C to 96 C Ambient Temperature: - C up to +5 C/+55 C EU Declaration of Conformity: 57 ATEX Certificate: CIE 6 ATEX 8X IECEx Certificate: IECEx CIE 6.8X Index of Protection according E/IEC 659: IP66 Impact Resistance (shock): IK Available for 5K lumen models only. Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft
Zone and - and Order using catalog numbering guide below or select catalog number from tables on following pages. Catalog umbering Guide FEED Series onmetallic ED uminaries FEED BD S A D Series: FEED - FEED Series Zone,,, ATEX/IECEx Certified umen Output: - K umen Output - K umen Output 5-5K umen Output 7-8K umen Output Mounting Version: S - Surface/Suspension Mount Standard Wiring (single phase) - Surface/Suspension Mount Dual oop In/Out Through Wiring (single phase) Cable Entry Type: A - Armored M - Unarmored M5 Voltage: BD - to Vac, 5/6 Hz Options: D - Diffused ens E - H Emergency (combined) amp Comparison Chart Catalog umber FEEDBDSA FEEDBDS FEEDBDA FEEDBD FEEDBDSA FEEDBDS FEEDBDA FEEDBD FEED5BDSA FEED5BDS FEED5BDA FEED5BD FEED7BDSA FEED7BDS FEED7BDA FEED7BD ine Current Amps.A @ V.A @ V.A @ V.8A @ V.A @ V.8A @ V.86A @ V.6A @ V Input Power Power Factor umen Output (umens) Clear Polycarbonate ens Diffused Polycarbonate ens Color Rendering Index (CRI) Correlated Color Temperature (CCT) ength m W >.95 7 565.785 W >.95 7 565.785 W >.95 6 5 7 565.9 86W >.95 85 79 7 565.9 Available for 5K lumen models only. All values displayed reflect typical values. Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and Technical Data Model Type Position Horizontal/ Vertical Diffused ens Gas Dust T Rating Surface T Ta= + C Ta= +5 C Ta= +55 C Ta= + C Ta= +5 C Ta= +55 C With K umens Standard With T6 T5 T5 8 C 9 C 95 C With T5 T K umens Standard With T6 T5 T5 86 C 96 C 5K umens Standard With With T6 T6 T5 T5 78 C 88 C 9 C With 5K umens Emergency With T6 T5 79 C 89 C Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft
Zone and - and Technical Data Model Type Position Horizontal/ Vertical Diffused ens Gas Dust T Rating Surface T Ta= + C Ta= +5 C Ta= +55 C Ta= + C Ta= +5 C Ta= +55 C With T5 T 8K umens Standard With T6 T5 86 C 96 C T umbers Represent the Maximum Temperature T # T T T T T5 T6 Temp. Range ºC -5-6- -5 86-85 Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and Catalog umbers Conduit/Cable Entries Voltage Ambient Temperature Weight kg with Diffused Polycarbonate Standard K umens.6 m ( ft) M Standard M5 Standard / Vac - C up to +55 C 6. FEEDBDSAD FEEDBDSD M Dual oop In/oop Out M5 Dual oop In/oop Out / Vac - C up to +55 C 6. FEEDBDAD FEEDBDD Standard K umens.6 m ( ft) M Standard M5 Standard / Vac - C up to +5 C 6. FEEDBDSAD FEEDBDSD M Dual oop In/oop Out M5 Dual oop In/oop Out Standard 5K umens. m ( ft) M Standard M5 Standard / Vac - C up to +5 C 6. / Vac - C up to +55 C 9. FEEDBDAD FEEDBDD FEED5BDSAD FEED5BDSD M Dual oop In/oop Out M5 Dual oop In/oop Out / Vac - C up to +55 C 9. FEED5BDAD FEED5BDD Standard 8K umens. m ( ft) M Standard M5 Standard / Vac - C up to +5 C. FEED7BDSAD FEED7BDSD M Dual oop In/oop Out M5 Dual oop In/oop Out / Vac - C up to +5 C. FEED7BDAD FEED7BDD M entries are with brass earth continuity plate for armored cable. M5 entries are for non-armored cable. Standard cable entry provides entries; at one and at the other end of the housing. oop In/oop Out through cable entry provides entries; at one and at the other end of the housing. Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft 5
Zone and - and Catalog umbers Conduit/Cable Entries Voltage Ambient Temperature Weight kg with Diffused Polycarbonate Emergency 5K umens. m ( ft) M Standard M5 Standard M Dual oop In/oop Out M5 Dual oop In/oop Out / Vac - C up to +5 C.5 / Vac - C up to +5 C.5 FEED5BDSADE FEED5BDSDE FEED5BDADE FEED5BDDE M entries are with brass earth continuity plate for armored cable. M5 entries are for non-armored cable. Standard cable entry provides entries; at one and at the other end of the housing. oop In/oop Out through wire cable entry provides entries; at one and at the other end of the housing. 6 Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and Wiring Diagrams Standard Version : Version : S Dual oop In/Out - Through Wiring (Single Phase) Standard (Single Phase) entries, at one end and at the other entries, at one end and at the other Emergency Version : Version : S Dual oop In/Out - Through Wiring (Single Phase) Standard (Single Phase) entries, at one end and at the other entries, at one end and at the other Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft 7
Zone and - and Wiring Diagram Mains ighting Switch Emergency Function Diagram Mains ighting Switch O ighting Switch OFF O U Standard Fluorescent ighting Fixture OFF U U Emergency Fluorescent ighting Fixture ED Status Color Indication Function Green ED Blinking Mains good Battery charged ED Continuous Mains good Battery connected and loaded Green and Red ED Blinking Alternately Mains good Battery in repair mode ED Blinking o battery connected OR Something is defective Red ED Continuous Mains faulty Output O in emergency mode ED Flashing Mains faulty Battery empty OR amp is defective Yellow (Orange) and another color ED Blinking Alternately Mains good ast automatic or manual operational check has been unsuccessful one (Off) o ight Emitted o mains Battery completely empty Self-Test In month intervals batteries are automatically discharged and recharged once. Emergency ight Duration Version Battery Capacity Duration ight Output 5K 7 Ah 6V hours 5% 8 Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and Accessories and Replacement Parts Description Catalog umber Fixing Brackets Set of two brackets for surface installation Zinc plated steel FEFBZ Brackets for Surface Mounting Set of two 6 stainless steel FESBS M8 Ring Bolts Set of two Zinc plated steel FERBM8Z Half Clamps Brackets for Pole Mounting Hinged Brackets Fall Prevention Kit Set of two Diameter for -/ to -/" pole: mm to 9 mm Zinc plated steel FEHC9Z 6 stainless steel FEHC9S Diameter for " pole: 6 mm Zinc plated steel FEHC6Z 6 stainless steel FEHC6S Set of two brackets for adjusting luminaire Aluminum FEHBA 6 stainless steel FEHBS Safety chain retains fixture temporarily to ease installation For M5 cable entry For M cable entry FESCM5 FESCM Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft 9
Zone and - and Accessories and Replacement Parts Replacement Drivers and Inverters Description Catalog umber K (qty:) driver for standard version (Z9) Z9 K, 5K (qty:) driver for standard version (Z98) FEEDSDBD 8K set of two drivers for standard version (Z98 + Z99) 5K Inverter for emergency version (Z9) FEED7SDBD FEED5EIBD Replacement ens.6 m (. ft) clear polycarbonate external lens with gasket Z65. m (. ft) clear polycarbonate external lens with gasket Z65 Replacement Diffuser Replacement ED Arrays.6 m (. ft) diffused internal lens for K and K versions FEEDDP. m (. ft) diffused internal lens for 5K and 8K versions FEEDDP ED array for K versions FEEDA ED array for 5K versions ED array for K version (qty:) and for 8K version (qty: ) FEED5A FEEDA Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and Mounting Options Dimensions in Millimeters (Inches) FEFBZ: zinc plated steel Set of two quick fixing brackets for ease of surface mounting 9. mm (.5") 6 mm (.5") 9. mm (.6") mm (.8") 8.5 5. mm (.98") 9. mm (.9") 8.5 mm (.") FESBS: 6 stainless steel Set of two brackets for surface mounting 8. mm (.5") mm (9.") mm (7.87"). mm (.5") 9.5 mm (.7") 9.5.5.5 mm (.57"). mm (.6") FERBM8Z: zinc plated steel Set of two ring bolts. mm (.79") 6. mm (.") 8. mm (.") 5. mm (.59") M8x.8 mm (.5") M 8 x.5 Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft
Zone and - and Mounting Options Dimensions in Millimeters (Inches) FEHC9Z: zinc plated steel or FEHC9S: 6 stainless steel Set of two clamps for pole diameter mm to 9 mm (for -/ to -/" pole). FEHC6Z: zinc plated steel or FEHC6S: 6 stainless steel Set of two clamps for pole diameter 6 mm (for pole). 75. mm (.95 ) 95 for.8 mm (.5") or 8. mm (.5"). mm (.55 ).8 mm (.5") or 8. mm (.5") or 8 for 5.8 mm (.") 85 mm (. ) Ø 6 mm (.6 ). mm (.55 ) 5.8 mm (.") FEHBA: aluminum or FEHBS: 6 stainless steel Set of two hinged brackets for adjusting luminaire. 5.5 mm (. ) 77. mm (. ) 6 9 6 9 8. mm (. ). mm (.9 ). mm (.6 ).5 mm (.57 ) 8. mm (.7 ) mm (5. ). mm (.6 ) M8x.8 mm (.5"). mm (.5 ) 9.5 mm (.7 ) Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and uminaire Dimensions in Millimeters (Inches) 7. mm (8.5") End View 5. mm (5.7"). mm (5.75") X M8 785. mm (.9") Side View.785 m (.58 ft) 7. mm (7.56") 9. mm (5.7") X M8 Side View.9 m (.56 ft) Version Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft
Zone and - and Photometric Data DATA SHOW IS ABSOUTE FEED K without Diffuser Zonal umens and Percentages at 5 C Zone umens Zone umens % uminaire - 6. - 57.8. - 79. - 876.9 6. - 77. -6 6 67. - 59. 6-9 75.. -5 78. -9 7 98. 5-6 66. 9-8 7..9 6-7.7-8. 7-8 56.7 8-9 6. 9-. - 8.8 -. -.7 -.8-5. FEED K with Diffuser Zonal umens and Percentages at 5 C Zone umens Zone umens % uminaire - 59.5-9.8. - 7. - 8. 6.9-6. -6 5 66. - 9. 6-9 6. 7.5-5. -9 57 9.7 5-6 7.8 9-8 8.8 6. 6-7 58. -8 96. 7-8.8 8-9. 9-8. - 5.9 -.8 -.9 -.8-5. 58 67 5 7 7 5 67 58 7 Polar Candela Distribution 8 7 6 5 7 - H -9 H Polar Candela Distribution 8 7 6 5 6 55 5 5 5 5 55 6 - H -9 H 9 8 7 6 5 -.5 H -5 H -67.5 H 9 8 7 6 5 -.5 H -5 H -67.5 H Isoillumination Plot fc fc 5 fc.5 fc.5 fc. fc. fc Distance in units of mount height ( ft) Isoillumination Plot fc fc 5 fc.5 fc.5 fc. fc. fc Distance in units of mount height ( ft) Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and Photometric Data DATA SHOW IS ABSOUTE FEED K without Diffuser umens Per Zone Zonal umen Summary Zone umens Zone umens % uminaire -.6-97..8-8.5-598.8 6.8-56.9-6 9. 67.6-65.9 6-9 8.6.6-5 68. -9 69.7 98. 5-6 658.9 9-8 78.6.8 6-7 589. -8 8. 7-8 5. 8-9 86.5 9-57. -.5-6. -.7 -. -5. FEED K with Diffuser umens Per Zone Zonal umen Summary Zone umens Zone umens % uminaire -.9-95..6-8.6-56.6 7. - 85.8-6 69.6 66. - 59. 6-9.9 7.5-5 66.6-9 88.5 9.9 5-6 57. 9-8 9. 6. 6-7 8.5-8 57.8. 7-8 7.8 8-9 6.6 9-9. - 69. -. - 6. -. -5.,8, Polar Candela Distribution 8 7 6 5,,8 867 65 7 7 65 867 - H -9 H Polar Candela Distribution 9 8 7 6 5 -.5 H -5 H -67.5 H 8 7 6 5,, 8 6 6 8,, - H -9 H 9 8 7 6 5 -.5 H -5 H -67.5 H Isoillumination Plot UX 5 UX.5 UX UX.5 UX. UX. UX Distance in units of mount height ( ft) Isoillumination Plot UX 5 UX.5 UX UX.5 UX. UX. UX Distance in units of mount height ( ft) Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft 5
Zone and - and Photometric Data DATA SHOW IS ABSOUTE FEED 5K without Diffuser Zonal umens and Percentages at 5 C Zone umens Zone umens % uminaire - 7. - 986.7. - 9.9-668 6. - 59.7-6 85 66.9-68. 6-9. -5 7. -9 59 98. 5-6 76. 9-8 8.5.8 6-7 6. -8 6. 7-8 88.5 8-9.5 9-68.8-9. -. -. -. FEED 5K with Diffuser Zonal umens and Percentages at 5 C Zone umens Zone umens % uminaire - 6. - 88..8-6. - 66 6. - 7.5-6 65 65.5-58. 6-9 8. -5 6.6-9 788 9.6 5-6 57.9 9-8 6.8 6. 6-7 85. -8 9. 7-8 8. 8-9 69. 9-56.6-69. - 6.6-7. -.,8 867 69 7 7 65 867,8, Polar Candela Distribution 8 7 6 5, - H -9 H Polar Candela Distribution 8 7 6 5,,89 867 69 7 7 65 867,8, - H -9 H 9 8 7 6 5 -.5 H -5 H -67.5 H 9 8 7 6 5 -.5 H -5 H -67.5 H 5 5 Isoillumination Plot fc fc 5 fc.5 fc.5 fc. fc. fc Distance in units of mount height ( ft) Isoillumination Plot fc fc 5 fc.5 fc.5 fc. fc. fc Distance in units of mount height ( ft) 6 Visit our website at www.appletonelec.com or contact us at +...5.7.5. January 7 draft
Zone and - and Photometric Data DATA SHOW IS ABSOUTE FEED 8K without Diffuser Zonal umens and Percentages at 5 C Zone umens Zone umens % uminaire - 6.6-8. - 6.6-96 6. - 98.7-6 576 67. - 67 6-9 68.9-5 6-9 88 98. 5-6 9-8 5..8 6-7 6-8 85. 7-8 897. 8-9 579.8 9-8. - 9.5-8. -.6 -.7 FEED 8K with Diffuser Zonal umens and Percentages at 5 C Zone umens Zone umens % uminaire - 9. - 7.9-6.7-886 6. - 97.9-6 56 65.7-5 6-9 7.9-5 -9 76 9.6 5-6 9 9-8 58. 6. 6-7 95. -8 795. 7-8 7.8 8-9 5.5 9-7.7-6.9-5. -.5 -.9,,6, 8 8,,6,, Polar Candela Distribution 8 7 6 5, - H -9 H Polar Candela Distribution 8 7 6 5,,97,5,5 767 8 8 767,5,5,97, - H -9 H 9 8 7 6 5 -.5 H -5 H -67.5 H 9 8 7 6 5 -.5 H -5 H -67.5 H 5 Isoillumination Plot 5 fc fc fc.5 fc 5 fc. fc.5 fc. fc Distance in units of mount height ( ft) 5 Isoillumination Plot 5 fc fc fc.5 fc 5 fc. fc.5 fc. fc Distance in units of mount height ( ft) Visit our website at www.appletonelec.com or contact us at +...5.7.5.. January 7 draft 7