Technical Data Sheet Opto Interrupter Features Fast response time High analytic Cut-off visible wavelength λp=94nm High sensitivity Pb free This product itself will remain within RoHS compliant version ITR968-F Descriptions The ITR968-F consist of an infrared emitting diode and an NPN silicon phototransistor, encased side-by-side on converging optical axis in a black thermoplastic housing, The phototransistor receives radiation from the IRED only.this is the normal situation. But when an object is in between, phototransistor could not receives the radiation. For additional component information, please refer to IR928-6C-F and PT928-6C-F Applications Mouse Copier Switch Scanner Floppy disk driver Non-contact Switching For Direct Board Device Selection Guide Device No. Chip Material LENS COLOR IR928-6C-F GaAlAs Water clear PT928-6C-F Silicon Water clear Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev1 Page: 1 of 6 Device No:CDRX-96-18 Prepared date:26/12/27 Prepared by:kunjiang Xie
Package Dimensions ITR968-F Notes: 1.All dimensions are in millimeters 2.Tolerances unless dimensions ±.2mm 3.Lead spacing is measured where the lead emerge from the package 4.Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification 5.These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don't reproduce or cause anyone to reproduce them without EVERLIGHT's consent 6.When using this product, please observe the absolute maximum ratings and the instructions for use outlined in these specification sheets. EVERIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev1 Page: 2 of 6 Device No:CDRX-96-18 Prepared date:26/12/27 Prepared by:kunjiang Xie
Absolute Maximum Ratings (Ta=25 ) Input Output ITR968-F Parameter Symbol Ratings Unit Power Dissipation at(or below) 25 Free Air Temperature Pd 75 mw Reverse Voltage V R 5 V Forward Current I F 5 ma Peak Forward Current (*1) Pulse width 1μs, Duty cycle=1% I FP 1 A Collector Power Dissipation Pd 75 mw Collector Current I C 2 ma Collector-Emitter Voltage B V CEO 3 V Emitter-Collector Voltage B V ECO 5 V Operating Temperature Topr -25~+85 Storage Temperature Tstg -4~+85 Lead Soldering Temperature (*2) Tsol 26 (1/16 inch form body for 5 seconds) (*1) tw=1 μsec., T=1 msec. (*2) t=5 Sec Electro-Optical Characteristics (Ta=25 ) Input Output Parameter Symbol Min. Typ. Max. Unit Conditions Forward Voltage V F --- 1.2 1.5 V I F =2mA Reverse Current I R --- --- 1 μa V R =5V Peak Wavelength λ P --- 94 --- nm I F =2mA View Angle 2θ1/2 --- 4 --- Deg I F =2mA Dark Current I CEO --- --- 1 na V CE =2V,Ee=mW/cm 2 C-E Saturation Voltage V CE (sat) --- ---.4 V I C (ON) 2.5 --- --- ma Collect Current I C (OFF) --- --- 2 μa Transfer Rise time t r --- 15 --- μsec Characteristics Fall time t f --- 15 --- μsec I C =2mA,Ee=1mW/cm 2 V CE =5V I F =2mA V CE =5V I C =1mA R L =1KΩ Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev1 Page: 3 of 6 Device No:CDRX-96-18 Prepared date:26/12/27 Prepared by:kunjiang Xie
Typical Electrical/Optical/Characteristics Curves for IR Fig.1 Forward Current vs. Fig.2 Spectral Distribution ITR968-F 7 6 5 4 3 2 1-4 -2 2 4 6 8 1 1 8 6 4 2 IF=2mA Ta=25 C Fig.3 Peak Emission Wavelength vs. 98 Fig.4 Forward Current vs. Forward Voltage 1 4 96 94 92 3 1 1 2 9-25 25 5 75 1 1 1 1 2 3 4 Fig.5 Forward Voltage vs ( C) 1.3 Fig.6 Relative Radiant Intensity vs. Angular Displacement -2-1 1 2 3 1.2 IF=2mA 1. 4 1.1 1 25 5 75 1 12.9.8.7.6.4.2.2.4.6 5 6 7 8 Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev1 Page: 4 of 6 Device No:CDRX-96-18 Prepared date:26/12/27 Prepared by:kunjiang Xie
Typical Electrical/Optical/Characteristics Curves for PT Fig.1Collector Power Dissipation vs. Fig.2 Spectral Sensitivity 1 8 6 ITR968-F 4 2-25 25 5 75 85 1 Fig.3 Relative Collector Current vs. 16 14 12 1 1 1 1 8 6 4 2 2 1 2 3 4 5 6 7 Fig.5 Collector Dark Current vs. Fig.4 Collector Current vs. Irradiance 1 1 1.1 14 12 1 8 6 C.1.5 1 1.5 Fig.6 Collector Current vs. Collector-Emitter Voltage 2 3 1 4 1 25 5 75 1 2 1 2 3 4 Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev1 Page: 5 of 6 Device No:CDRX-96-18 Prepared date:26/12/27 Prepared by:kunjiang Xie
Reliability Test Item And Condition The reliability of products shall be satisfied with items listed below. Confidence level:9% LTPD:1% NO. Item Test Condition Test Hours/ Cycle Sample Size ITR968-F Failure Judgement Ac/Re Criteria 1 Solder Heat TEMP : 26 ± 5 1 sec 22 PCs /1 H : +1 15 mins 2 Temperature Cycle 5 min 3 cycle 22 PCs I C(on) L.8 /1 L : -4 H : +1 15 min 5 min 3 Thermal Shock 1 sec 3 cycle 22 PCs L :the initial test value /1 4 High Temperature Storage 5 Low Temperature Storage 6 DC Operating Life 7 High Temperature / High Humidity L : -1 5 min TEMP. : +1 1 TEMP. : -4 1 V CE =5V 1 I F =2mA 85 / 85% R.H. 1 22 PCs /1 22 PCs /1 22 PCs /1 22 PCs /1 EVERLIGHT ELECTRONICS CO., LTD. Tel: 886-2-2267-2, 2267-9936 Office: No 25, Lane 76, Sec 3, Chung Yang Rd, Fax: 886-2267-6244, 2267-6189, 2267-636 Tucheng, Taipei 236, Taiwan, R.O.C http:\\www.everlight.com Everlight Electronics Co., Ltd. http:\\www.everlight.com Rev1 Page: 6 of 6 Device No:CDRX-96-18 Prepared date:26/12/27 Prepared by:kunjiang Xie