Shuttle Oven Models: S100, S000, S000NC Need help? Call our hour, toll-free Ovention Hotline Replacement Parts List IMPORTANT NOTE: Locate the Specification Label on the unit to determine the exact Model Name and electrical specifications. This information is needed to identify the correct replacement parts. See exploded view illustration(s) for Specification Label location. CAUTION Use of replacement parts other than those supplied by Ovention may result in damage to the unit or injury to personnel and will void all warranties. 018 Ovention, Inc.
Ovention Shuttle Oven Front Component Replacement Parts Model S000 shown. 1 7 8 9 10 Specification Label located on the side of the left component cover. 11 1 1 1 1 1 Shuttle Door, Left S100 0709-011 1 S000 070-01 1 Conveyor End Stop S100 (Left, ") 0709-08 1 S000 070-0 Crumb Tray S100 0709-0 S000 070-0 Latch 0.0.197.00 Leg, " 0.0.19.00 Jet Plate Assembly S100 0709-00 S000 070-00 7 Shuttle Door, Right S100 0709-010 1 S000 070-01 1 8 Drive Belt S100 0..07.00 1 S000 0..08.00 1 9 Belt Cover S100 0709-07 1 S000 070-08 1 10 Drive Wheel 0..07.00 1 11 Conveyor End Stop, Right, ʺ (S100 only) 0709-087 1 1 Thumbscrew, Eyebrow 0.0.19.00 1 Power Cord w/plug S100, 08/0 V, 1Ф 0.18.01.00 1 S100 (80 W Heater), 0.18.7.00 1 08/0 V, 1Ф S100, 0 V, 1Ф 0.18.9.00 1 S100, 0/00 V, Ф 0.18.8.00 1 S000, 08/0 V, 1Ф 0.18.7.00 1 1 Hinge, Female, Left 0.1.007.00 1 1 Hinge, Male Right 0.1.00.00 1 Wiring Diagram S100 08/0 V, 1Ф 10-01-117 0 V, 1Ф 10-01-17 0/00 V, Ф 10-01-1 S000 10-01-11
Door Replacement Parts 1 7 8 9 10 11 1 1 1 1 1 17 18 19 0 S100 only Model S000 shown. 1 1 UI Board S100 R0700-00-S10 1 S000, 1Ф R0700-00-S01 1 S000, Ф R0700-00-S0 1 Fish Paper Insulator 0709-011 1 LCD Assembly w/bracket, ʺ R0.01.78.00 LCD Spacer Film 0..09.00 Cooling Fan Assembly (includes two fans) S100 R0.1.18.00 1 S000 R0.1.190.00 1 Wire Nut, Lever, Pole 0.0.1.00 7 Latch Keeper 0.0.198.00 8 Trim Bezel S100 0709-01 1 S000 070-00 1 9 Touchscreen Overlay S100 070-000 1 S000 0701-000 1 Ф = Phase For units with date code 1817 and older, use USB Cable P/N 0.0..00. 10 Mounting Bracket, Connector Kit 0..7.00 1 11 Hinge, Male, Left 0.1.00.00 1 1 Door Connector Kit (includes item 10) R0.1.0.00 1 1 Fan Guard 0.1.1.00 1 Standby Switch 0.19..00 1 1 Window Plug 0.0..00 1 Cover, USB 0.0..00 1 17 Adapter, USB 0.0..00 1 18 Mounting Bracket, USB 0..71.00 1 19 USB Cable, 0ʺ 0.0.8.00 1 0 Hinge, Female, Right 0.1.008.00 1 1 Toast Catcher Kit (S100 only) R0..1.00 1 Wire Harness, UI Board to Door Connector (not shown) 0.18..00 1 NOTE: The last four digits in a ten digit numerical serial number are the manufacturing date code: 9010 Year 01 Week Four The shaded areas contain information for International models only.
Rear Component Replacement Parts 1 Rear, Right View 1 1 1 17 18 19 0 1 Model S000 shown. 7 8 9 10 11 1 1 7 8 9 0 1 7 8 9 0 Rear, Left View 1 9 17 1 1 19 0 1 7 8 18
1 Back Cover S100 0709-08 1 S000 070-0 1 Rear Standoff (S100 only) 0701-1 1 Heater w/mounting Plate S100, 1Ф, 00 W, US 070-0 1 S100, 1Ф, 00 W, CA 070-01 1 S100, 1Ф, 80 W, US 0709-09 1 S000, 1Ф, 0 W, US 0701-11 S000, 1Ф, 000 W, CA 0701-0 S000, Ф, 700 W, USCA 070-1 Hex Screw w/washer S100 0.0.771.00 1 S000 0.0.771.00 High Limit Hold Down Clamp 0701-9 1 Cord Grip S100, 0 A 0.0.90.00 1 S100/S000, 0 A 0.0.09.00 1 7 Thermocouple, Left S100 0.01.77.00 1 S000 0.01..00 1 8 Thermal Cutoff 0.1.17.00 1 9 RFI Filter, 0 A (S100, 1Ф only) 0.1.7.00 1 10 Fan 0.1.18.00 11 Finger Guard 0.1.0.00 1 Air Filter 0..001.00 1 Component Cover, Left 0..1.00 1 1 Power Supply, 08/0 V Input, V DC Output 0.17.0.00 1 Snap Bushing, 1-1/ 0.0..00 1 Motor Controller 0.01.0.00 17 Thermostar, High Limit 0.1.177.00 18 IR Sensor Assembly (includes transmitter and receiver) 0.18.1.00 19 Window Plug 0.0..00 0 Linear Actuator * 0..07.00 1 Acutator Claw Assembly R070-1 Actuator Bracket Kit R070-1 Actuator Knob/Pin R0.0.1.00 RFI Filter, 0 A (S100 only) 1Ф 0.1..00 1 Ф 0.1..00 Solid State Relay (S000, Ф only) R0.01..00 DIN Rail Clip 0.01..00 1 7 Relay 0.01.1.00 1 8 T-Block Stop 0.1.07.00 9 T-Block Insulator, Wago 00-191 0.1.07.00 1 0 T-Block Jumper, A S100/S000, 1Ф 0.1.07.00 S100, Ф 0.1.07.00 S000, Ф 0.1.07.00 1 1 Mini Circuit Breaker, 1 A S100/S000, 1Ф 0.0.079.00 S100, Ф 0.0.079.00 1 S000, Ф 0.0.079.00 The shaded areas contain information for International models only. T-Block Insulator, Wago 010-191 S100/S000, 1Ф 0.1.070.00 S000, Ф 0.1.070.00 T-Block Jumper, 7 A S100 0.1.07.00 S000 0.1.07.00 Terminal Block, Position S100, 1Ф 0.1.071.00 S100, Ф 0.1.071.00 10 S000 0.1.071.00 7 Terminal Block, Position S100/S000, 1Ф 0.1.08.00 S000, Ф 0.1.08.00 Locking Shaft, (S000 only) 0.19..00 1 7 Disconnect Switch (includes items and 9, S000 only) R0.19..00 1 8 Cover, Fuse 070-18 1 9 Knob, Red-Yellow ON/OFF Switch (S000 only) 0.0.0.00 1 0 Component Cover, Right 0..1.00 1 1 Thermocouple, Right 0.01.77.00 1 Gear, 1 Teeth 0..0.00 1 Mounting Plate, Drive Motor 070-180 1 Blower Wheel Kit S100 R0.1.1.00 S000 R0.1.10.00 Blower Motor Kit S100 R0.1.1.00 S000 R0.1.18.01 Blower Bracket (S000 only) R0..1.00 7 RFI Bracket (S100 only) 0..180.00 1 8 Blower Housing Assembly S100 R0.1.1.00 S000 R0.1.11.00 9 Indicator Light 0.19.8.00 1 0 Wire Nut, Lever, Pole 0.0.1.00 1 1 Wire Nut, Lever, Pole 0.0.11.00 Drive Motor 0.1.1.00 1 Spacer, Drive Motor 070-01 Shuttle Circuit Board 0700-0 1 Speaker w/leads 0.18.9.00 1 Relay Board R0.01.7.00 1 7 Mini Circuit Breaker, A (S100, Ф only, not shown) 8 RFI Bracket, Filter (S100, Ф only, not shown) 9 Wire Harness, Relay Board to -Pin Connector (not shown) 0.0.081.00 0..777.00) 1 0.18.7.00 1 0 Insulation, Top/Rear (not shown) S100 0709-001 1 S000 070-001 1 Ф = Phase * For units with date code 17 and older, use Linear Actuator P/N 0..09.00. For units with date code 1808 and older, use Fan P/N 0.1.18.00. For use on units with date code 1809 and newer.
Conveyor Belt Assembly Replacement Parts Model S000 shown. 1 1 Conveyor Belt S100 R0..00.00 1 S000 R0..00.00 1 Sprocket Idle Assembly S100 0709-009 1 S000 070-08 1 Flange Bearing Kit (includes beariings) R0.0.00.00 1 Bearing Plate 070-0 Sprocket Drive Assembly S100 0709-008 1 S000 070-09 1 Conveyor Assembly (includes items 1 ) S100 R0709-007 1 S000 R070-0 1 NOTE: The last four digits in a ten digit numerical serial number are the manufacturing date code: 9010 Year 01 Week Four
Legacy Electrical Parts S000 Only The electrical parts listed below are for S000 units with a date code of 118 and older. 1 Terminal Block 0.1.0.00 1 Distribution Block 0.1.0.00 1 Fuse Holder, Dual 0.0.09.00 Time Delay Fuse, A 0.0.07.00 Time Delay Fuse, 1 A 0.0.07.00 7
Need help? Call our hour, toll-free Ovention Hotline Ovention, Inc. P.O. Box 000 Milwaukee, WI -000 U.S.A. 8-98-OVEN(8) connect@oventionovens.com partsandservice@oventionovens.com www.oventionovens.com Printed in U.S.A. October 018