McQuay AAF. Enersaver Packaged Terminal Heat Pump. ENC 000 Vintage B. ENH Vintage B. PNHS Design A (1), B (2)

Replacement Parts List No. 057114500 Revision J 10/2013 McQuay AAF Enersaver Packaged Terminal Heat Pump ENC 000 Vintage B ENH 009-015 Vintage B PNHS 009-015 Design A (1), B (2) To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.daikinapplied.com

Contents About the Model Changes... 2 Parts List Revision History... 3 Nomenclature Serial... 4 Model - ENC, ENH... 5 Model - PNHS... 6 Chassis Diagram... 7 Components... 8 Compressor Section Diagrams... 9 Components... 10 Condenser (Outdoor Air) Fan Section...11 Evaporator (Room Air) Fan Section... 12 Control Box Diagrams... 13 Wall Mounted Thermostats- ENH Only... 14 Unit Mounted Thermostats... 15 Electric Heat Section... 16 Damper Section Manual... 17 Motorized ENH- until 11/97... 18 Motorized ENH, PNHS- 11/97 & later... 19 Power Cords... 20 Wall Sleeve Cabinet Assembly Diagrams... 21 Short Cabinet Components... 22 Long Cabinet Components... 23 Field Installed Accessories Receptacles... 25 Optional Room Cabinet Front Panel... 25 Replacement Filter... 25 Outdoor Stamped Louvers... 25 Condensate Drain Kit... 25 Sensor- Wall Mounted... 25 Installation Kits and Accessories... 26 Hydronic Valves- ENH Only... 26 Critical Parts List... CPL1 About the Model Changes In 1999 the model numbering nomenclature for the Enersaver PTHP changed: The ENH "B" Vintage unit is now either the: PNHS Design "A" unit (the AAF Enersaver PTHP) or PNHS Design"B" unit (the Type 45 retrofit heat pump chassis). The unit's components did not change when the nomenclature did (a few engineering changes have taken place since this RPL was last issued, and the part number changes are noted). The complete model number nomenclature currently used has been added to this revision. Unless otherwise noted, all components listed in this revision apply to both the current and the original model numbered units. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 2

Parts List Revision History Rev. Date Description NEW 9/97 New A 2/99 Page 6 - Added Reference 8A. Page 7 - Corrected description for Ref. #5 and Ref. #8. Added information for Drain Pan (Ref. #8A). Page 11 - Added Fan Board (Ref. #8). Added Motor Mount. Page 14 - Added Receptacle Assy, Plug Assy, Receptacle, Plug, Terminal Pin and Terminal Socket. Page 15 - Updated part number for Freezestat. Page 17 - Added "Before 11/10/97" to title. Page 18 - Added new page 18, "ENH Damper Section - After 11/10/97", which resulted in the re-numbering of all subsequent pages. B 2/00 Page 21 - Deleted part numbers 063017280, 063101701, 063017380 & 063101702. C 5/00 Page 9 - Ref. # 20 with p/n's 060626701 & 060626702 have 13200 Btu's (was 15000 Btu's). Page 14 - Ref. # 97 - Transformer p/n changed to 060630701 (was 063042501). D 7/01 Page 11 - Ref. # 57 part number for sizes 012 & 015 changed from 063032301 to 073374601. E 3/03 Added nomenclature for PNHS1 & PNHS2. Removed all 120V columns (never applied to ENH. Page 4 - Added serial number nomenclature for units built after 2/99. Page 6 - Added new (subsequent pages re-numbered). Page 7 - Added Ref. # 14, 15, 16, 31, 63 to drawings. Page 8 - Ref. # 1 added standard panel for units built post 7/99. Ref. # 5 added baffle for units built post 7/99. Ref. # 14-16 added new. Ref. # 30, 31 moved from compressor section. Ref. # 70-78 moved from ENH heat pump piping section. Gasket p/n 06311403 moved to condenser fan section. Page 9- Removed ref. # 30-32 & detail A. Page 10- Removed ref. # 30-32. Page 11- Ref. # 35 added p/n 059024601 for unit size 015. Page 12- Removed blockoffs (redundant). Ref. # 54 added new. Ref. # 56 added wheel hub clamp. Ref. # 57 removed 063032101 120V motor. Added 073374501 for 012/015 208/. Ref. # 58 063031701 added for size 015. Page 15- Added Terminal Board 802007090, Control Top 056931301 and Cover 056929001. Moved Circuit Breakers from Power Cords Section. Page 16- Separated common parts and added PNHS codes for electric heat. Pages 17-19 Reformatted. Page 20- Added cords for PNHS units. Moved circuit breakers to control box. Pages 21-23 Reformatted. Page 24 - Added new. F 4/04 Page 12 - Bubble #57; Part #063032201(Motor 1/12HP,Double Shaft, ) was incorrectly designated for and has been changed to Part #063032301(Motor 1/12HP,Double Shaft, ). G 1/2006 Page 8 - Added another Reversing Valve to Bub #77 p/n106694102, & added (*) note.(now reflects units built until 4/05 and 4/05 & later). Bub. 378 was re-written (now reflects units built until 4/05 and 4/05 &later). Page 14 - Bub #85 p/n changed from 067180401 to 066803901, Bub #96 specification was changed from TDR to TD2. Bub #97 p/n changed from 060630701 to 060630702. H 11/08 Page 8 - Bub #73 p/n changed from 073335401 to 0733335502. I 5/12 Rebrand to Daikin Mcquay. Formatted to CS5.5. Page 4- Updated Serial - 2/99 to present. Page 12- Ref #57 Delete 115/60/1V motor p/n 063032101. CPL1- Add Critical Parts List. J 10/13 Daikin Rebranding. Drawings were reformatted & numerous changes done. Page 8- Sheet metal deleted and added footnote 1. Deleted Touch-up Paint p/ns 061174723 (antique Ivory). Page 10- Add updated capacitor p/ns 669450001, 910120049 & 910120048. Page 11- Add updated capacitor p/ns 669241401, 669241501 & 910120041. Page 12- Add updated capacitor p/ns 910120041 & 910120042. Add updated motor p/ns 063032202. 063032302, 063032502 & 063032602. Page 14- Ref# 96 Change specification TDR to TD2. Change relay p/n 073386201 to 073386101. Pages 17-18 Ref # 138 Filter change to Screen, Fiberglass. Page 21- Delete ENC000B (ordered with ENR "B") PNHS1 Field Installed Accessory (not used w/pnhs2-des B). Pages 22-23 Delete Touch-up Paint p/ns 061174723 (antique Ivory) & 061174724 (oxford brown). Page 24- Add Condensate Kits p/ns 105542401 & 105542410. Add Sensor p/n 668375301 & 107096001. Page 25- Added retrofit kit p/n 063028801 to Installation Kits from pg 24 Rev I. CPL1- Delete ENC from title header. Added Fan Housings Assy for Evaporator & Condenser. Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 3

Nomenclature Serial - until 2/99 7 6A 12345 010 Factory 7 = Auburn, NY Engineering Revision Serial Year and Month of Manufacture: Year Month Z= 1994 A= Jan. 5= 1995 B= Feb. 6= 1996 C= Mar. 7= 1997 D= Apr. 8= 1998 E= May 9= 1999 F= Jun G= Jul H= Aug J= Sep. K= Oct. L= Nov. M= Dec. Serial - 2/99 & later AUB U 99 05 34048 Plant Identification AUB= Auburn U= Unit Serial (build sequence) Week of Manufacture Year of Manufacture 99= 1999 00= 2000 01= 2001 etc. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 4

Nomenclature Model - ENC, ENH ENH 009B 03 18 CC Y UEYM 1 Y Code 01 02 03 04 05 06 07 08 25 01 Unit Type ENH= Enersaver Packaged Terminal Heat Pump ENC= Wall Sleeve Cabinet Assembly Only 02 Unit Size 009B= Nominal 9000 BTUH Unit 012B= Nominal 12000 BTUH Unit 015B= Nominal 15000 BTUH Unit 000B= Wall Sleeve Cabinet Only 03 Voltage 39= 240/60/1 03= 208/60/1 40= 277/60/1 YY= No Requirement (Wall Sleeve Cabinet Only) 04 Heater YY= None HH= Hydronic (Hot Water or Steam) 18= 1.8 KW Electric 24= 2.4 KW Electric 32= 3.2 KW Electric 43= 4.3 KW Electric 48= 4.8 KW Electric 05 Chassis Type CC= Commercial SG= SG45 Option Wiring YY= No Requirement (Wall Sleeve Cabinet Only) 06 Not an ENH or ENC Item Y= No Requirement 07Control Type T-Stat Heat Setback Changeover Location Type Control Type UCYY Unit Cool Only None None UCRY Unit Cool Only Remote None UEYM Unit Elect. None Manual UEYA Unit Elect. None Auto UEUM Unit Elect. Unit Manual UEUA Unit Elect. Unit Auto UERM Unit Elect. Remote Manual UERA Unit Elect. Remote Auto UHYM Unit Hydro. None Manual UHYA Unit Hydro. None Auto UHUM Unit Hydro. Unit Manual UHUA Unit Hydro. Unit Auto UHRM Unit Hydro. Remote Manual UHRA Unit Hydro. Remote Auto WEYM Wall Elect. None Manual WEYA Wall Elect. None Auto WEUM Wall Elect. Unit Manual WEUA Wall Elect. Unit Auto WERM Wall Elect. Remote Manual WERA Wall Elect. Remote Auto WHYM Wall Hydro. None Manual WHYA Wall Hydro. None Auto WHUM Wall Hydro. Unit Manual WHUA Wall Hydro. Unit Auto WHRM Wall Hydro. Remote Manual WHRA Wall Hydro. Remote Auto YYYY No Requirement (Wall Sleeve Cabinet Only) 08 Damper 1= Manual Fresh Air Damper 2= Motorized Fresh Air Damper Y= None (Wall Sleeve Cabinet Only) 25 Miscellaneous X= Special Y= No Requirement PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 5

Nomenclature Model - PNHS Code PNHS 1 009 C Z 35 Z 12 AR 14 C I C 1 01 & 02 03 04 05 06 07 08 09 10 11 12 13 14 15 01 Unit Type & PNHS= Enersaver Packaged Terminal Heat Pump 02 03 Unit Design (Vintage) 1= Design A (AAF Enersaver version PTHP) 2= Design B (Type 45 replacement heat pump chassis) 04 Size (1000's BTUH) 009 012 015 05 Voltage C= 208/60/1 J= 265/277/60/1 06 Coil Options Z= None 07 Heat Options 35= 2.5 KW Electric Heat 41= 3.5 KW Electric Heat 44= 4.0 KW Electric Heat 08 Hand Application Z= Not Applicable 09 Controls 12= Unit Mounted Manual Changeover 10 Discharge AR= Flat Top 11 Return Air/ OA 14= Bottom 12 Power Connection C= Cord 13 Color I= Antique Ivory 14 SKU Type A= Stock B= Standard Leadtime C= Extended Leadtime 15 Product Style 1= 1st Product Style Change PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 6

Chassis Diagram 12 See Compressor 10 Section 11 29 62 14 27 28 7 See Condenser 26 Fan Section 40 4 41 35 See Condenser Fan Section 38 39 73 8A 9 8 2 36 See Condenser Fan Section 15 77 76 5 13 78 1 30 16 70 13 20 See Compressor Section 6 23 24 25 75 31 See Compressor Section PNHS2 (Design B) Baffle 63 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 7

Chassis Components Ref Description Part Unit Size No. 009 012 015 1 Panel-End, RH 1 1 1 1 Panel-End, RH, Cold Climate ENH only 1 1 1 1 2 Panel- End, LH 1 1 1 1 Panel- End, LH, Cold Climate ENH only 1 1 1 1 4 Blockoff - Evaporator, Front 1 1 1 1 5 Drain Pan Blockoff, Evaporator 1 1 1 1 6 Base Pan, Chassis 057919801 1 1 1 7 Bulkhead 1 1 1 1 Bulkhead, Cold Climate ENH only 1 1 1 1 8 Fanboard/Evap. Motor Mount/Drain Pan Assy 063109801 1 1 1 8A Drain Pan only 106228201 1 1 1 9 Blockoff, Evaporator, End RH 1 1 1 1 10 Blockoff, Evaporator, End LH 1 1 1 1 11 Gasket, Bulkhead Top 063110402 1 1 1 12 Gasket, Evaporator Top 063110401 1 1 1 13 Gasket, Condenser Side 2 063050201 2 2 2 14 Gasket 063092701 1 1 1 15 Gasket, Baffle 063110404 1 1 1 16 Baffle- Condensate 1 1 1 1 30 Coil, Condenser 057935201 1 Coil, Condenser 073379501 1 Coil, Condenser 059031001 1 31 Strainer 056303301 1 1 1 62 Coil- Evaporator (IAC) 3 Row 057918301 1 1 Coil- Evaporator (IAC) 4 Row 059016601 1 63 Baffle- SG45 Chassis PNHS2 only 063121101 1 1 1 70 Check Valve 073335401 1 1 1 73 Strainer 056303301 1 Strainer 073335502 1 1 75 Cap Tube, Cooling 52" Long 063061701 1 Cap Tube, Cooling 40" Long 060634734 1 Cap Tube, Cooling 80" Long 063090701 1 N/S Cap Tube, Heating 057937101 1 Cap Tube, Heating 059023402 1 76 Drain Valve 063077801 1 1 1 77 Reversing Valve 3 until 3/05 066533701 1 1 1 Reversing Valve 3 3/05 to 3/11 106694102 1 1 1 Reversing Valve 3 3/11 & later 910110418 1 1 1 78 Solenoid, Reversing Valve 208/230V until 4/05 066541903 1 1 1 208/230V 4/05 to 4/11 106694204 1 1 1 208/230V 4/11 & later 910110437 1 1 1 until 4/05 066541904 1 1 1 4/05 to 4/11 106694205 1 1 1 4/11 & later 910110438 1 1 1 N/S Screen, Filter Access 063067401 1 1 1 N/S Filter, Throwaway until 3/99 063093501 1 1 1 N/S Filter, Cleanable until 3/99 063081701 1 1 1 Filter, Cleanable 3/99 & later 105537401 1 1 1 N/S= Not Shown on Diagram. 1 Please contact Daikin Applied with unit model and serial number for part numbers on Chassis components. 2 Does not apply to the PNHS2 (Design B) units. 3 New & old valves/solenoid are not compatible. If a new valve is ordered to replace an old valve, a new solenoid coil must also be ordered. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 8

Compressor Section Diagrams Sizes 009 & 015 20 25 24 23 Typ. 3 places 29 28 27 26 Size 012 20 25 24 23 Typ. 3 places PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 9

Compressor Section Components 009 012 015 Ref. Description Part No. 20 Compressor 061086002 1 1 Compressor 061086001 1 Compressor 067281302 1 1 Compressor 067281301 1 Compressor 060626701 1 1 Compressor 060626702 1 N/S Compressor Overload 066819602 1 1 Compressor Overload 066819601 1 Compressor Overload 057479501 1 1 Compressor Overload 067282801 1 Compressor Overload 300009405 1 1 Compressor Overload 300009404 1 23 Grommet 060623301 3 3 3 3 3 3 3 3 3 24 Sleeve 060623401 3 3 3 3 3 3 3 3 3 25 Flange Nut 802012035 3 3 3 3 3 3 3 3 3 N/S Terminal Cover, Compressor 067280501 1 1 1 N/S Nut, Compressor 066536501 1 1 1 N/S Spring, Compressor 066536301 1 1 1 N/S Gasket, Compressor 066536601 1 1 1 N/S Gasket, Compressor 066536201 1 1 1 26 3 Capacitor 25 MFD 370V until 3/09 067291512 1 1 1 1 1 Capacitor, 25 MFD 370V 3/09 & later 669450001 1 1 1 1 1 Capacitor 20 MFD 370V until 4/12 067291518 1 1 Capacitor, 20 MFD 370V 4/12 & later 910120049 1 1 Capacitor 25 MFD 440V until 4/12 067291517 1 1 Capacitor, 25 MFD 440V 4/12 & later 910120048 1 1 27 3 Boot, Capacitor 067291601 1 1 1 1 1 1 1 1 1 28 3 Bracket - Capacitor 850010570 1 1 1 1 1 1 1 1 1 29 3 Screw 040501415 2 2 2 2 2 2 2 2 2 N/S= Not Shown on Diagram. * units apply only to the ENH. 3 Shown on the Chassis Diagram. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 10

Condenser (Outdoor Air) Fan Section Diagram & Components 35 46 44 45 37 43 35 42 36 Detail B 009 012 015 Ref. Description Part No. 35 Fan Housing 063065901 1 1 1 1 1 1 Fan Housing 059024601 1 1 1 36 Fan Prop 063067901 1 1 1 1 1 1 1 1 1 37 Motor, 1/10 HP 073392301 1 1 Motor, 1/10 HP 073392601 1 Motor, 1/6 HP 073392101 1 1 Motor, 1/6 HP 073392401 1 Motor, 1/6 HP 059016401 1 1 Motor, 1/6 HP 059016501 1 38 3 Capacitor, 3 MFD 370V until 3/09 067291501 1 1 1 1 1 1 Capacitor, 3 MFD 370V 3/09 & later 669241401 1 1 1 1 1 1 Capacitor, 4 MFD 370V until 6/09 067291502 1 1 Capacitor, 4 MFD 370V 6/09 & later 669241501 1 1 Capacitor, 4 MFD 440V until 4/12 067291525 1 Capacitor, 4 MFD 440V 4/12 & later 910120041 1 39 3 Cover, Capacitor 067291602 1 1 1 1 1 1 1 1 1 40 3 Bracket, Capacitor 850010570 1 1 1 1 1 1 1 1 1 41 3 Screw 040501415 2 2 2 2 2 2 2 2 2 42 Motor Mount 063030001 1 1 1 1 1 1 1 1 1 43 Spacer 063077101 3 3 3 3 3 3 3 3 3 44 Grommet, Tube 035928100 3 3 3 3 3 3 3 3 3 45 Grommet, Washer 035928000 3 3 3 3 3 3 3 3 3 46 Nut 063060601 3 3 3 3 3 3 3 3 3 * units apply only to the ENH. 3 Shown on the Chassis Diagram. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 11

Evaporator (Room Air) Fan Section Diagram & Components 54 8 8 57 55 56 55 57 55 8 56 61 59 58 60 Day Stat (REF. Unit Mounted Thermostat Cap Tube) 009 012 015 Ref. Description Part No. 8 Fan Board 063109801 1 1 1 1 1 1 1 1 1 54 Gasket, Fan Board 063110403 1 1 1 1 1 1 1 1 1 55 Fan Housing 063030701 2 2 2 2 Fan Housing 063030702 2 2 2 2 2 56 Fan Wheel 063050401 2 2 2 2 2 2 2 2 2 N/S Clamp- Wheel Hub 066534601 2 2 2 2 2 2 2 2 2 57 Motor 1/12 HP until 7/07 063032201 1 1 Motor 1/12 HP 7/07 & later 063032202 1 1 Motor 1/12 HP until 7/07 063032301 1 Motor 1/12 HP 7/07 & later 063032302 1 Motor 1/8 HP until 7/07 073374501 1 1 1 1 Motor 1/8 HP 7/07 & later 073374502 1 1 1 1 Motor 1/8 HP until 7/07 073374601 1 1 Motor 1/8 HP 7/07 & later 073374602 1 1 58 Capacitor, 4 MFD 370V until 4/12 063031601 1 1 1 1 1 1 1 1 Capacitor, 4 MFD 370V 4/12 & later 910120041 1 1 1 1 1 1 1 1 Capacitor, 5 MFD 370V until 4/12 063031701 1 Capacitor, 5 MFD 370V 4/12 & later 910120042 1 59 Bracket, Cover-Capacitor 063067801 1 1 1 1 1 1 1 1 1 60 Screw 040501415 4 4 4 4 4 4 4 4 4 61 Clamp-Motor Mounting 063048201 2 2 2 2 2 2 2 2 2 N/S Motor Mount 063110302 1 1 1 1 1 1 1 1 1 N/S= Not Shown on diagram. * units apply only to the ENH. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 12

Control Box Diagrams TH2 93 97 90 146 X1 TDR CB 89 87 96 R6 R5 R4 TDR 88 R3 R3 92 85 86 TH9 TH1 PB 91 PB 98 94 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 13

Control Box Wall Mounted Thermostats- ENH Only Components 009 012 015 Ref. Description Part No. 85 Relay-Cool R2 066803901 1 1 1 1 1 1 1 1 1 86 Relay-Heat R3 066803901 1 1 1 1 1 1 1 1 1 87 Relay-Fan, without Setback R4 063097101 1 1 1 1 1 1 1 1 1 Relay-Fan, with Setback R4 066803901 1 1 1 1 1 1 1 1 1 88 Relay-Setback R5 803005121 1 1 1 1 1 1 Relay-Setback R5 803005120 1 1 1 89 Relay-Interlock, Wet Heat R6 061019401 1 1 1 1 1 1 Relay-Interlock, Wet Heat R6 061019402 1 1 1 90 Relay-Remote Setback TDR 073386101 1 1 1 1 1 1 1 1 1 91 Switch-Push Button (3) PB 063039601 1 1 1 1 1 1 1 1 92 Thermostat-Manual Changeover TH1 063040701 1 1 1 1 1 1 1 1 1 Thermostat-Man.Changeover+Fan SW TH1 063041001 1 1 1 1 1 1 1 1 1 Thermostat-Auto Changeover TH1 063040401 1 1 1 1 1 1 1 1 1 N/S Subbase-Auto Changeover Stat 063049001 1 1 1 1 1 1 1 1 1 93 Thermostat-Setback TH2 073394201 1 1 1 1 1 1 1 1 1 94 Knob 073397001 1 1 1 1 1 1 1 1 1 N/S Thermostat-Low Limit TH3 057930001 1 1 1 1 1 1 1 1 1 96 Relay-Time Delay (TD2) until 7/10 073386201 1 1 1 1 1 1 1 1 1 Relay-Time Delay (TD2) 7/10 & later 073386101 1 1 1 1 1 1 1 1 1 97 Transformer X1 063042401 1 1 1 1 1 1 Transformer X1 060630702 1 1 1 98 Thermostat-Low Ambient TH9 073394301 1 1 1 1 1 1 1 1 1 N/S Receptacle Assembly 063105303 1 1 1 1 1 1 1 1 1 N/S Plug Assembly 107174152 1 1 1 1 1 1 1 1 1 N/S Receptacle 047934204 1 1 1 1 1 1 1 1 1 N/S Plug 802007736 1 1 1 1 1 1 1 1 1 N/S Terminal Pin 034247401 6 6 6 6 6 6 6 6 6 N/S Terminal Socket 802007741 6 6 6 6 6 6 6 6 6 N/S=Not shown on diagram. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 14

Control Box Unit Mounted Thermostats Components 009 012 015 Ref. Description Part No. 86 Relay, Heat- Wet Heat 4 R3 061019401 1 1 1 1 1 1 Relay, Heat- Wet Heat 4 R3 061019402 1 1 1 88 Relay, Setback 4 R5 803005121 1 1 1 1 1 1 Relay, Setback 4 R5 803005120 1 1 1 89 Relay, Interlock- Wet Heat 4 R6 061019401 1 1 1 1 1 1 Relay, Interlock- Wet Heat 4 R6 061019402 1 1 1 Relay, Interlock- Electric Heat 4 R6 803005121 1 1 1 1 1 1 Relay, Interlock- Electric Heat 4 R6 803005120 1 1 1 91 Switch, Push Button,(5) Man. Changeover PB 063039801 1 1 1 1 1 1 1 1 1 Switch, Push Button, (3) Auto Changeover 4 PB 063039601 1 1 1 1 1 1 1 1 1 92 Thermostat, Manual Changeover TH1 073394101 1 1 1 1 1 1 1 1 1 Thermostat, Auto Changeover 4 TH1 073398001 1 1 1 1 1 1 1 1 1 93 Thermostat, Setback 4 TH2 073394201 1 1 1 1 1 1 1 1 1 94 Knob- Changeover Thermostat 073397001 1 1 1 1 1 1 1 1 1 96 Relay- Time Delay (TD2) until 7/10 073386201 1 1 1 1 1 1 1 1 1 Relay- Time Delay (TD2) 7/10 & later 073386101 1 1 1 1 1 1 1 1 1 98 Thermostat, Low Ambient TH9 073394301 1 1 1 1 1 1 1 1 1 146 Circuit Breaker 4 15 Amp 063096101 1 1 1 Circuit Breaker 4 20 Amp 063096102 1 1 1 Circuit Breaker 4 15 Amp 063096201 1 1 1 1 1 1 Circuit Breaker 4 20 Amp 063096202 1 1 1 1 1 1 Circuit Breaker 4 30 Amp 063096203 1 1 1 1 1 1 N/S Terminal Board 802007090 2 2 2 2 2 2 2 2 2 N/S Freezestat TC5 106229401 1 1 1 1 1 1 1 1 1 N/S Panel- Control Box Top 056931301 1 1 1 1 1 1 1 1 1 N/S Panel- Control Box Cover 056929001 1 1 1 1 1 1 1 1 1 N/S= Not shown on diagram. * units apply only to the ENH. 4 Used only on ENH units. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 15

Electric Heat Section Diagram & Components 120 124 120 121 125 122 or 123 Fan Board Common Parts Ref. Description Part Qty. No. 121 Clamp-Element 063022101 4 4 4 122 Mount-Heater Right-Hand 063050001 2 2 2 123 Mount-Heater Left-Hand 063050002 2 2 2 124 Wire Harness 056936401 1 1 1 125 Overheat Stat-Disc+150F OH 063040901 1 1 1 Heaters Volt. Ref. ENH PNHS Heater Part No. Code 04= Code 07= Position 120 18 N/A Both 063079705 2 24 35 Right-hand 063079701 1 24 35 Left-hand 063079705 1 32 41 Right-hand 063079702 1 32 41 Left-hand 063079701 1 43 44 Right-hand 063079703 1 43 44 Left-hand 063079702 1 48 N/A Both 063079703 2 18 N/A Both 063079704 2 24 N/A Both 063079705 2 32 N/A Right-hand 063079701 1 32 N/A Left-hand 063079705 1 43 N/A Right-hand 063079702 1 43 N/A Left-hand 063079701 1 48 N/A Both 063079702 2 24 35 Both 063079704 2 32 41 Both 063079705 2 43 44 Right-hand 063079701 1 43 44 Left-hand 063079705 1 N/A= Not applicable. * units apply only to the ENH. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 16

Damper Section- Manual Diagram & Components 140 132 141 131 138 130 Ref. Description Part Qty. No. 130 Damper 063018801 1 131 Lever, Damper Operator 063018901 1 132 Angle, Lever 063018401 1 140 Gasket 063092702 2 141 Gasket 063092703 2 138 Screen, Fiberglass 063118801 1 N/S Tap Screw 106083702 4 N/S= Not shown on diagram. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 17

Damper Section- Motorized ENH- until 11/97 Diagram & Components 137 138 137 136 135 134 135 133 134 009 012 015 Ref. Description Part No. 133 Damper 063018301 1 1 1 1 1 1 1 1 1 134 Shaft, Damper 063089401 1 1 1 1 1 1 1 1 1 135 Spring, Damper 063089501 1 1 1 1 1 1 1 1 1 136 Toggle Switch, SPST SW2 802005045 1 1 1 1 1 1 1 1 1 137 Motor 063078901 1 1 1 1 1 1 Motor 063079001 1 1 1 138 Screen, Fiberglass 063118801 1 1 1 1 1 1 1 1 1 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 18

Damper Section- Motorized ENH/PNHS- 11/97 & later Diagram & Components 9 8 Detail A 10 12 11 6 4 2 5 3 7 Detail A 24 1 Detail B Detail B 009 012 015 Ref. Description Part No. 1 Support, Damper Motor 105904901 1 1 1 1 1 1 1 1 1 2 Damper Lever 105905001 1 1 1 1 1 1 1 1 1 3 Channel Operating Arm 062968001 1 1 1 1 1 1 1 1 1 4 Spring Nut 802017023 1 1 1 1 1 1 1 1 1 5 Spring, Extension 105905401 1 1 1 1 1 1 1 1 1 6 Screw, Tap, 8-18 x.38 106083702 4 4 4 4 4 4 4 4 4 7 Washer 040500301 2 2 2 2 2 2 2 2 2 8 Damper 063018801 1 1 1 1 1 1 1 1 1 9 Gasket 063092702 2 2 2 2 2 2 2 2 2 10 Gasket 063092703 2 2 2 2 2 2 2 2 11 Screen, Fiberglass 063118801 1 1 1 1 1 1 1 1 1 12 Bushing, Snap-in 105905601 1 1 1 1 1 1 1 1 1 24 Motor 802024015 1 1 1 Motor 802024037 1 1 1 Motor 802024016 1 1 1 N/S Switch, Rocker, SPDT 047357307 1 1 1 1 1 1 1 1 1 N/S= Not shown on diagram. * units apply only to the ENH. PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 19

Power Cords Components ENH Power Cords for Building Receptacles Installed by Others- Electric Heat Only 009 012 015 Description Part Cord Set, (2.4 kw) 15 amp, 60" Lg. 063095701 1 1 1 1 1 1 Cord Set, (3.2 kw) 20 amp, 60" Lg., 063042801 1 1 1 1 1 1 Cord Set, (4.3/4.8 kw) 30 amp, 60" Lg., 063043001 1 1 1 1 1 1 ENH Power Cords Permanently Connected to AAF Wall Sleeve- Short Cabinet 009 012 015 Description Part Cord Set, 20 amp, 20" Lg. 063042701 1 1 1 1 1 1 Cord Set, 20 amp, 20" Lg. 063043101 1 1 1 Receptacle, 20 amp 047139805 1 1 1 1 1 1 Receptacle, 20 amp 047139802 1 1 1 ENH Power Cords Permanently Connected to AAF Wall Sleeve- Long Cabinet 009 012 015 Description Part Cord Set, 20 amp, 60" Lg. 063042801 1 1 1 1 1 1 Cord Set, (2.4 kw) 15 amp, 60" Lg. 063043201 1 1 1 Receptacle, 20 amp 047139805 1 1 1 1 1 1 Receptacle, 20 amp 047139802 1 1 1 PNHS1 (Design A) Power Cords 009 012 015 Description Part Cord Set 063042701 1 1 1 Cord Set 063043101 1 1 1 PNHS2 (Design B) Power Cords 009 012 015 Description Part Cord Set- Electric Heat Units 063108701 1 1 1 Cord Set- Electric Heat Units 057041801 1 1 1 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 20

Wall Sleeve Cabinet Assembly Diagrams 165 Short Cabinet- 37.5" Long ENH or PNHS1 Units 172 173 150 174 163 164 171 166 170 165 172 160 173 150 174 163 164 Long Cabinet- 41.50" Long ENH Hydronic Heat Units (not applicable to PNHS1 units) 162 171 162 160 161 168 169 166 170 167 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 21

Wall Sleeve Cabinet Assembly Ref. Description Part Qty. No. 150 Wall Sleeve Assembly- Short Cabinet Standard 063099202 1 Sea Coast ENH Only 063099208 1 Cold Climate ENH Only 063099214 1 163 Access Door Standard Construction 063010390 1 Sea Coast ENH Only 063010380 1 164 Access Door w/ Lock Standard Construction ENH Only 063086001 1 Sea Coast ENH Only 063086002 1 165 Lock and Keys Only ENH Only 063050101 1 166 Clip - Hinge 063060801 1 167 Hinge Pin 063099001 1 168 Junction Box ENH Only 4EQB33 1 169 Cover-Junction Box ENH Only 802007355 1 170 Gasket 063092901 1 171 Gasket 063110405 1 172 Bracket-Chassis Support 063010601 2 173 Nut until 5/99 040499901 2 Nut 5/99 & later 105915801 2 174 Discharge Grille 5 063130190 1 N/S Subbase- 5" 063099520 1 N/S Front Panel-Solid Standard 063017290 1 Sea Coast ENH Only 063017280 1 Cold Climate ENH Only 063101701 1 N/S Front Panel-Louver 063101601 1 N/S Screw-Front Panel 038990701 6 N/S Exterior Louver Stamped ENH Only 063021901 1 Extruded 063031401 1 N/S= Not shown on diagram. 5 Spotwelded into wall sleeve assembly. Short Cabinet Components PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 22

Wall Sleeve Cabinet Assembly Ref. Description Part Qty. No. 150 Wall Sleeve Assembly- Long Cabinet Standard- Hydronic Heat 063099201 1 Sea Coast- Hydronic Heat 063099207 1 Cold Climate- Hydronic Heat 063099213 1 Standard- Electric Heat 063099203 1 Sea Coast 063099209 1 Cold Climate 063099215 1 160 Blockoff- Hydronic Coil 063010490 1 161 Hydronic Heat Coil YRF26A 1 162 Screw- Hydronic Coil 038990701 6 163 Access Door Standard Construction 063010390 1 Sea Coast 063010380 1 164 Access Door w/ Lock Standard Construction 063086001 1 Sea Coast 063086002 1 165 Lock and Keys Only 063050101 1 166 Clip - Hinge 063060801 1 167 Hinge Pin 063099001 1 168 Junction Box 4EQB33 1 169 Cover- Junction Box 802007355 1 170 Gasket 063092901 1 171 Gasket 063110405 1 172 Bracket- Chassis Support 063010601 2 173 Nut until 5/99 040499901 2 Nut 5/99 & later 105915801 2 174 Discharge Grille 5 063130190 1 N/S Subbase- 5" 063099502 1 N/S Front Panel-Solid Standard 063017390 1 Sea Coast 063017380 1 Cold Climate 063101702 1 N/S Front Panel- Louvered Standard Only 063101602 1 N/S Screw- Front Panel 038990701 6 N/S Exterior Louvered Stamped 063022001 1 Extruded 063031301 1 N/S= Not shown on diagram. 5 Spotwelded into wall sleeve assembly. Long Cabinet Components PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 23

Field Installed Accessories Receptacles (field installed in short cabinet subbase or long cabinet end compartment) Description Part Receptacle- 20 Amp- Units 047139805 Receptacle- 20 Amp- 265V Units 047139802 Optional Room Cabinet Front Panel (used when unit is floor mounted WITHOUT electrical subbase) Description Part Louvered Front Panel 063018090 Angle, Blockoff- either size 063018190 Gasket- either size 063091808 Replacement Filter Description Part Filter, Permanent- Cleanable 30.38" x 7.06" x.25" 063081701 Outdoor Stamped Louvers (clear anodized aluminum flanged to cover oversized outdoor opening) Description Part Outdoor Stamped Louver until 8/00 063021703 Outdoor Stamped Louver 8/00 & later 107322501 Condensate Drain Kit Description Part Tube Drain Kit for Heat Pumps 1 Pack 105542401 Tube Drain Kit for Heat Pumps 10 Pack 105542410 Sensor- Wall Mounted Description Part TStat- AC/DC, ACO, 7-Day Programmable, 2 Heat/2 Cool 668375301 Remote Sensor for TSat 668375301 107096001 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 24

Field Installed Accessories Installation Kits and Accessories Description Part Deflector- Discharge Air 063085401 Front Panel- Louvered Short Cabinet 063017701 Long Cabinet 063017801 Intake Collar- 1½" Outdoor Short Cabinet 063021103 Long Cabinet 063021104 Intake Collar- 4½" Outdoor Short Cabinet 063021102 Long Cabinet 063021101 Wall Guard Flange- 3 Sided, Indoor Short Cabinet 063016701 Long Cabinet 063016702 Thermostat Limiter 063029501 Retrofit Kit for Type SG45 PNES2 only 063028801 Hydronic Valves- ENH Units Description Part Hydronic Valve w/harness, 120V 063102301 Hydronic Valve w/harness, 063102302 Hydronic Valve w/harness, 230V 063102303 Hydronic Valve w/harness, 063102304 PTHP; ENC 000/ENH 009-015 Vint. B/PNHS1,2 009-015 Des. A,B Rev. J 10/13 RPL 571145 / Page 25

Critical Daikin Applied OEM Parts Are What Your Daikin Applied HVAC Unit Needs! McQuay Packaged Terminal Heat Pump AAF Packaged Terminal Heat Pump ENH, Unit Sizes 009-015, Vintage B PNHS1,2 Unit Sizes 009-015, Design A,B CRITICAL COMPONENTS MODEL UNIT SIZE VOLTAGE PART NUMBER COMPRESSOR Compressor, 9000 BTUH ALL 009 208-230/60/1 061086002 Compressor, 9000 BTUH ALL 009 265/60/1 061086001 Compressor, 12000 BTUH ALL 012 208-230/60/1 067281302 Compressor, 12000 BTUH ALL 012 265/60/1 067281301 Compressor, 14000 BTUH ALL 015 208-230/60/1 060626701 Compressor, 14000 BTUH ALL 015 265/60/1 060626702 CONDENSER MOTOR Motor, 1/10 HP ALL 009 208-230/60/1 073392301 Motor, 1/10 HP ALL 009 265/60/1 073392601 Motor, 1/6 HP ALL 012 208-230/60/1 073392101 Motor, 1/6 HP ALL 012 265/60/1 073392401 Motor, 1/6 HP ALL 015 208-230/60/1 059016401 Motor, 1/6 HP ALL 015 265/60/1 059016501 EVAPORATOR MOTOR Motor, 1/12 HP ALL 009 208-230/60/1 063032202 Motor, 1/12 HP ALL 009 265/60/1 063032302 Motor, 1/8 HP ALL 012, 015 208-230/60/1 073374502 Motor, 1/8 HP ALL 012, 015 265/60/1 073374602 FAN HOUSING ASSY & WHEEL Fan Housing Assy- Condenser ALL 009, 012 N/A 063065901 Fan Housing Assy- Condenser ALL 015 N/A 059024601 Fan Prop- Condenser ALL ALL N/A 063067901 Fan Housing Assy- Evaporator ALL 009 N/A 063030701 Fan Housing Assy- Evaporator ALL 012, 015 N/A 063030702 Wheel- Evaporator ALL ALL N/A 063050401 Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs. To Locate A Distributor, Go To www.daikinapplied.com or Call 1-800-37PARTS 571145 Rev. J 10/2013 CPL Page 1 of 1