vbolie Pro Coditio Moitorig System Product Datasheet Betly Nevada* Asset Coditio Moitorig Descriptio The vbolie Pro Coditio Moitorig System uses sophisticated sigal processig algorithms together with machiery operatig states to moitor assets cotiuously. This system is part of a coditio based maiteace program that idetifies problems before assets begi to fail. Beefits of the vbolie Pro Coditio Moitorig System are: Cost savigs from reduced machiery dow time Early detectio of bearig defects Reductio of damage to assets The moitorig system's key features are: Sigal coditioig Alarmig Speed iputs Cotrol system commuicatio The vbolie Pro Coditio Moitorig System commuicates with System 1* via dual Etheret coectios. The moitorig system uses 24 bit aalog/digital coversio ad 40 khz badwidth to moitor rollig elemet bearig machiery ad gearig. Sophisticated sigal processig algorithms extract measuremet ad health idices from each accelerometer poit. The algorithms ca be custom tued to specific bearig ad gear box characteristics. vbolie Pro Coditio Moitorig System exports treded measuremets like direct, bias, speed, gap as well as chael ot Ok status to third party systems such as DCS via Modbus over etheret. The vbolie Pro Coditio Moitorig System compoets are vbolie Pro moitor, System 1*, Betly Nevada Moitor Cofiguratio software, trasducers, ad cables. Page 1 of 8
Figure 1: vbolie Pro Coditio Moitorig System Compoets Page 2 of 8
Specificatios Electrical Specificatios TX/RX B Accuracy Idicates etwork traffic is flowig o Network B Iputs Miimum Iput Power Maximum Iput Power Maximum Curret Maximum Irush Curret Maximum Iputs Dyamic Rage Sigal/Noise Ratio A/D Coversio Badwidth Outputs Buffered Sigal Outputs Network A Network B Power LED OK LED Dager LED Alert LED Kph 1 OK LED Kph 2 OK LED Net A TX/RX A Net B 18 Vdc 36 Vdc 1.7 A 2.7 A Less tha 5 ms 12 dyamic sigals 2 Keyphasor* sigals 110 db @ fs = 102.4 ksps 110 db @ fs = 102.4 ksps Sigma-Delta 24 bits omial 0 to 40kHz Two 15 pi DSUB coector 550 ohm output impedace Two Idepedet Etheret Ports 10/100 BaseT Network DHCP Port 10/100 BaseT Local Static IP Port LEDs Idicates whe a proper power iput is preset Idicates whe the system is fuctioig properly Idicates a Dager Alarm coditio Idicates a Alert coditio Idicates Keyphasor sigal 1 is triggerig Idicates Keyphasor sigal 2 is triggerig Idicates Network A has a valid lik Idicates etwork traffic is flowig o Network A Idicates Network B has a valid lik Direct pk or rms ± 1.1% Bias Dyamic Data Cofigurable Sychroous Waveforms Spectral Lies Spectrum Frequecy Rage Spectral Resolutio Spectrum Widow Types Demodulatio Badwidth Update Rate Data Storage +0.8 V / -1.34 V Up to 8192 samples 100 to 12,800 i icremets of 2X User Cofigurable up to 40kHz 100 to 12,800 i icremets of 2X Haig 125Hz to 10kHz 18 preset optios Up to oce every 10 miutes User cofigurable 8 hours Typical No alarms Keyphasor Sigal Iputs Speed Rage Speed Accuracy 1 to 120,000 rpm 1 to 100 rpm ± - 0.1 rpm 100 to 10,000 rpm ± 1 rpm 10,000 to 120,000 rpm ± 10 rpm Supported Trasducers Acceleratio Chaels Keyphasor Chaels Compatible with costat curret accelerometers Proximity switches such as Turck Ni8 M18T AP6X7M Betly Nevada Proximity Probes Page 3 of 8
Physical Dimesios Weight Moutig 8.88 X 5.89 X 2.17 iches 225 X 150 X 55 mm Figure 1 o page 7 1.4 kg 3 lbs Di Rail Moutig Evirometal Limits Operatig Temperature Rage Storage Temperature Rage Relative Humidity Pollutio Degree -40 C to +70 C -40 F to 158 F -45 C to +85 C -49 F to 185 F 0% to 95% o-codesig for operatio ad storage Pollutio Degree 2 Workig voltage < 30 Vrms or 60 Vdc Compliace ad Certificatios For the detailed listig of coutry ad product specific approvals, refer to the Approvals Quick Referece Guide, documet 108M1756, at www.gemeasuremet.com. EMC EMC Stadards: EN 61000-6-2 Immuity for Idustrial Eviromets EN 61000-6-4 Emissios for Idustrial Eviromets Europea Commuity Directives: EMC Directive 2014/30/EU Electrical Safety Electrical Safety Stadards: EN 61010-1 Europea Commuity Directives: LV Directive 2014/35/EU Hazardous Area Approvals For the detailed listig of coutry ad product specific approvals, refer to the Approvals Quick Referece Guide, documet 108M1756, at www.gemeasuremet.com. CSA/NRTL/C Class I, Zoe 2 AEx A IIC T4 Gc Class I, Divisio 2 Groups A, B, C ad D Istall per drawig 115M4822 T4 @ Ta = -40 C Ta +70 C ATEX/IECEx II 3 G Ex A IIC T4 Gc Ex ec IIC T4 Gc Istall per drawig 115M4822 T4 @ Ta = -40 C Ta +70 C SPECIFIC CONDITIONS OF USE: Page 4 of 8
1. The device shall be istalled i a additioal eclosure that provides a igress protectio ratig ot less tha IP54 ad meets the eclosure requiremets of IEC 60079-0. 2. The equipmet shall oly be used i a area of ot more tha pollutio degree 2, as defied i IEC 60664-1. 3. Trasiet protectio shall be provided that is set at a level ot exceedig 140% of the peak rated voltage value at the supply termials to the equipmet. 4. Tighteig torque rage is 2.0 i-lbf [0.22 N-m] miimum / 2.2 i-lbf [0.25 N-m] maximum. WARNING HAZARDOUS ENVIRONMENT DO NOT DISCONNECT OR OPEN EQUIPMENT UNLESS POWER HAS BEEN SWITCHED OFF OR THE AREA IS KNOWN TO BE NON- HAZARDOUS. Page 5 of 8
Orderig Iformatio For the detailed listig of coutry ad product specific approvals, refer to the Approvals Quick Referece Guide, documet 108M1756, at www.gemeasuremet.com. 284622-050 284622-030 138131 Accelerometer Cable 15.2 m (50 ft) with right agle coector Accelerometer Cable 9.1 m (30ft) with right agle coector CAT5 Cable Miimum cable legth is 3 feet. Maximum cable legth is 320 feet. 60M500 - AA - BB A: Agecy Approvals 00 Noe 05 Multi Approvals (CSA, IECEx, ATEX) B: System 1 Licese 00 Noe 01 Oe Sesors ad Cables Part Number AS3100S2-Z2 AM3100T2-Z AP3500T2-Z1 AP3500S2-Z1 Accelerometer, Side Exit 100 mv/g 0.7-10,000 Hz Descriptio Accelerometer, Top Exit 100 mv/g, 0.4-14,000 Hz Accelerometer, Top Exit 500 mv/g, 0.2-2,300 Hz Accelerometer, Side Exit 500 mv/g, 0.2-3,700 Hz See 3300 XL NSv Proximity Trasducer System datasheet, part umber 147385-01,ad 3300 XL 8mm Proximity Trasducer System datasheet, part umber 141194-01. 330780 3300 XL 11mm Proximity Trasducer System 330180 3300 XL 8mm Proximity Trasducer System 330980 3300 XL NSV Proximity Trasducer System 200355 287844 284613-050 284613-030 Low Frequecy Accelerometer 100 mv/g 0.2-10,000 Hz Accelerometer Moutig Stud 1/4-28 to M8x1.25 SST Accelerometer Cable 15.2 m (50 ft) with straight coector Accelerometer Cable 9.1 m (30 ft) with straight coector 323314-01 323314-02 Accessories 100M9465-01 Miscellaeous Cable legths are 3, 6, 10, 25, 40, 50, 75, 85, 100, 120, 150, 200, 250 ad 320 feet. Buffered output cable 15-pi DSUB to 7 SMA coectors Buffered output cable 15-pi DSUB to 7 BNC coectors Betly Nevada Moitor Cofiguratio Software DVD BNMC Software is icluded with vbolie Pro Coditio Moitorig System for user admiistratio, IP cofiguratio ad firmware updates. 104M2708-01 Spare Power Iput Coector 104M3960-01 Spare Iput Coector Ch 1-10 104M3961-01 Spare Iput Coector Ch 11-12 104M3962-01 Spare Iput Coector KPH 1-2 Page 6 of 8
Graphs ad Figures Figure 1: vbolie Pro Dimesios i iches [millimetres] Figure 2: vbolie Pro - Side View Dimesios i iches [millimetres] Page 7 of 8
Copyright 2016-2017 Baker Hughes, a GE compay, LLC ("BHGE") All rights reserved. * Deotes a trademark of Betly Nevada, LLC, a wholly owed subsidiary of Baker Hughes, a GE compay. All product ad compay ames are trademarks of their respective holders. Use of the trademarks does ot imply ay affiliatio with or edorsemet by the respective holders. The iformatio cotaied i this documet is subject to chage without prior otice. 1631 Betly Parkway South, Mide, Nevada USA 89423 Phoe: 1-775.782.3611 www.gemeasuremet.com Page 8 of 8