Uniform, high efficacy and easy to design array

Transcription

1 Illumination LUXEON CoB Core Range (Gen 3) Uniform, high efficacy and easy to design array The third generation of LUXEON CoB represents a new breakthrough for arrays. The efficacies will be >160 lm/w for 70CRI and 80CRI products. Due to its small Light Emitting Surface (LES) and industryleading thermal resistance, LUXEON CoB is easy to work with, enabling simplified and less expensive luminaire designs. LUXEON CoBs are hot-tested at 85 C real world operating conditions which means additional testing can be minimized. LUXEON CoB LEDs are available in 3-step MacAdam ellipse, ensuring uniform optical performance in a wide range of applications. Features and Benefits Primary Applications Highest flux densities with industry s smallest LES Architectural 3-step MacAdam ellipse color definition: Freedom from Binning for color consistency from luminaire to luminaire Up to 4x lower thermal resistance than competition, enabling smaller heatsinks and higher lumens Supported by a comprehensive optical, mechanical and electrical ecosystem Downlights High Bay & Low Bay Lamps Outdoor Specialty Lighting Spotlights DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet 017 Lumileds Holding B.V. All rights reserved. No. E35519

2 Table of Contents General Product Information... Product Test Conditions... Part Number Nomenclature... Lumen Maintenance... Environmental Compliance...3 Performance Characteristics...3 Product Selection Guide....3 Optical Characteristics...8 Electrical and Thermal Characteristics....8 Absolute Maximum Ratings...8 Characteristic Curves...9 Spectral Power Distribution Characteristics...9 Light Output Characteristics...10 Forward Current Characteristics Radiation Pattern Characteristics...15 Color Bin Definitions...16 Mechanical Dimensions Packaging and Labeling Information....0 Tube...0 Inner Box.... Outer Box...3 DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. i

3 General Product Information Product Test Conditions LUXEON CoB Core Range (Gen 3) LEDs are tested and binned with a DC drive current specified below at a junction temperature, T j, of 85 C: 00mA LUXEON CoB 10s 00mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB mA LUXEON CoB 185 Part Number Nomenclature Part numbers for LUXEON CoB Core Range (Gen 3) follow the convention below: L C 5 A A B B C C C C D E E F F Where: A A designates nominal CCT (=00K, 7=700K, 30=3000K, 35=3500K, 40=4000K, 50=5000K, 56=5600K, 57=5700K, 65=6500K) B B designates minimum CRI (70=70CRI, 80=80CRI, 90=90CRI) C C C C designates product configuration (example: 10, 103, 104, 105, 108, 111, 116, 181, 131, 185) D designates options for product specification E E designates light emitting surface (LES) size (06=6mm, 09=9mm, 13=13mm, 15=15mm, 19=19mm, 3=3mm, 9=9mm, 3=3mm) F F designates options for product specification Therefore, the following part number is used for a LUXEON CoB 103, 3000K 80CRI, with a 9mm LES: L C E Lumen Maintenance Please contact your local Sales Representative or Lumileds Technical Solutions Manager for more information about the long-term performance of this product. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved.

4 Environmental Compliance Lumileds LLC is committed to providing environmentally friendly products to the solid-state lighting market. LUXEON CoB Core Range (Gen 3) is compliant to the European Union directives on the restriction of hazardous substances in electronic equipment, namely the RoHS Directive 011/65/EU and REACH Regulation (EC) 1907/006. Lumileds LLC will not intentionally add the following restricted materials to its products: lead, mercury, cadmium, hexavalent chromium, polybrominated biphenyls (PBB) or polybrominated diphenyl ethers (PBDE). Performance Characteristics Product Selection Guide Table 1. Product performance of LUXEON CoB Core Range (Gen 3) at specified test current, T j =85ºC. Product Nominal CCT [1] Luminous Flux (lm) Typical Minimum Luminous CRI [1,, 3] Minimum Typical Efficacy (lm/w) Test Current (ma) LES [4] (mm) Part Number LUXEON CoB 10s LUXEON CoB 10 00K LC5-8010E K LC E K LC E K LC E K LC E K LC E K [5] LC5-9010E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC5-8010E K LC E K LC E K LC E K LC E K LC E K [5] LC5-9010E K LC E K LC E K LC E K LC E0900 Table 1 continued on next page. 1. Lumileds maintains a tolerance of ± on CRI and ±6.5% on luminous flux measurements.. Typical CRI is approximately points higher than the minimum CRI specified, but this is not guaranteed. 3. R9 value of 90CRI products is > Light Emitting Surface (LES) is the inner diameter (phosphor area) inside the dam. 5. AtmoSphere Technology creates the ideal ambiance for restaurants and other hospitality venues. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 3

5 Table 1. Product performance of LUXEON CoB Core Range (Gen 3) at specified test current, T j =85ºC (continued). Product Nominal CCT [1] Luminous Flux (lm) Typical Minimum Luminous CRI [1,, 3] Minimum Typical Efficacy (lm/w) Test Current (ma) LES [4] (mm) Part Number LUXEON CoB 103 LUXEON CoB K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K [5] LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K [5] LC E K LC E K LC E K LC E K LC E1300 Table 1 continued on next page. 1. Lumileds maintains a tolerance of ± on CRI and ±6.5% on luminous flux measurements.. Typical CRI is approximately points higher than the minimum CRI specified, but this is not guaranteed. 3. R9 value of 90CRI products is > Light Emitting Surface (LES) is the inner diameter (phosphor area) inside the dam. 5. AtmoSphere Technology creates the ideal ambiance for restaurants and other hospitality venues. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 4

6 Table 1. Product performance of LUXEON CoB Core Range (Gen 3) at specified test current, T j =85ºC (continued). Product Nominal CCT [1] Luminous Flux (lm) Typical Minimum Luminous CRI [1,, 3] Minimum Typical Efficacy (lm/w) Test Current (ma) LES [4] (mm) Part Number LUXEON CoB 105 LUXEON CoB K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K [5] LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K [5] LC E K LC E K LC E K LC E K LC E1500 Table 1 continued on next page. 1. Lumileds maintains a tolerance of ± on CRI and ±6.5% on luminous flux measurements.. Typical CRI is approximately points higher than the minimum CRI specified, but this is not guaranteed. 3. R9 value of 90CRI products is > Light Emitting Surface (LES) is the inner diameter (phosphor area) inside the dam. 5. AtmoSphere Technology creates the ideal ambiance for restaurants and other hospitality venues. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 5

7 Table 1. Product performance of LUXEON CoB Core Range (Gen 3) at specified test current, T j =85ºC (continued). Product Nominal CCT [1] Luminous Flux (lm) Typical Minimum Luminous CRI [1,, 3] Minimum Typical Efficacy (lm/w) Test Current (ma) LES [4] (mm) Part Number LUXEON CoB 111 LUXEON CoB K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K [5] LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E300 00K LC E K LC E K LC E K LC E K LC E K LC E K LC E300 00K [5] LC E K LC E K LC E K LC E K LC E300 Table 1 continued on next page. 1. Lumileds maintains a tolerance of ± on CRI and ±6.5% on luminous flux measurements.. Typical CRI is approximately points higher than the minimum CRI specified, but this is not guaranteed. 3. R9 value of 90CRI products is > Light Emitting Surface (LES) is the inner diameter (phosphor area) inside the dam. 5. AtmoSphere Technology creates the ideal ambiance for restaurants and other hospitality venues. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 6

8 Table 1. Product performance of LUXEON CoB Core Range (Gen 3) at specified test current, T j =85ºC (continued). Product Nominal CCT [1] Luminous Flux (lm) Typical Minimum Luminous CRI [1,, 3] Minimum Typical Efficacy (lm/w) Test Current (ma) LES [4] (mm) Part Number LUXEON CoB 181 LUXEON CoB 131 LUXEON CoB K LC G K LC G K LC G K LC G K LC G K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC E K LC G K LC G K LC G K LC G K LC G K LC G K LC G K LC G K LC G K LC G K LC G K LC G K LC G300 Notes for Table 1: 1. Lumileds maintains a tolerance of ± on CRI and ±6.5% on luminous flux measurements.. Typical CRI is approximately points higher than the minimum CRI specified, but this is not guaranteed. 3. R9 value of 90CRI products is > Light Emitting Surface (LES) is the inner diameter (phosphor area) inside the dam. 5. AtmoSphere Technology creates the ideal ambiance for restaurants and other hospitality venues. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 7

9 Optical Characteristics Table. Optical characteristics for LUXEON CoB Core Range (Gen 3) at specified test current, T j =85 C. Part Number Typical Total Included Angle [1] Typical Viewing Angle [] LC5-xxxx1xxxxx Notes for Table : 1. Total angle at which 90% of total luminous flux is captured.. Viewing angle is the off axis angle from the LED centerline where the luminous intensity is ½ of the peak value. Electrical and Thermal Characteristics Table 3. Electrical and thermal characteristics for LUXEON CoB Core Range (Gen 3) at specified test current, T j =85 C. Part Number Forward Voltage [1] (V f ) Minimum Typical MAXIMUM Typical Temperature Coefficient of Forward Voltage [] (mv/ C) Typical Thermal Resistance Junction to CASE [3] ( C/W) LC5-xxxx10E LC5-xxxx10E LC5-xxxx103E LC5-xxxx104E LC5-xxxx105E LC5-xxxx108E LC5-xxxx111E LC5-xxxx116E LC5-xxxx181G LC5-xxxx131E LC5-xxxx185G Notes for Table 3: 1. Lumileds maintains a tolerance of ±% on forward voltage measurements.. Measured between 5 C and 85 C. 3. Thermal resistance is measured between junction and the bottom of the LUXEON CoB substrate. Absolute Maximum Ratings Table 4. Absolute maximum ratings for LUXEON CoB Core Range (Gen 3). Parameter Maximum Performance DC Forward Current [1,] x test current [3] LED Junction Temperature [1] (DC & Pulse) 15 C ESD Sensitivity (ANSI/ESDA/JEDEC JS ) Class 3B Operating Case Temperature [1] -40 C to 105 C LED Storage Temperature -40 C to 10 C Allowable Reflow Cycles 3 Reverse Voltage (V reverse ) LUXEON LEDs are not designed to be driven in reverse bias Notes for Table 4: 1. Proper current derating must be observed to maintain the junction temperature below the maximum allowable junction temperature.. Residual periodic variations due to power conversion from alternating current (AC) to direct current (DC), also called ripple, are acceptable if the following conditions are met: The frequency of the ripple current is 100Hz or higher The average current for each cycle does not exceed the maximum allowable DC forward current The maximum amplitude of the ripple does not exceed 0% of the maximum allowable DC forward current 3. Exception: LUXEON CoB 181 has a maximum DC forward current of.1a (1.75x test current). DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 8

10 Characteristic Curves Spectral Power Distribution Characteristics Figure 1a. Typical normalized power vs. wavelength for LC5-xx701xxxxx00 at specified test current, T j =85 C. Figure 1b. Typical normalized power vs. wavelength for LC5-xx801xxxxx00 at specified test current, T j =85 C. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 9

11 Figure 1c. Typical normalized power vs. wavelength for LC5-xx901xxxxx00 at specified test current, T j =85 C. Light Output Characteristics Figure. Typical normalized light output vs. junction temperature for LC5-xxxx1xxxxx00 at specified test current. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 10

12 LC5-xxxx10E0600 LC5-xxxx10E0900 LC5-xxxx103E0900 LC5-xxxx104E1300 LC5-xxxx105E1300 LC5-xxxx108E1500 DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 11

13 LC5-xxxx111E1900 LC5-xxxx116E300 LC5-xxxx181G900 LC5-xxxx131E900 LC5-xxxx185G300 Figure 3. Typical normalized light output vs. forward current for LUXEON CoB Core Range (Gen 3) at T j =85 C. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 1

14 Forward Current Characteristics LC5-xxxx10E0600 LC5-xxxx10E0900 LC5-xxxx103E0900 LC5-xxxx104E1300 LC5-xxxx105E1300 LC5-xxxx108E1500 DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 13

15 LC5-xxxx111E1900 LC5-xxxx116E300 LC5-xxxx181G900 LC5-xxxx131E900 LC5-xxxx185G300 Figure 4. Typical forward current vs. forward voltage for LUXEON CoB Core Range (Gen 3) at T j =85 C. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 14

16 Radiation Pattern Characteristics Figure 5. Typical radiation pattern for LC5-xxxx1xxxxx00 at specified test current, T j =85ºC. Figure 6. Typical polar radiation pattern for LC5-xxxx1xxxxx00 at specified test current, T j =85ºC. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 15

17 Color Bin Definitions Figure 7. 3-step MacAdam ellipse illustration for Table 5. Table 5. 3-step MacAdam ellipse color bin definitions for LUXEON CoB Core Range (Gen 3). Nominal CCT Color Space Center Point [1] (cx, cy) Major Axis, a Minor Axis, b Ellipse Rotation Angle, θ 00K Single 3-step MacAdam ellipse (0.500, ) K Single 3-step MacAdam ellipse (0.4578, ) K Single 3-step MacAdam ellipse (0.4338, ) K Single 3-step MacAdam ellipse (0.4073, ) K Single 3-step MacAdam ellipse (0.3818, ) K Single 3-step MacAdam ellipse (0.3447, ) K Single 3-step MacAdam ellipse (0.393, 0.343) K Single 3-step MacAdam ellipse (0.387, ) K Single 3-step MacAdam ellipse (0.313, 0.38) Notes for Table 5: 1. Lumileds maintains a tolerance of ±0.005 on x and y coordinates in the CIE 1931 color space. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 16

18 Mechanical Dimensions R1.6 x 16± ± ± xxxx ± ±0. LC5-xxxx10E0600 LC5-xxxx10E0900 R1.6 x 16± R1.6 x 15.5± ± ±0. 4± xxxx ± ± xxxx ±0.1 0±0. 0.5±0. LC5-xxxx103E0900 LC5-xxxx104E1300 DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 17

19 R1.6 x R1.6 x ± ± ±0. 4± xxxx ±0. 1± ± ±0. xxxx ± ±0. LC5-xxxx105E1300 LC5-xxxx108E1500 X x xxxx 111 xxxx C 8±0. L ± ±0. 1±0.1 8±0. LC5-xxxx111E1900 LC5-xxxx116E300 and LC5-xxxx181G300 DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 18

20 xxxx 131 xxxx 185 LC5-xxxx131E900 LC5-xxxx185G300 Figure 8. Mechanical dimensions for LUXEON CoB Core Range (Gen 3). DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 19

21 Packaging and Labeling Information LUXEON CoB Core Range (Gen 3) LEDs are packaged in tubes then in a carton box. Each tube contains a specified number of LEDs. The LEDs in each tube come from a single category code, ensuring they are all well-matched for light output, color, and forward voltage. Each tube contains a rubber stopper at one end. The tube label has both alphanumeric and bar code information. The carton boxes have printed information providing part numbers with CAT codes that indicate luminous flux, color and forward voltage bins. Table 6. Number of LEDs per tube for LUXEON CoB Core Range (Gen 3). Part Number TOTAL UNITS PER TUBE TOTAL TUBES PER Inner box TOTAL UNITS PER Inner box LC5-xxxx10E LC5-xxxx10E LC5-xxxx103E LC5-xxxx104E LC5-xxxx105E LC5-xxxx108E LC5-xxxx111E LC5-xxxx116E LC5-xxxx181G LC5-xxxx131E LC5-xxxx185G Tube Figure 9a. Tube dimensions for LC5-xxxx10E0600. Figure 9b. Tube dimensions for LC5-xxxx10E0900. Notes for Figures 9a and 9b: 1. Drawings not to scale.. All dimensions are in millimeters. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 0

22 Figure 9c. Tube dimensions for LC5-xxxx10xE1300 and LC5-xxxx108E1500. Figure 9d. Tube dimensions for LC5-xxxx111E1900, LC5-xxxx116E300 and LC5-xxxx181G300. Notes for Figures 9c, 9d and 9e: 1. Drawings not to scale.. All dimensions are in millimeters. Figure 9e. Tube dimensions for LC5-xxxx131E900 and LC5-xxxx185G300. Figure 10. Example of a tube label for LUXEON CoB Core Range (Gen 3). Notes for Figure 10 - Tube Label descriptions for customer use: Field labels not described are for Lumileds internal use only. 1. Lumileds part number.. Unique production lot identification number. This number is required for traceability purpose. 3. Product category code. 4. Number of LED emitters in a tube. 5. LED test date in YYWW format. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 1

23 Inner Box Figure 11. Dimensions for inner box packaging for LUXEON CoB Core Range (Gen 3). Table 7. Inner box information for LUXEON CoB Core Range (Gen 3). BOX TYPE DIMENSIONS (mm) H l W AVERAGE WEIGHT (100pcs/box) AVERAGE WEIGHT (100pcs/box) Inner Box Kg 0.305Kg Figure 1. Example of inner box label for LUXEON CoB Core Range (Gen 3). Notes for Figure 1 Inner Box Label descriptions for customer use: Field labels not described are for Lumileds internal use only. 1. Lumileds part number.. Number of LED emitters in a box. 3. LED test date in YYWW format. 4. Customer part number for custom requests only. 5. Unique production lot identification number. This number is required for traceability purpose. 6. Product category code. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved.

24 Outer Box INNER BOXES (40PCS) INNER BOXES (8PCS) INNER BOXES (0PCS) OUTER RSC OUTER RSC OUTER RSC (L) 510mm X (W) 90mm X (H) 1mm (L) 510mm X (W) 310mm X (H) 47mm (L) 510mm X (W) 360mm X (H) 30mm Figure 13. Dimensions for outer box packaging for LUXEON CoB (Gen 3). Table 8. Outer box information for LUXEON CoB Core Range (Gen 3). BOX TYPE DIMENSIONS (mm) H l W MAXIMUM INNER BOXES PER OuTER BOX MAXIMUM QUANTITY PER OUTER BOX AVERAGE WEIGHT (100pcs/box) AVERAGE WEIGHT (50pcs/box) Outer Box kg.77kg Outer Box kg 6.85kg Outer Box kg 13.70kg Figure 14. Example of outer box label for LUXEON CoB Core Range (Gen 3). Notes for Figure 14 Outer Box Label descriptions for customer use: Field labels not described are for Lumileds internal use only. 1. Country code of origin of manufacturing of parts (e.g. MY for Malaysia, CN for China) according to ISO alpha- document.. Lumileds part number. 3. Customer part number for custom requests only. 4. Total number of LED emitters in a shipment box. DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Lumileds Holding B.V. All rights reserved. 3

25 About Lumileds Lumileds is the global leader in light engine technology. The company develops, manufactures and distributes groundbreaking LEDs and automotive lighting products that shatter the status quo and help customers gain and maintain a competitive edge. With a rich history of industry firsts, Lumileds is uniquely positioned to deliver lighting advancements well into the future by maintaining an unwavering focus on quality, innovation and reliability. To learn more about our portfolio of light engines, visit lumileds.com. 017 Lumileds Holding B.V. All rights reserved. LUXEON is a registered trademark of the Lumileds Holding B.V. in the United States and other countries. lumileds.com DS16 LUXEON CoB Core Range (Gen 3) Product Datasheet Neither Lumileds Holding B.V. nor its affiliates shall be liable for any kind of loss of data or any other damages, direct, indirect or consequential, resulting from the use of the provided information and data. Although Lumileds Holding B.V. and/or its affiliates have attempted to provide the most accurate information and data, the materials and services information and data are provided as is, and neither Lumileds Holding B.V. nor its affiliates warrants or guarantees the contents and correctness of the provided information and data. Lumileds Holding B.V. and its affiliates reserve the right to make changes without notice. You as user agree to this disclaimer and user agreement with the download or use of the provided materials, information and data.