TMO-100 Telemetry, SCADA and Telecontrol using Tetra-Infrastructure. 05 September 2011 Mexico City, Mexico

Transcription

1 TMO-100 Telemetry, SCADA and Telecontrol using Tetra-Infrastructure 05 September 2011 Mexico City, Mexico Funk-Electronic Piciorgros GmbH Michael D. Piciorgros

2 Why TETRA and not. APCO 25 DMR WiMAX WiFi GSM, Edge, 2G, 3G, (4G) Other digital Wireless Systems

3 because? Try to compare all technical and commercial aspects of the following presentation with the mentioned technologies

4 What exactly is Telemetry and SCADA? Who needs Wireless Data Communication and Tele Control?

5 Question: What is SCADA?

6 SCADA (Supervise Control and Data Acquisition) The term SCADA basically includes the whole system starting from the Monitors and Computers in the Control Room, the Interfacing to the Infrastructure, the Infrastructure itself, up to the Outstations the PLC c and Sensors or Actors. The following Slides will demonstrate how the SCADA Control Room Part can be interfaced to Tetra Infrastructure using different options and how the data communication speed can be optimized. Ref.: Acquisition

7 Typical SCADA Server Layout Ref: Scada: Wikipedia Monitor: Samsung

8 A few pictures from different sites using wireless SCADA will demonstrate some typical applications

9 Surface Coal Mining (Water Level Control)

10 GAS Flow Control with Solar Power (Germany)

11 GAS Quality Control

12 Waste Water Monitoring Treatment Plant

13 Utility (Energy Companies)

14 Features needed for SCADA and Telemetry Applications, shown on one of the available TETRA SCADA Products: TMO-100 Similar Products may be available from: Motorola, Cassidian, Unimo, Sepura, Teltronics and other TETRA manufacturers

15 Tetra Modem - TMO-100

16 Power Supply: 12 Volt up to 24 Volt +/-20%

17 Heavy Duty Connectors

18 DIN-Rail Mounting

19 BNC Antenna Connector

20 16 digital Inputs including 8 Event Counter and 8 Timer (*) All inputs visible as LED

21 8 (16) digital Outputs PNP open Collector (500 ma each) All Outputs visible as LED

22 4 analog Inputs 0-20 ma or 4-20 ma

23 8 LED Field Strength Bar Graph

24 Two Serial Ports RS-232 or RS-485 / (RS-422)

25 10/100 MB Ethernet Port

26 Voice Option

27 How can I use all these TETRA Modem features? Each of the following examples use only a Windows PC with the on board Hyper Terminal Software!

28 Sending text from a computer to a TETRA terminal Windows/Mac Coffe is ready Coffe is ready

29 Sending a text message from a terminal to a computer Windows/Mac Need Support on Site Need Support on Site

30 Reading the RF-Field Strength using a Status Command RF = -78dBm

31 MMI Commands from Terminal to Outstation (MMI = Man Machine Interface) Switch on Light (or Output)

32 MMI Commands from PC to Outstation SCADA Server Switch on Light

33 File transfer with SDS / PD and standard Windows Terminal Tools (Hyper-Terminal) Windows/Mac Windows/Mac

34 I/O access via SDS (PD) to a TMO-100 Outstation SCADA Server

35 SCADA (PC) to PLC/RTU communication using SDS (PD) SCADA Server PLC

36 SCADA Server using Modbus or IEC access via SDS (PD) to a TMO-100 Outstation SCADA Server

37 Send an Alarm (Text) to a TETRA Terminal ALERT..

38 Send an Alarm (Text) to a Computer PC / MAC ALERT..

39 System Features:

40 TMO TETRA related Features SDS can be up to 255 bytes (2047 Bit) long. Type TL and TL 4 Circuit Switched Data supported (Straight Modem Access) Packet Switched Data (IP) supported Single and Multi Slot Packet Data supported (IP, speed, *) Secondary Control Channel supported Automatic PPP Link set up to the TETRA Switch Router Function with Port Forwarding and NAT Up to 3 Watt RF Output Power Encryption TEA1, TEA2, TEA3 Voice feature even with active Packet Data Link Build in Tetra Monitor (local and remote) via embedded Web Server Field Strength Indicator on the Front Panel Short Data or SDS can be sent as alarms (low field strength...) 350 MHz, 380 MHz, 410 MHz 450 MHz and 800 MHz available

41 TMO-100 Voice Option Standard 8 Pin Connector for Mic. Speaker handset One Group Number (GISSI) to be programmed Seven individual Numbers (ISSI) to be programmed ISSI and GISSI to be programmed locally or remotely using the embedded Web Server Select ISSI / GISSI by number of PTT presses Automatic PPP disconnect when pressing PTT Automatic PPP re connect after Voice timeout or reject Software Interfaces available for Smart Control via AUX Interface or Ethernet Port

42 TMO-100 Protocol and I/O related Features All digital and analog I/O isolated Serial Port COM / AUX available as RS-232 or RS-485/(422) Level 1 Protocol: Timeout or 3964R Device Protocol to access internal Registers: Modbus RTU Serial Protocols to be forwarded: Modbus RTU, DNP3, IEC , PakBus, user Defined Ethernet 10/100 MBit IP-Port for Local Network UDP and TCP supported Embedded Web Server as Configuration Tool Modbus/IP, IEC , DNP3 IP, others Low Power Consumption: < Volt (typical 80 ma)

43 PicoLogo User Application Interface Easy to use graphical user interface Optimized for Tetra Infrastructure Basic Logic Functions (and, or, exor, ) Complex Logic Functions (delay on, delay off, flip flop, ) Analog Functions (analog compare, ) Timer and Clock Functions (time, date, Dynamic Text Message generation for Alarms and Status GPS Functions (position, ) Modbus RTU Slave (set and read register, coil, ) Modbus RTU Master (set and read register, coil, ) send (sending text and alarm messages by ) SNMP Trap (automated machine messaging) more

44 PicoLogo User Application Interface, Design

45 TMO-100 Embedded Web Server Web Server to be used as Configuration Tool for the Device, Protocols and IP Parameter, Configuration Tool for TETRA Network Parameter, Configuration for the Voice Option TETRA Monitor Device Monitor Error Log Web Server can be accessed locally using the IP Port and remotely over the TETRA Infrastructure Easy to be used with any Web Browser (Firefox, Internet Explorer, )

46 TMO-100 Embedded Web Server

47 myscad Embedded SCADA Functionality IP Access to myscad (embeded SCADA) Access over TETRA infrastructure Low TETRA traffic, graphics loaded from local server Up to 10 different SCADA pages On / Off, text, one bit, sixteen bit and analogue Functions Easy to manage and to design

48 myscad Screen Capture

49 TMO-100 Live Demo Demo-Laptop Connect_To-TMO-100_in_Germany

50 Please don t forget: All of that was: Yes, we can! So, can the others too???

51 Funk - Electronic Piciorgros GmbH Claudiastr Köln-Porz Germany Thank you very much for your interest in our Products