1983 CX650C Parts Manual

Transcription

1 1983 CX650C Parts Manual The data contained herein was collected from sources on the Internet freely available to the general public. Disclaimer: The information contained herein is believed to be accurate but the user of this data assumes all risk associated with its usage. 1

2 Table of Contents Air Cleaner... 4 Alternator & Starter Clutch... 5 Battery & Sidecovers... 6 Block, Cylinder... 7 Brake Caliper... 9 Brake Lines, Front & Master Cylinder & Lever Brake Panel, Rear & Rear Axle Camshaft & Tachometer Gear Camshaft Chain & Tensioner Carburetors Clutch Clutch Cover & Oil Filter Coolant Reserve Tank & Engine Hangers Crankshaft & Pistons Cylinder Head, Left Cylinder Head, Right Cylinder Head Covers Electrical Plate & Modules Emblems Engine Cover, Front (Transmission Cover) Engine Cover, Rear Exhaust System Fender, Front Fender, Rear Final Shaft Footpegs Forks Frame Fuel Tank & Petcock Gasket Kit A Gasket Kit B Handlebar & Top Bridge & Fuse Panel & Lockset Handlebar Controls & Mirrors Headlight Instruments: Speedometer & Tachometer & Lights Oil Pan Oil Pump & Primary Drive Gear Pedal, Brake & Shift Pedal Radiator & Cooling Fan & Grille Rear End Seat Shifter Drum & Forks Shock Absorbers, Rear

3 Stand, Center & Side Stand Starter Motor Steering Stem & Horns Swingarm Tail Light Thermostat & Coolant Pipes & Hoses Tools Transmission Turn Signals Valves & Rocker Arms Water Pump & Ignition Pulse Generator Wheel, Front & Brake Disc Wheel, Rear Wire Harness & Ignition Coils

4 Air Cleaner 01 HOUSING, AIR CLEANER ME RUB, BREATHER TANK MF5-000 (replaces ME8-000) COVER, A/CLNR HSG ME ELEMENT, AIR CLEANER ME SEAL MN4-405 (replaces ME8-000) STAY ME TUBE, R ME BAND, A/CLNR TUBE (replaces ) TUBE, L ME TUBE, BREATHER ME FILTER TUBE ME PLUG, BREATHER TUBE TANK, STORAGE ME CLIP (16MM) COLLAR, CHAIN GUARD GROMMET, SIDE COVER MA BOLT, FLANGE (6X20) SCREW, PAN (4X25) A SCREW-WASHER (6X20) CLIP, TUBE (A15) CLIP, TUBE (B12.5) BOLT, FLANGE (6X12) BOLT, FLANGE (6X12)

5 Alternator & Starter Clutch 01 GEAR SET, STARTER GEAR SHAFT GEAR MF5-000 (replaces ) CLUTCH, STARTER SPRING CAP ALTERNATOR ASSY MA ROTOR MA STATOR MA BOLT (12X30) BOLT,SOCKET 8MM KCJ-690 (replaces ) WASHER (12MM) WASHER (37MM) BEARING (32MM) ROLLER (15X13) BOLT, FLANGE (6X40) (replaces ) 003 5

6 Battery & Sidecovers 01 BATTERY (YB14-A2) MW3-720 (replaces MB1-671) (replaces MB1-672) TUBE ME CABLE ME BAND A, BATTERY ME BAND B, BATTERY ME GROMMET, A/CLNR HSG RUBBER, BATTERY BOX COVER, R. *R114CU* ME8-000ZA CVR, R. SIDE *NH1Z* ME8-000ZB COVER, L. *R114CU* ME8-000ZA CVR, L. SIDE *NH1Z* ME8-000ZB NUT, CAP (6MM) (replaces S) (replaces ) PIN, COTTER (3.0X45) (replaces ) BOLT, FLANGE (6X10) BOLT, FLANGE (6X10)

7 Block, Cylinder 01 BLOCK, CYLINDER ME BLOCK, CYLINDER ME SPACER, R. EMBLEM ME SPACER, L. EMBLEM ME EMBLEM, R MG EMBLEM, L MG HOLDER, TRANSMISSION MC ORIFICE (8MM) MC CAP, CRANKSHAFT ME JET, R. OIL ME SEPARATOR, OIL ME VALVE BEARING A, MAIN MC BEARING B, MAIN MC BEARING C, MAIN MC COLLAR, O-RING

8 14 DIPSTICK, OIL MK7-670 (replaces ) BOLT, FLANGE (6X20) MB2-000 (replaces MC7-000) WASHER (12MM) O-RING (22X3.0) (replaces ) O-RING (13.6X2.4) O-RING (8X1.7) HB3-003 (replaces ) O-RING (8.2X1.5) MC BOLT, STUD (10X90) B SCREW, OVAL (4X8) G SCREW, TAPPING (4X8) NUT, FLANGE (10MM) PIN, DOWEL (8X14) BOLT, FLANGE (6X12) (replaces ) BOLT, FLANGE (6X16) (replaces ) BOLT, FLANGE (6X32) (replaces ) BOLT, FLANGE (8X25) (replaces ) 007 8

9 Brake Caliper 01 PAD, RR MJ6-014 (replaces MC7-007) (replaces MC7-014) (replaces MJ6-004) PISTON MA SCREW, BLEEDER CAP, BLEEDER CLAMP ME CALIPER, L. FR ME4-016 (replaces ME4-006) (replaces ME4-007) CALIPER, L MB SPRING, PAD MA DUST SEAL MA BRACKET, L. FR MA SLEEVE MA RETAINER, BRACKET PIN, BOLT MA BOOT B MA BOOT, PIN SEAL, PISTON MA PIN, HANGER MA PLATE MA BOLT, FLANGE (8X49) MA BOLT, FLANGE (6X10) (replaces ) BOLT, FLANGE (6X10) (replaces ) BOLT, FLANGE (10X40) BOLT, FLANGE (10X40) BOLT,FLANGE NI BRAKE PAD KIT 431A0-MC

10 Brake Lines, Front & Master Cylinder & Lever 01 SWITCH, FR. STOP MA HOSE, FR. BRAKE ME8-672 (replaces ME8-671) MASTER CYLINDER, FR ME8-673 (replaces ME8-671) BOOT PROTECTOR MA CAP MA HOLDER MB DIAPHRAGM MA5-672 (replaces MA5-671) BOOT MASTER CYLINDER SET MA LEVER, R. HANDLEBAR MA6-016 (replaces MA6-006) BOLT, R MA BOLT, SOCKET (6X23) MB BOLT, OIL (10X22) KM3-751 (replaces ) (replaces KE8-000) (replaces KM3-750) WASHER, OIL BOLT CIRCLIP MA SCREW, FLAT (4X12) G (replaces G) SCREW-WASHER (4X12) (replaces ) NUT, FLANGE (6MM)

11 Brake Panel, Rear & Rear Axle 01 AXLE, RR. WHEEL ME COLR, RR. AXLE SIDE ME PANEL, RR ME WASHER, ANCHOR PIN (replaces ) SHOE, BRAKE MW3-671 (replaces ) DUST SEAL, BRAKE CAM CAM, RR. BRAKE MB0-010 (replaces MB0-000) INDICATOR, RR. BRAKE ARM, RR. BRAKE RUBBER SPRING, FR BOLT, RR WASHER A (replaces ) NUT, HEX. (8MM) S NUT, FLANGE (8MM) PIN, COTTER (2.0X35) (replaces ) (replaces ) (replaces ) (replaces ) (replaces ) PIN, COTTER (2.0X22) PIN, SPLIT (2.0X22) PIN, COTTER (2.5MM) (replaces ) (replaces ) BOLT, FLANGE (8X40) (replaces ) 001 NI SHOE KIT, BRAKE MW3-671 (replaces ) (replaces 431A )

12 Camshaft & Tachometer Gear 01 HOLDER, CAMSHAFT ME GASKET (replaces ) GEAR, TACHOMETER CAMSHAFT ME ARM A, ROCKER ARM B, ROCKER SHAFT, ROCKER ARM ME7-000 (replaces ) SPRING A BOLT, SPECIAL (6X30) WASHER (26MM) WASHER WASHER (6.7MM) COLLAR (28MM) ME ROLLER (5X8.5) OIL SEAL (6X14.5X5) (replaces ) SCREW, PAN (5X20) G BOLT, FLANGE (6X28) (replaces )

13 Camshaft Chain & Tensioner 01 SPROCKET, CAM BOSS, CAM SPROCKET CHAIN, CAM MA TENSIONER, CAM CHAIN MC TENSIONER, CAM CHAIN MC COLLAR (6X14.7) PIN MC GUIDE, CAM CHAIN MC PLATE MC BOLT, HEX. (6X30) BOLT, FLANGE (8X32) MC BOLT (7X17) NUT, LOCK (20MM) MJ8-000 (replaces ) WASHER, LOCK BOLT, FLANGE (6X16) (replaces )

14 Carburetors 01 GASKET SET ME2-305 (replaces ME2-671) NEEDLE SET, JET ME FLOAT SET (replaces ) CHAMBER SET, FLOAT MC SCREW SET A KC2-970 (replaces ) ROD SET, PUMP ME DIAPHRAGM SET, PUMP ME PISTON SET, VACUUM SCREW SET B ME SCREW SET C PC6-005 (replaces ) HOLDER SET, ADJ ME JOINT SET, FUEL ME JOINT SET, FUEL ME CHAMBER SET C, FLOAT (replaces ) VALVE SET, AIR CUT KB7-901 (replaces KB7-004) SPRING ME BOLT ME CARBURETOR ASSY ME8-672 (replaces ME8-671) CARBURETOR ASSY., R ME CARBURETOR ASSY., L ME VALVE, FLOAT HOLDER, NEEDLE JET NOZZLE, MAIN ME TUBE KG4-405 (replaces ) SCREW-WASHER (4X10) SCREW-WASHER (4X12) SCREW-WASHER (4X16) SCREW-WASHER (5X12) SCREW-WASHER (5X16) SCREW-WASHER (6X14)

15 31 CLIP, TUBE (B6.5) JET, MAIN (#78) GHB-0780 (replaces ) JET, MAIN (#122) GHB-1220 (replaces ) (replaces ) JET, SLOW (#45) MA

16 Clutch 01 CLUTCH (OUTER) ME GUIDE, CLUTCH ME7-000 (replaces ME2-000) CENTER, CLUTCH ME DISK, CL FRICTION DISK, CL FRICTION (replaces ) DISK B, CL FRICTION (replaces ) PLATE B, CLUTCH PLATE B, CLUTCH PLATE, CLU PRESS ME PLATE, CLUTCH LIFTER SPRING, CLUTCH ME BOLT (6X22) NUT, LOCK (20MM) WASHER, LOCK WASHER (25MM) ME BEARING (32X42X20) ME BEARING (6000)

17 Clutch Cover & Oil Filter 01 COVER, CLUTCH GASKET, CLUTCH COVER (replaces ) CASE, OIL FILTER ELEMENT, OIL FILTER 154A SEAT SPRING BOLT MA6-000 (replaces ) SHAFT, CLUTCH LEVER MG SPRING, CLUTCH LEVER ROD, CLUTCH LIFTER OIL SEAL (12X18X4) O-RING (15X2.5) O-RING (81X4.5) MA6-003 (replaces ) CIRCLIP (10MM) BOLT, FLANGE (6X28) (replaces ) BOLT, FLANGE (6X28)

18 Coolant Reserve Tank & Engine Hangers 01 JOINT, BREATHER TUBE TANK, RESERVE ME CAP, RESERVE TANK CABLE, CAP LOCK GASKET, RESERVE TANK REFLECTOR, FR BRKT, R. FR. ENG HGR ME CAP, FR. ENG HGR MA BRKT, L. FR. ENG HGR ME CAP, TOOL BOX ME LABEL, RESERVE TANK LABEL MA BOLT, FLG (12X155) ME BOLT, FLANGE (6MM) BOLT, FLG (10X155) GE1-670 (replaces ME8-000) NUT, FLANGE (6MM) NUT, FLANGE (10MM) NUT, FLANGE (12MM) BULK HOSE (7.5X8000) M BULK HOSE (7.5X8000) M CLIP, TUBE (B12)

19 Crankshaft & Pistons 01 RING SET (STD) ME RING SET (OS 0.25) ME RING SET (OS 0.50) ME PISTON, R. (STD) ME PISTON, R. (0. 25) ME PISTON, R. (0. 50) ME PISTON, L. (STD) ME PISTON, L. (0. 25) ME PISTON, L. (OS 0.50) ME PIN, PISTON ME NUT, CONNECTING ROD ME ROD, CONNECTING ME BOLT, CONNECTING ROD ME BEARING B, CONN ROD ME BEARING C, CONN ROD ME BEARING D, CONN ROD ME BEARING E, CONN ROD ME BEARING F, CONN ROD ME CRANKSHAFT ME WASHER, CRANK SIDE ME KEY (25X18) CLIP (21MM)

20 Cylinder Head, Left 01 CYLINDER HEAD, L ME GUIDE, IN VALVE MG8-405 (replaces ) GUIDE, IN VALVE MG8-405 (replaces MA1-305) GASKET, CYL HD ME2-405 (replaces ME2-000) INSULATOR, L. CARB ME BAND (56) (replaces ) (replaces GHB-710) BOLT, FLANGE (8X55) (replaces ME2-000) WASHER (5MM) WASHER (10X24) (replaces MA1-000) O-RING (6.9X1.5) O-RING (40X2.4) (replaces ) BOLT, STUD (6X55) B BOLT, STUD (10X80) B (replaces ) SCREW, PAN (5X8) A SCREW, PAN (5X20) G NUT, FLANGE (10MM) PIN, DOWEL (8X14) BOLT, FLANGE (6X22) (replaces ) S/PLG (DPR8EA-9) S/PLG (X24EPR-U9) S/PLG (DPR9EA-9) S/PLG (X27EPR-U9)

21 Cylinder Head, Right 01 CYLINDER HEAD, R ME GUIDE, IN VALVE MG8-405 (replaces ) GUIDE, IN VALVE MG8-405 (replaces MA1-305) GASKET, CYL HD ME2-405 (replaces ME2-000) INSULATOR, R. CARB ME BAND (56) (replaces ) (replaces GHB-710) BOLT, FLANGE (8X55) (replaces ME2-000) WASHER (5MM) WASHER (10X24) (replaces MA1-000) O-RING (6.9X1.5) O-RING (40X2.4) (replaces ) BOLT, STUD (6X55) B BOLT, STUD (10X80) B (replaces ) SCREW, PAN (5X8) A SCREW, PAN (5X20) G NUT, FLANGE (10MM) PIN, DOWEL (8X14) BOLT, FLANGE (6X22) (replaces ) S/PLG (DPR8EA-9) S/PLG (X24EPR-U9) S/PLG (DPR9EA-9) S/PLG (X27EPR-U9)

22 Cylinder Head Covers 01 HOLDER ME7-000 (replaces ) COVER, CYLINDER HEAD ME GASKET, HEAD COVER GASKET, PLUG HOLE BOLT, SPECIAL (6X60) MC BOLT, FLG (12X150) RUBBER, SETTING PIN, DOWEL (14X20)

23 Electrical Plate & Modules 01 MODULE, IGN CONT MA4-601 (replaces ) RECTIFIER, REGULATOR ME CABLE ME CABLE, STARTER MOTOR ME COVER (replaces ) COVER ME COVER, BATTERY ME COVER A SWITCH MJ0-000 (replaces ME8-007) COVER, FUSE ME RUB, SHOCK ABSORBER MB RELAY, TURN SIGNAL MG9-681 (replaces MB0-004) SUSPENSION PLATE, ELECTRIC ME COLLAR NUT, HEX. (6MM) S WASHER, PLAIN (6MM) NUT, FLANGE (6MM) WASHER, SPRING (6MM) BOLT, FLANGE (6X12) BOLT, FLANGE (6X12) FUSE F (30A)

24 Emblems 01 EMBLEM, R. FUEL TANK ME EMBLEM, L. FUEL TANK ME EMBLEM, RR. (TYPE1) ME8-000ZA EMBLEM, RR. (TYPE2) ME8-000ZB

25 Engine Cover, Front (Transmission Cover) 01 COVER, TRANSMISSION ME GASKET, TRANS CVR ME2-306 (replaces ME2-000) CAP MC PIPE, OIL PASSAGE ME O-RING (11.8X2.4) ZE9-003 (replaces ) (replaces ZE9-000) (replaces HA5-000) (replaces HA5-003) O-RING (11.8X2.4) MJ CLAMP, CABLE SUB-WIRE KAZ-000 (replaces MA1-730) SWITCH, OIL PRESSURE MJ4-024 (replaces MB9-004) (replaces MJ0-004) (replaces MJ4-004) (replaces MJ4-014) O-RING (27.5X2.6) (replaces ) PIN, DOWEL (8X14) BOLT, FLANGE (6X14) (replaces ) BOLT, FLANGE (6X14) (replaces ) BOLT, FLANGE (6X28) (replaces )

26 Engine Cover, Rear 01 COVER, RR ME GASKET, RR. COVER (replaces ) CAP MC GUIDE, NEUTRAL CABLE SWITCH, NEUTRAL (replaces ) (replaces ) COLLAR (22.2MM) OIL SEAL (14X26X6) ZW5-003 (replaces ) (replaces ) O-RING (27.5X2.6) (replaces ) NUT, HEX. (4MM) S WASHER, SPRING (4MM) PIN, DOWEL (10X16) O-RING (23X2.8) BOLT, FLANGE (8X40) (replaces ) BOLT, FLANGE (6X14) (replaces ) BOLT, FLANGE (6X32) (replaces )

27 Exhaust System 01 JOINT, EX. PIPE GASKET, EX. PIPE (replaces ) GASKET, PROTECTOR MM9-740 (replaces ) (replaces KF9-900) PRE CHAMBER ME8-611 (replaces ME8-671) PROTR, R. CHAMBER ME PIPE, R. EX ME8-611 (replaces ME8-671) MUFFLER, R ME8-405 (replaces ME8-671) BAND, R. FR. MUFFLER BAND, L. FR. MUFFLER BAND, R. RR. MUFFLER BAND, L. RR. MUFFLER GASKET, MUFFLER MK4-000 (replaces ) (replaces ) GASKET, RR. MUFFLER MG7-750 (replaces ) PROTR, L. CHAMBER ME PIPE, L. EX ME8-611 (replaces ME8-671) MUFFLER, L ME8-405 (replaces ME8-671) BOLT, FLANGE (8X37) SCREW-WASHER WASHER, LOCK MA BOLT-WASHER (6X12) BOLT-WASHER (6X12) NUT, FLANGE (6MM) NUT, FLANGE (8MM) RUBBER A BOLT, FLANGE (8X20)

28 (replaces ) (replaces ) BOLT, FLANGE (8X50) BOLT, FLANGE (8X50)

29 Fender, Front 01 FENDER, FR ME8-405 (replaces ME8-000) BOLT, FLANGE (6X14) (replaces )

30 Fender, Rear 01 REFLECTOR, REFLEX ME SENSOR, STOP & TAIL ME SUSPENSION ME COLLAR HOLDER ASSY., HELMET MB1-871 (replaces MB1-701) (replaces MB1-870) E-CLIP COLLAR, SEAT LOCK LOCK ASSY., LID SPRING WASHER, SEAT SETTING FENDER A, RR ME FENDER B, RR ME RUBBER B, RR. FENDER CLAMP, CABLE BASE, R ME BASE, L ME LID, TAIL BOX ME PLATE, LOCK ME BOX ASSY., TAIL ME GROMMET, A/CLNR HSG GE BRACKET, R. RR. GRIP ME BRACKET, L. RR. GRIP ME PIPE, RR. GRIP ME COLLAR, RR. GRIP ME RUBBER, BATTERY BOX COWL, RR. *R114CU* 837A3-ME8-000ZA COWL SET, RR. *NH1Z* 837A3-ME8-000ZB CAP, RR. SHOCK TOP ME EMBLEM, RR. COWL ME STAY, RR. COWL ME RUBBER, RR. COWL ME PIPE, L. GRIP ME RUBBER, RR PIPE, R. GRIP ME RUBBER

31 35 COLR, MIRROR SETTING GA BOLT, SOCKET (8MM) BOLT, SOCKET (8X42) 0166-ME COLLAR (6.2X12) WASHER, RR. COVER WASHER (10MM) MA SCREW, PAN (6X18) A (replaces ) NUT, FLANGE (5MM) NUT, FLANGE (6MM) WASHER, PLAIN (5MM) BOLT, FLANGE (6X25) BOLT, FLANGE (6X25) BOLT, FLANGE (6X32) (replaces ) BOLT, FLANGE (8X14) (replaces )

32 Final Shaft 01 SHAFT, FINAL MG LIFTER, DAMPER MA CAM, DAMPER MC STOPPER SPRING, DAMPER MA WASHER BEARING (62/22) PL0-018 (replaces PL0-008) (replaces ) (replaces ) (replaces ) (replaces ) (replaces ) OIL SEAL (22X36X7) MC7-000 (replaces ) (replaces )

33 Footpegs 01 STAY, STOP SWITCH ME PIN, STEP BAR JOINT (replaces ) FOOTPEG, R. MAIN ME8-000 (replaces ME8-305) BAR, R. FOOTPEG ME BAR, R. FOOTPEG ME ARM, R. FOOTPEG ME SPRING SLIDER, STEP MB STOPPER, STEP RUBBER MB FOOTPEG, L. MAIN ME FOOTPEG, L. MAIN ME ARM, L. FOOTPEG ME BAR, L. FOOTPEG ME BAR, L. FOOTPEG ME RUBBER, FOOTPEG ME RUBBER, MAIN FOOTPEG ME HOLDER, R ME HOLDER, L ME FOOTPEG, R. PILLION ME FOOTPEG, L. PILLION ME BAR, R. PILLION STEP MB BAR, L MB RUBBER, PILLION STEP MB WASHER, PILLION STEP MB COLR, BUZZER SETTING BOLT, SOCKET (8X28) MA6-750 (replaces ) BOLT, SOCKET (10X25) ME BOLT, HEX. (6X16) A (replaces A) (replaces A) NUT, FLANGE (10MM) WASHER, PLAIN (6MM) (replaces ) (replaces ) WASHER, PLAIN (8MM)

34 28 PIN, COTTER (1.6X10) PIN, COTTER (1.6X25) (replaces ) PIN C BOLT, FLANGE (6X10) (replaces ) BOLT, FLANGE (10X20) (replaces )

35 Forks 01 FORK ASSY., R. FR ME SPRING, FR. FORK ME COLLAR, SPRING ME PLATE, SPRING JOINT ME PIPE, FR. FORK ME SPRING, REBOUND ME RING, BACK-UP BUSH, FORK PIPE SLEEVE, FORK PIPE CASE, R. (LOWER) ME PIECE, OIL LOCK RING, PISTON ME HOLDER, GREASE MB WASHER, HOLDER MB PIPE, SEAT ME CIRCLIP (INNER) BOLT ASSY., FR. FORK ME VALVE, AIR CAP, AIR VALVE MG SEAL SET, FR. FORK MB9-782 (replaces ) (replaces MB9-781) (replaces MG2-305) FORK ASSY., L. FR ME CASE, L. (LOWER) ME STABILIZER, FR. FORK MB1-050 (replaces MB1-010) (replaces MB1-020) (replaces MB1-030) (replaces MB1-040) BOLT, SOCKET (8X27) (replaces ) BOLT, SOCKET (8X28) ME BOLT, SOCKET (8X17) MB0-405 (replaces MB0-000) GASKET, FR WASHER (8MM) DUST SEAL

36 30 O-RING (29.2X3.5) MA CAP (8MM) MB0-010 (replaces MB0-000) BOLT, HEX. (6X8) A (replaces A)

37 Frame 01 FRAME ME STAY, R. SIDE COVER ME STAY, L. SIDE COVER ME COVER, FR. SIDE ME LABEL ME BOLT, FLG (12X308) SCREW-WASHER (5X16) NUT, HEX. (10MM) NUT, FLANGE (6MM) NUT, FLANGE (12MM) BOLT, FLANGE (10X70) (replaces )

38 Fuel Tank & Petcock 01 O-RING (2.4X18.6) GHB-B GASKET SET, PETCOCK GASKET GASKET O-RING (2.4X18.6) GHB-B00 (replaces ) (replaces ) PETCOCK ASSY., AUTO ME8-015 (replaces ME8-005) BODY, PETCOCK MA1-732 (replaces MA1-731) FILTER SET, FUEL (replaces ) COVER SET, PETCOCK ME5-005 (replaces ) O-RING (10.6X1.3) (replaces MA1-731) FILTER, CUP CUP, FUEL STRAINER GA TANK, FUEL *R114CU* 175A1-ME8-000ZA TANK, FUEL *NH1Z* 175A1-ME8-000ZB RUBBER, FR. TANK COLLAR, FR RUB, RR. FUEL TANK ME CAP, FUEL FILLER MB1-033 (replaces MB1-013) 001 (replaces MB1-023) LABEL, FR. (TYPEG) ME8-670ZA LABEL *A73* (TYPEG) ME9-670ZA BOLT, FLANGE (8X36) COLLAR MA WASHER (8.3MM) SCREW-WASHER (4X8) BULK HOSE (7.5X8000) M CLIP, TUBE (B7) CLIP, TUBE (B12) CLIP, TUBE (C6.5) BULK HOSE (3.5X1000) M BULK HOSE (3.5X1000) M

39 26 BOLT, FLANGE (8X28) (replaces )

40 Gasket Kit A (Image Not Available) 00 GASKET KIT A 061A1-ME2-405 (replaces 061A1-ME2-000) SEAL, VALVE STEM MB9-003 (replaces ) GASKET (replaces ) GASKET, CYL HD ME2-405 (replaces ME2-000) GASKET, HEAD COVER GASKET, PLUG HOLE GASKET, EX. PIPE (replaces ) O-RING (6.9X1.5) O-RING (21.9X2.3) MB6-003 (replaces ) (replaces ) SEAL, WATER PIPE O-RING (53.8X3.1) O-RING (13.5X1.4) PH7-660 (replaces ) O-RING (40X2.4) (replaces ) O-RING (23X2.8)

41 Gasket Kit B (Image Not Available) 00 GASKET KIT B 061B1-ME2-T00 (replaces 061B1-ME2-000) GASKET, OIL PAN ME2-306 (replaces ME2-000) GASKET, CLUTCH COVER (replaces ) GASKET, TRANS CVR ME2-306 (replaces ME2-000) GASKET, RR. COVER (replaces ) GASKET O-RING (11.8X2.4) ZE9-003 (replaces ) (replaces ZE9-000) (replaces HA5-000) (replaces HA5-003) O-RING (11.8X2.4) MJ GASKET, PULSER COVER MC7-306 (replaces MC7-000) O-RING (22X3.0) (replaces ) O-RING (13.6X2.4) O-RING (27.5X2.6) (replaces ) O-RING (15X2.5) O-RING (8X1.7) HB3-003 (replaces ) O-RING (81X4.5) MA6-003 (replaces ) O-RING (15.3X3.5) MC O-RING (23X2.8)

42 Handlebar & Top Bridge & Fuse Panel & Lockset 01 LOCK SET ME8-010 (replaces ME8-000) SWITCH ASSY ME BASE, CONTACT MC5-000 (replaces MA6-007) KEY, BLANK (TYPE1) KW3-771 (replaces MA6-811) KEY, BLANK (TYPE2) KW3-771 (replaces MA6-811) PLATE ASSY., FUSE ME COVER, FUSE ME LABEL, FUSE MG HANDLEBAR ME WEIGHT B, HANDLEBAR MC WEIGHT, HANDLE ME RUB, HANDLE WEIGHT HOLDER, HANDLEBAR MF5-750 (replaces ME8-000) BRIDGE, FORK TOP ME BOLT, FLANGE (8X19) KB BOLT, SOCKET (7X32) MB BOLT, SOCKET (8X32) ME NUT, STEERING STEM KA WASHER PIN, SPRING (4X21) ME CAP (8MM) MB0-010 (replaces MB0-000) SCREW, FLAT (5X8) G SCREW, OVAL (6X60) B FUSE B (15A)

43 Handlebar Controls & Mirrors 01 CABLE A, THROTTLE KK9-950 (replaces ME8-000) CABLE B, THROTTLE ME CABLE, CHOKE ME LEVER, CHOKE ME HOLDER, CHOKE LEVER ME WASHER, WAVE (22MM) ME CABLE, CLUTCH ME SWITCH ASSY., STAR ME8-305 (replaces ME8-670) SWITCH, TURN SIGNAL ME SWITCH, FR. LEVER PIPE, THROTTLE GRIP GRIP, R. HANDLE KR3-680 (replaces ME8-000) GRIP, L. HANDLE KR3-680 (replaces ME8-000) BRKT, L. HANDLEBAR ME LEVER, L. HANDLEBAR MA6-000 (replaces ) (replaces MC3-700) BOOT, HANDLEBAR BOLT, CABLE ADJ (replaces ) MIRROR, R ME MIRROR, L ME BOLT, L BOLT, SOCKET (6X23) MB NUT, FIXING SCREW-WASHER (5X30) SCREW-WASHER (5X35) (replaces ) NUT, FLANGE (6MM) BAND B1, CABLE

44 Headlight 01 HDLT (12V 65/45W) ME HDLT (12V 60/55W) MF RIM, HEADLIGHT MB SCREW SPRING (replaces MB1-671) NUT, BEAM ADJUSTING WASHER HEADLIGHT UNIT MF5-751 (replaces MB1-671) (replaces ME9-670) NUT, UNIT HOLDER COVER, SCREW CASE, HEADLIGHT ME STAY, R. HEADLIGHT ME STAY, L. HEADLIGHT ME BOLT, SOCKET (8X22) KV0-000 (replaces MB4-000) CLAMP, CLUTCH CABLE ME SCREW, PAN (5X8) H SCREW, PAN (5X12) B WASHER, SPRING (5MM) BOLT, FLANGE (8X20) BOLT, FLANGE (8X20)

45 Instruments: Speedometer & Tachometer & Lights 01 BULB (12V3.4W2CP) SA5-003 (replaces GA7-701) (replaces ) (replaces SA5-004) BULB (12V/3W) MB0-003 (replaces MB0-000) (replaces MB0-005) METER, COMBINATION ME WIRE, PILOT ME SPEEDOMETER ASSY ME4-671 (replaces ME8-671) COVER, SPEEDOMETER ME SOCKET, SPEEDOMETER ME RUBBER, SPEEDOMETER ME RUBBER ME BRACKET A, METER ME BRACKET B, METER ME WASHER, PLAIN MA TACHOMETER ASSY ME8-611 (replaces ME8-671) COVER, TACHOMETER ME SOCKET, TACHOMETER ME RUBBER, TACHOMETER ME CABLE, TACHOMETER ME COLLAR B ME COLLAR A ME METER, TEMPERATURE ME8-018 (replaces ME8-008) RUBBER ME RUBBER A ME RUBBER B ME PLATE ME BOX ASSY., PILOT ME CASE, PILOT (UPPER) ME CASE, PILOT (LOWER) ME COVER, PILOT BOX ME CABLE, SPEEDOMETER ME

46 (replaces ME5-850) (replaces ME8-000) (replaces MF5-000) CABLE (INNER) KM1-000 (replaces ME1-670) LABEL SCREW, TAP (4X40) ME SCREW, TRUSS (4X16) ME SCREW, TRUSS (4X35) ME WASHER (6MM) O-RING (6.8X1.9) PJ4-000 (replaces ) (replaces MC7-003) SCREW, PAN (3X16) J SCREW, PAN (4X6) A (replaces A) SCREW, PAN (4X30) A (replaces A) SCREW, OVAL (5X16) G SCREW, TAP (3X20) SCREW, TAP (4X16) NUT, HEX. (4MM) S NUT, HEX. (6MM) S NUT, FLANGE (6MM) WASHER, PLAIN (4MM) WASHER, SPRING (4MM)

47 Oil Pan 01 PAN, OIL ME GASKET, OIL PAN ME2-306 (replaces ME2-000) BOLT, DRAIN (14MM) WASHER, DRAIN (14MM) BOLT, FLANGE (6X40) (replaces )

48 Oil Pump & Primary Drive Gear 01 PUMP ASSY., OIL ME SPROCKET SPROCKET CHAIN, OIL PUMP BODY, OIL STRAINER ME PIPE, OIL STRAINER ME COLLAR, O-RING VALVE ASSY., RELIEF GEAR, PRIMARY DRIVE ME BOLT, UBS (12X28) WASHER O-RING (13.6X2.4) O-RING (15X2.5) O-RING (15.3X3.5) MC BOLT, HEX. (6X8) A (replaces ) (replaces A) PIN, DOWEL (8X14) BOLT, FLANGE (6X14) (replaces ) BOLT, FLANGE (6X25) (replaces ) BOLT, FLANGE (6X32) (replaces )

49 Pedal, Brake & Shift Pedal 01 PEDAL, GEARSHIFT ME RUBBER, GEARSHIFT SWITCH, RR. STOP KA2-405 (replaces ) 001 (replaces ME8-000) SPRING, STOP SWITCH ME ROD, RR. BRAKE ME PEDAL, RR. BRAKE ME SPRING, BRAKE RETURN MR1-770 (replaces ME8-000) SHAFT, RR ME BOLT, HEX. (6X40) H NUT, HEX. (6MM) S (replaces KA3-711) (replaces S) (replaces ) (replaces S) (replaces S) (replaces ) PIN, SPLIT (1.6X12) SPRING A, BRAKE ROD JOINT, BRAKE ARM NUT B PIN B BOLT, FLANGE (6X20) (replaces ) BOLT, FLANGE (6X25) (replaces )

50 Radiator & Cooling Fan & Grille 01 RADIATOR ME GASKET, DRAIN ZB5-003 (replaces PA0-003) VALVE, DRAIN SHROUD ME FAN, COOLING ME MOTOR, FAN ME COVER, RADIATOR ME GRILLE, RADIATOR ME COVER, RADIATOR PLATE, R ME PLATE, L ME CAP, RADIATOR (replaces ) (replaces ) (replaces PA0-014) RUBBER COLLAR SUB-WIRE HARNESS A ME SWITCH ASSY., THERMO MC BOLT-WASHER (6x10) SCREW, FLAT (6X12) B (replaces ) WASHER, SPRING (5MM) WASHER, PLAIN (5MM) (replaces ) O-RING (13.5X1.4) PH7-660 (replaces ) BOLT, CAP (6X32) B SCREW, PAN (6X12) J SCREW-WASHER (5X10) NUT, HEX. (5MM) S BULK HOSE (7.5X8000) M CLIP, TUBE (B12) BOLT, FLANGE (6X10) (replaces )

51 Rear End 01 CAP, VALVE ADJ (replaces ) (replaces ) GEAR, FINAL DRIVEN ME CASE, FINAL GEAR ME STAY, RUBBER (LOWER) ME CAP, BREATHER MB0-020 (replaces MB0-010) BREATHER ASSY ME GEAR SET, FINAL MG COVER, GEAR CASE MG PLATE, DUST GUARD MG RETAINER, BEARING ME9-010 (replaces ME9-000) LOCK A, BEARING ADJ LOCK B, BEARING ADJ JOINT, PINION ME9-770 (replaces ME9-000) HOLDER, O-RING MB0-010 (replaces MB0-000) PIN MB SHIM A (0.10) MB0-310 (replaces MB0-300) AR 15 SHIM B, STOPPER PIN MB0-300 AR 16 SHIM A (1.82) MB SHIM B (1.88) MB SHIM C (1.94) MB SHIM D (2.00) MB SHIM E (2.06) MB SHIM F (2.12) MB SHIM G (2.18) MB WASHER (35X40) MB SPACER A (1.82) MB SPACER B (1.88) MB SPACER C (1.94) MB SPACER D (2.00) MB

52 18 SPACER E (2.06) MB SPACER F (2.12) MB SPACER G (2.18) MB SPACER H (2.24) MB SPACER I (2.30) MB COLLAR B, RR MB BOLT, SEALING (8MM) BOLT, FLANGE (8X27) MB BOLT, FLANGE (10X38) BOLT, HEX. (6X16) MB NUT, FLANGE (16MM) ME NUT, HEX. (16MM) MB0-010 (replaces MB0-700) GASKET (8MM) BEARING (16012C3) MB BEARING (57/34C3) MB BEARING (6305) MB BEARING (19/16) MB0-013 (replaces MB0-003) (replaces MB0-005) OIL SEAL (34X50X7) MB0-003 (replaces MB0-000) (replaces MB0-005) OIL SEAL (39X51X7) ME9-005 (replaces ME9-003) OIL SEAL (60X80X8) MB0-003 (replaces MB0-000) O-RING (30.8MM) O-RING (22.1X2) (replaces MB0-003) (replaces MB0-005) O-RING (35.2X2.4) MB0-005 (replaces MB0-000) O-RING (58.5X3.5) MB O-RING (58.5X3.5) MB0-000 (replaces MB0-003) BOLT, HEX. (6X12) A (replaces ) (replaces ) BOLT 2, STUD (8X28) E (replaces E) WASHER, PLAIN (6MM)

53 Seat 01 SEAT, DOUBLE KF5-010 (replaces ME8-000) 001 (replaces ME8-010) STAY, R. SEAT BELT KF STAY, L. SEAT BELT KF BOLT, FLANGE (6X16) (replaces )

54 Shifter Drum & Forks 01 FORK ME FORK MC7-000 (replaces ME2-000) SHAFT A MC SHAFT B MC DRUM, GEARSHIFT MC PLATE, DRUM CAM MC PLATE, DRUM CENTER COLLAR, DRUM CENTER STOPPER COLLAR SPRING, DRUM STOPPER ARM, GEARSHIFT ARM, GEARSHIFT SPINDLE, GEARSHIFT SPINDLE, GEARSHIFT SPRING, GEARSHIFT COLR, GEARSHIFT ARM SPRING SPRING PIN PLATE, POINT WASHER (12MM) WASHER BEARING (16005) BOLT, FLANGE (6X25) (replaces ) BOLT, FLANGE (6X25) ROLLER (4X11.8) ROLLER (4X14)

55 Shock Absorbers, Rear 01 S/ABS ASSY., R. RR ME SPRING, RR. SHOCK ME JOINT (UPPER) MC DAMPER, R. RR ME ADJUSTER, SPRING ME SEAT, SPRING ME COLLAR, RR. SHOCK BUSH, RUBBER (UPPER) EMBLEM, RR. SHOCK MB S/ABS ASSY., L. RR ME DAMPER, L. RR ME SEAT B, SPRING ME RUBBER, STOPPER WASHER (10.3MM) BOLT, HEX. (10X32) B (replaces B) NUT, HEX. (10MM) S NUT, HEX. (10MM) S NUT, CAP (10MM) S

56 Stand, Center & Side Stand 01 STAND, MAIN ME COLLAR, MAIN STAND MA SPRING, MAIN STAND ME STAND ASSY., SIDE ME RUBBER, STAND COLLAR BOLT NUT, HEX. (10MM) SPRING D, SIDE STAND BOLT, FLANGE (6X25) (replaces ) BOLT, FLANGE (10X25) (replaces ) (replaces )

57 Starter Motor 01 STAY, STARTER MOTOR MOTOR ASSY., STARTER (replaces ) BRUSH SET, CARBON GEAR (27T) SPRING, CARBON BRUSH BOLT, START MTR CVR BOLT, START MTR CVR (replaces ) O-RING (60X1.4) (replaces ) O-RING (24.4X3.1) MG7-003 (replaces ) (replaces ) NUT, HEX. (6MM) S (replaces ) WASHER, SPRING (5MM) WASHER, SPRING (6MM) CIRCLIP (11MM) BOLT, FLANGE (6X18) (replaces ) BOLT, FLANGE (6X35) (replaces )

58 Steering Stem & Horns 01 STAY, HORN ME HORN ASSY. (HIGH) MB HORN ASSY. (HIGH) MB HORN ASSY. (LOW) MB1-740 (replaces MB1-700) RACE, STEERING BALL (replaces ) RACE, STEERING BALL (replaces ) STEM, STEERING ME RACE, STEERING CONE (replaces ) RACE, STEERING CONE (replaces ) DUST SEAL WASHER THREAD KE8-010 (replaces ME9-000) COVER (LOWER) ME9-000 (replaces ME9-000) GROMMET, A/CLNR HSG BOLT, SOCKET (10X30) MB BOLT, FLANGE (6X12) (replaces ) BOLT, FLANGE (6X14) (replaces ) BALL (#8) (1/4)

59 Swingarm 01 JOINT, YOKE ME SHAFT, DRIVE ME BOOT, JOINT SPRING ME RING, YOKE STOPPER ME RING, STOPPER MB ARM, RR ME SWINGARM *NH1Z* ME8-000ZA (replaces ME8-000) PLATE, DUST SEAL LABEL, TIRE CAUTION ME BOLT, PIVOT ME BOLT, L. RR ME BOLT, RR CAP, R. LOCK NUT ME NUT, HEX. (8MM) NUT, LOCK (23MM) ME BEARING (30202) (replaces ) (replaces ) (replaces ) OIL SEAL (27X43X7) ME OIL SEAL (20X35X5) ME5-003 (replaces ME5-004) NUT, HEX. (8MM) S WASHER, PLAIN (8MM) WASHER (10MM) PIN, COTTER (2.0X35) (replaces ) (replaces ) (replaces ) (replaces ) (replaces ) PIN, COTTER (2.0X22)

60 23 PIN, SPLIT (2.0X22) BOLT, FLANGE (8X32) (replaces )

61 Tail Light 01 GASKET, SEAL SA TAILLIGHT UNIT ME SOCKET, TAILLIGHT ME CASE, TAILLIGHT ME LIGHT ASSY., LICENSE MG1-003 (replaces ME8-671) BASE MB LENS, LICENSE MB1-013 (replaces MB1-003) WIRE, LICENSE ME COVER MB GASKET, LENS MB BULB (12V8W4CP) (67) (replaces ) (replaces ) (replaces ) (replaces ) BULB (12V27/8W) BRKT, NUMBER PLATE ME NUT, CAP (4MM) S NUT, FLANGE (6MM)

62 Thermostat & Coolant Pipes & Hoses 01 THERMOSTAT UNIT (replaces ) COVER, THERMOSTAT MA CASE, THERMOSTAT PIPE, WATER (UPPER) ME STAY, THERMOSTAT ME JOINT A, WATER PIPE ME HOSE, WATER (UPPER) ME HOSE, WATER (LOWER) ME CLAMP, WATER PIPE ME PIPE, RR. WATER ME WIRE B, GUARD BAND, HOSE TUBE (5X225) ME CLIP, COIL WIRE ME SENDING UNIT BOLT, SPECIAL (5X22) O-RING (21.9X2.3) MB6-003 (replaces ) (replaces ) SEAL, WATER PIPE O-RING (53.8X3.1) O-RING (13.5X1.4) PH7-660 (replaces ) O-RING (23X2.8) CLIP, TUBE (D10.5) BOLT, FLANGE (6X25) (replaces ) BOLT, FLANGE (6X25) BOLT, FLANGE (6X25)

63 Tools 01 TOOL SET ME WRENCH, PIN WRENCH (18.5X17) WRENCH, EYE (12MM) WRENCH, HEX. (6MM) WRENCH, HEX. (5MM) SPANNER (10X12) SPANNER (14X17) PLIERS (135) SCREWDRIVER 1 (NO.2) SCREWDRIVER 2 (NO.3) SCREWDRIVER 3 (NO.2) GRIP HANDLE (12MM) WRENCH, EYE (24MM) BAG, TOOL ME5-670 (replaces )