Automation Molded Case Circuit Breakers IEC Style. Motors Automation Energy Transmission & Distribution Coatings

Transcription

1 Automation Molded Case Circuit Breakers IEC Style Motors Automation Enery Transmission & Distribution Coatins

2 Molded Case Circuit breakers

3 Molded Case Circuit Breakers Summary Molded Case Circuit Breakers 0 Overview and Technical Data 06 Reference Code 08 Selection Guide 09 Trip Units 6 Accessories 8 Installation and Connections 9 Characteristic Curves Dimensions (mm) 9

4 Molded Case Circuit Breakers DWB and DWA circuit breakers were developed accordin to IEC standard to protect electrical circuits for distribution, enerator and motor applications in a wide rane of rated currents from 6 to 600 A. The Riht Circuit Breaker for our Application For power distribution and electric circuits the circuit breakers DWB_D up to 00 A and DWA up to 800 A ensure overload and short-circuit protections throuh thermal and manetic releases, respectively. The DWA600 features an electronic trip unit providin LSI protection. DWB_M and DWM circuit breakers are desined to protect motor branch circuit aainst short-circuits, therefore, these circuit breakers trip units have manetic releases only. Moreover, they are set in order to avoid the motor trippin durin the startin time of the motor, when the motor current is up to 8 times its rated current. These circuit breakers are used in three-component starters alon with the contactor as switchin device and the overload relay for overload protection of the motor. In enerator applications, DWB_G and DWG circuit breakers are applied to protect enerators and, then, avoid any risks due to short-circuit and overload situations. Their trip units are composed of thermal and manetic releases especially desined to meet the specific requirements of low fault levels when protectin a enerator. Finally, IWB and IWA switch-disconnectors are applied to switch on and off electrical circuits under normal conditions, this way, these devices are not applied as protection, therefore they do not have trip units. Protectin and Disconnectin in Frames The new DWB circuit breakers are very compact savin space in electrical panels. Its rated current oes from 6 to 00 A in frame sizes: DWB60 - currents from 6 to 60 A DWB0 - currents from 80 to 0 A DWB00 - currents from 60 to 00 A In applications above 00 A, DWA circuit breakers complement the solution providin protection up to 600 A. DWA800 - currents from 0 to 800 A DWA600_E - currents from 00 to 600 A Molded Case Circuit Breakers

5 Molded Case Circuit Breakers Flexibility WEG DWB rane offers full flexibility for customers when fittin internal accessories, because the auxiliary contact blocks are common for frames 60, 0 and 00 moreover the shunt and undervoltae releases are common for frames 60 and 0. Easiness for Replacement Throuh the transparent front cover of DWB circuit breakers, it can be easily identified which accessories are installed. Double Protection Oriented to provide safe solutions to electricians, WEG circuit breakers have double insulation between live parts and the front of the equipment, except terminals. Besides that, internal accessories were desined to be completely separate from the power circuit, this way avoidin any risk of contact with live parts. Hih Performance The WEG molded case circuit breakers can be used in a wide rane of applications providin quick protection aainst short-circuits. Alon with WEG contactors and WEG smart relay, DWB rane fulfills the requirements of type coordination accordin to standard IEC L 80 ka H 6 ka S 0 ka N ka ) B 6 ka Short-circuit breakin 80 / V DWB60 DWB0 DWB00 DWA800 DWA600 Note: ) Except DWB60N that breaks up to 0 ka. Molded Case Circuit Breakers

6 Overview and Technical Data Common characteristics Desined accordin to IEC Rated voltaes Rated operational voltae - Ue (0 / 60 Hz) 690 V dc 0 ) Rated impulse withstand voltae - Uimp kv 8 Other characteristics Selectivity cateory A Pollution deree Maximum relative humidity 9% DWB60 DWB0 Electrical characteristics accordin to IEC Rated current - In ( C) ) A 60 Number of poles,, Insulation voltae - Ui V 800 Short-circuit breakin capacity levels B N L Rated ultimate short-circuit breakin capacity - Icu Rated service short-circuit breakin capacity - Ics Mechanical lifespan (C-O) Electrical lifespan (C-O) ka rms 0-0 V V 6 0 ) 80 0 V 0 ) V V V % Icu 0-0 V 0% 0% 7% 80- V 0% 0% 7% 0 V 0% 0% 7% V 0% 0% 7% -0 V 0% 0% 7% V 0% 7% 0% Number of operations 8000 Operations per hour Number of operations 00 Operations per hour Protection Aainst short-circuit & overload (fixed thermomanetic) es Aainst short-circuit & overload (adjustable thermal and fixed manetic) es Aainst short-circuit & overload (adjustable thermomanetic) No LSI (electronic) No Aainst short-circuit (manetic only) es Switch-disconnector (no trip unit) es Installation and connections Maximum cross-section mm² 70 Cables Minimum cross-section mm² Torque tihtenin Nm 6 Busbars Maximum width mm² Torque tihtenin Nm 6 Dimensions W (W-P) x D x H mm 78 (.) x 7 x 6) 78 x 6 x 6) Weiht / poles ( poles) k 0.9 (.).8 0,, 800 B N L % 0% 7% 0% 0% 7% 0% 0% 7% 0% 0% 0% 0% 0% 0% 0% 7% 7% No es No No es es 8 () x 78 x 6 6) x 7 x 9 6).8 (.9).8 Notes: ) Not applicable for DWA600. ) For other temperatures, see section Installation and connections. ) Circuit breakers with rated currents of 6, 0, and A, the short-circuit breakin capacity Icu is 0 ka. ) Circuit breakers with rated currents of 6, 0, and A, the short-circuit breakin capacity Icu is ka. ) Valid for DWA800 up to 60 A. 6) Not considerin phase barriers and/or terminal covers. 6 Molded Case Circuit Breakers

7 DWB00 DWA800 DWA ,,,,,, N H N H S H % 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% 0% 7% ) ) No No No No No No es es No No No es es es es es es es x 0 x (M8) / 0 (M) x 0 x 8 / x (M) / 0 (M) 7 () x 99 x 7 6) (80) x 97 x 7 6) (80) x 6 x 6).6 (.6) 7. (9.) 9 () Molded Case Circuit Breakers 7

8 Reference Code DWB Reference DWB60 DWB0 DWB00 IWB60 IWB0 IWB00 Breakin capacity 80 Code 6 ka B 0/ ka N 6 ka H 80 ka L DWB60N - DF Rated current Number of poles Application Trip unit Code Fixed thermomanetic D Distribution Adjustable thermal and fixed manetic DF Adjustable thermomanetic DA Motor Fixed manetic MF Adjustable manetic MA Fixed thermomanetic G Generator Adjustable thermal and fixed manetic GF Adjustable thermomanetic GA DWA Application Distribution Motor Generator ) Switchdisconnector Code DWA DWM DWG IWA Breakin 80 Code 0/ ka N 0 ka S 6 ka H BD - rated voltae Code / dc E6 8 / dc E7 60 / dc E8 - / dc E BS - rated voltae Code V dc C0 8 V dc C07 V dc C -7 D / dc E 00-0 D66 None D70 N/A None 0 N/A DWA800H E - D66 Frame size Rated current Number of poles Rotary handle Code MR 66 mm DWA MR 6 mm DWA MRI MRI None 0 N/A Auxiliary contacts BC/AL Code AL 0 BC BC+AL BC 0 BC+AL BC 0 E None 0 E600 N/A Nota: ) For enerator protection on the frame 600 use DWA Molded Case Circuit Breakers

9 Selection Guide Circuit Breakers for Distribution Circuit Protection - and Poles DWB60 In Rated current (A) Short-circuit breakin capacity Icu (ka) Thermal protection Reference code current settin Manetic protection current settin Minimum Maximum poles poles ) DWB60B - Fixed thermomanetic DWB60B6-D DWB60B6-D DWB60B0-D DWB60B0-D 00 6 DWB60B-D DWB60B-D 0 6 DWB60B-D DWB60B-D DWB60B0-D DWB60B0-D DWB60B0-D DWB60B0-D DWB60B6-D DWB60B6-D DWB60B70-D DWB60B70-D DWB60B80-D DWB60B80-D DWB60B90-D DWB60B90-D DWB60B0-D DWB60B0-D 0 6 DWB60B-D DWB60B-D 0 6 DWB60B-D DWB60B-D 0 6 DWB60B-D DWB60B-D DWB60B60-D DWB60B60-D DWB60N - Fixed thermomanetic DWB60N6-D DWB60N6-D DWB60N0-D DWB60N0-D DWB60N-D DWB60N-D DWB60N-D DWB60N-D DWB60N0-D DWB60N0-D DWB60N0-D DWB60N0-D DWB60N6-D DWB60N6-D DWB60N70-D DWB60N70-D DWB60N80-D DWB60N80-D DWB60N90-D DWB60N90-D DWB60N0-D DWB60N0-D DWB60N-D DWB60N-D DWB60N-D DWB60N-D DWB60N-D DWB60N-D DWB60N60-D DWB60N60-D DWB60L - Fixed thermomanetic DWB60L6-D DWB60L6-D DWB60L0-D DWB60L0-D DWB60L-D DWB60L-D DWB60L-D DWB60L-D DWB60L0-D DWB60L0-D DWB60L0-D DWB60L0-D DWB60L6-D DWB60L6-D DWB60L70-D DWB60L70-D DWB60L80-D DWB60L80-D DWB60L90-D DWB60L90-D DWB60L0-D DWB60L0-D DWB60L-D DWB60L-D DWB60L-D DWB60L-D DWB60B - Adjustable thermal and fixed manetic DWB60B0-DF DWB60B0-DF DWB60B0-DF DWB60B0-DF DWB60B6-DF DWB60B6-DF DWB60B80-DF DWB60B80-DF DWB60B0-DF DWB60B0-DF DWB60B-DF DWB60B-DF DWB60B60-DF DWB60B60-DF DWB60N - Adjustable thermal and fixed manetic DWB60N0-DF DWB60N0-DF DWB60N0-DF DWB60N0-DF DWB60N6-DF DWB60N6-DF DWB60N80-DF DWB60N80-DF DWB60N0-DF DWB60N0-DF DWB60N-DF DWB60N-DF DWB60N60-DF DWB60N60-DF Note: ) -pole circuit breaker in a -pole frame. Molded Case Circuit Breakers 9

10 Selection Guide Circuit Breakers for Distribution Circuit Protection - and Poles DWB0 Rated current (A) Short-circuit breakin capacity Icu (ka) Thermal protection Reference code In current settin Manetic protection current settin Minimum Maximum poles poles ) DWB0B - Adjustable thermal and fixed manetic DWB0B0-DF DWB0B0-DF 0 6 DWB0B-DF DWB0B-DF DWB0B60-DF DWB0B60-DF DWB0B00-DF DWB0B00-DF DWB0B0-DF DWB0B0-DF DWB0N - Adjustable thermal and fixed manetic DWB0N0-DF DWB0N0-DF DWB0N-DF DWB0N-DF DWB0N60-DF DWB0N60-DF DWB0N00-DF DWB0N00-DF DWB0N0-DF DWB0N0-DF DWB0L - Adjustable thermal and fixed manetic DWB0L0-DF DWB0L0-DF DWB0L-DF DWB0L-DF DWB0L60-DF DWB0L60-DF DWB0L00-DF DWB0L00-DF DWB00 Rated current (A) Short-circuit breakin capacity Icu (ka) In Thermal protection Manetic protection Reference code current settin current settin Minimum Maximum Minimum Maximum poles poles ) DWB00N - Adjustable thermomanetic DWB00N00-DA DWB00N00-DA DWB00N0-DA DWB00N0-DA DWB00N0-DA DWB00N0-DA DWB00N00-DA DWB00N00-DA DWB00H - Adjustable thermomanetic DWB00H00-DA DWB00H00-DA DWB00H0-DA DWB00H0-DA DWB00H0-DA DWB00H0-DA DWB00H00-DA DWB00H00-DA DWA800 Rated current (A) Short-circuit breakin capacity Icu (ka) In Thermal protection Manetic protection Reference code current settin current settin Minimum Maximum Minimum Maximum poles poles ) DWA800N - Adjustable thermomanetic DWA800N-00- DWA800N DWA800N-60- DWA800N DWA800N-800- DWA800N-800- DWA800H - Adjustable thermomanetic DWA800H-00- DWA800H DWA800H-60- DWA800H DWA800H-800- DWA800H-800- DWA600 Rated current (A) Short-circuit breakin capacity Icu (ka) In Thermal protection Manetic protection Reference code current settin current settin Minimum Maximum Minimum Maximum poles poles ) DWA600S-E - Electronic LSI DWA600S-E- DWA600S-E DWA600S-E600- DWA600S-E600- DWA600H-E - Electronic LSI DWA600H-E- DWA600H-E DWA600H-E600- DWA600H-E600- Note: ) -pole circuit breaker in a -pole frame. Molded Case Circuit Breakers

11 Selection Guide Circuit Breakers for Distribution Circuit Protection - Poles DWB60 In Rated current (A) Thermal protection current settin Minimum Maximum Manetic protection current settin 0-0 Short-circuit breakin capacity Icu (ka) DWB60B - Fixed thermomanetic Neutral not protected Reference code ( poles) Neutral 0% protected Neutral 0% protected DWB60B6-D DWB60B6-DT DWB60B0-D DWB60B0-DT 00 6 DWB60B-D DWB60B-DT 0 6 DWB60B-D DWB60B-DT DWB60B0-D DWB60B0-DT DWB60B0-D DWB60B0-DT DWB60B6-D DWB60B6-DT DWB60B70-D DWB60B70-DT DWB60B80-D DWB60B80-DT DWB60B90-D DWB60B90-DT DWB60B0-D DWB60B0-DT 0 6 DWB60B-D DWB60B-DT 0 6 DWB60B-D DWB60B-DT 0 6 DWB60B-D DWB60B-DP DWB60B-DT DWB60B60-D DWB60B60-DP DWB60B60-DT DWB60N - Fixed thermomanetic DWB60N6-D DWB60N6-DT DWB60N0-D DWB60N0-DT DWB60N-D DWB60N-DT DWB60N-D DWB60N-DT DWB60N0-D DWB60N0-DT DWB60N0-D DWB60N0-DT DWB60N6-D DWB60N6-DT DWB60N70-D DWB60N70-DT DWB60N80-D DWB60N80-DT DWB60N90-D DWB60N90-DT DWB60N0-D DWB60N0-DT DWB60N-D DWB60N-DT DWB60N-D DWB60N-DT DWB60N-D DWB60N-DP DWB60N-DT DWB60N60-D DWB60N60-DP DWB60N60-DT DWB60B - Adjustable thermal and fixed manetic DWB60B0-DF DWB60B0-DFT DWB60B0-DF DWB60B0-DFT DWB60B6-DF DWB60B6-DFT DWB60B80-DF DWB60B80-DFT DWB60B0-DF DWB60B0-DFT DWB60B-DF DWB60B-DFT DWB60B60-DF DWB60B60-DFP DWB60B60-DFT DWB60N - Adjustable thermal and fixed manetic DWB60N0-DF DWB60N0-DFT DWB60N0-DF DWB60N0-DFT DWB60N6-DF DWB60N6-DFT DWB60N80-DF DWB60N80-DFT DWB60N0-DF DWB60N0-DFT DWB60N-DF DWB60N-DFT DWB60N60-DF DWB60N60-DFP DWB60N60-DFT Molded Case Circuit Breakers

12 Selection Guide Circuit Breakers for Distribution Circuit Protection - Poles DWB0 In Rated current (A) Thermal protection current settin Minimum Maximum Manetic protection current settin 0-0 Short-circuit breakin capacity Icu (ka) DWB0B - Adjustable thermal and fixed manetic Neutral not protected Reference code ( poles) Neutral 0% protected Neutral 0% protected DWB0B0-DF DWB0B0-DFT 0 6 DWB0B-DF DWB0B-DFT DWB0B60-DF DWB0B60-DFP DWB0B60-DFT DWB0B00-DF DWB0B00-DFP DWB0B00-DFT DWB0B0-DF DWB0B0-DFP DWB0B0-DFT DWB0N - Adjustable thermal and fixed manetic DWB0N0-DF DWB0N0-DFT DWB0N-DF DWB0N-DFT DWB0N60-DF DWB0N60-DFP DWB0N60-DFT DWB0N00-DF DWB0N00-DFP DWB0N00-DFT DWB0N0-DF DWB0N0-DFP DWB0N0-DFT DWB00 In Rated current (A) Short-circuit breakin capacity Icu (ka) Thermal protection Manetic protection Reference code ( poles) current settin current settin Minimum Maximum Minimum Maximum Neutral not protected DWB00N - Adjustable thermomanetic DWB00N00-DA DWB00N0-DA DWB00N0-DA DWB00N00-DA DWB00H - Adjustable thermomanetic DWB00H00-DA DWB00H0-DA DWB00H0-DA DWB00H00-DA DWA800 In Rated current (A) Short-circuit breakin capacity Icu (ka) Thermal protection Manetic protection Reference code ( poles) current settin current settin Minimum Maximum Minimum Maximum Neutral not protected DWA800N - Adjustable thermomanetic DWA800N DWA800N DWA800N-800- DWA800H - Adjustable thermomanetic DWA800H DWA800H DWA800H-800- DWA600 In Rated current (A) Short-circuit breakin capacity Icu (ka) Thermal protection Manetic protection Reference code ( poles) current settin current settin Minimum Maximum Minimum Maximum Neutral not protected DWA600S-E Electronic LSI DWA600S-E DWA600S-E600- DWA600H-E Electronic LSI DWA600H-E DWA600H-E600- Molded Case Circuit Breakers

13 Selection Guide Circuit Breakers for Generator Protection DWB60 I n Rated current (A) Short-circuit breakin capacity Icu (ka) Thermal protection Reference code Manetic protection current settin current settin Minimum Maximum poles DWB60B - Fixed thermomanetic 00 6 DWB60B-G DWB60B7-G DWB60B8-G 6 DWB60B-G 60 6 DWB60B-G DWB60B0-G DWB60B60-G DWB60B - Adjustable thermal and fixed manetic 00 6 DWB60B-GF DWB60B7-GF DWB60B8-GF 8 6 DWB60B-GF DWB60B-GF DWB60B0-GF DWB60B60-GF DWB0 Rated current (A) Short-circuit breakin capacity Icu (ka) Thermal protection Reference code In Manetic protection current settin current settin Minimum Maximum poles DWB0B - Adjustable thermal and fixed manetic DWB0B-GF DWB0B-GF DWB0B60-GF DWB0B00-GF DWB0B0-GF DWB00 Rated current (A) Thermal protection current settin Manetic protection current settin Short-circuit breakin capacity Icu (ka) Reference code I n Minimum Maximum Minimum Maximum poles DWB00N - Adjustable thermomanetic DWB00N00-GA DWB00N0-GA DWB00N0-GA DWB00N00-GA DWG800 Rated current (A) Thermal protection current settin Manetic protection current settin Short-circuit breakin capacity Icu (ka) Reference code I n Minimum Maximum Minimum Maximum poles DWG800N - Adjustable thermomanetic DWG800N DWG800N DWG800N-800- DWA600 Rated current (A) Thermal protection current settin Manetic protection current settin Short-circuit breakin capacity Icu (ka) Reference code I n Minimum Maximum Minimum Maximum poles DWA600S-E - Electronic LSI DWA600S-E DWA600S-E600- DWA600H-E - Electronic LSI DWA600H-E DWA600H-E600- Molded Case Circuit Breakers

14 Selection Guide Circuit Breakers for Motor Branch Circuit Protection DWB60 In Rated current (A) Short-circuit breakin capacity Icu (ka) Reference code Manetic protection current settin poles DWB60N - Fixed manetic DWB60N-MF DWB60N-MF DWB60N0-MF DWB60N0-MF DWB60N6-MF DWB60N80-MF DWB60N9-MF DWB60L - Fixed manetic DWB60L-MF DWB60L-MF DWB60L0-MF DWB60L0-MF DWB60L6-MF DWB60L80-MF DWB60L9-MF DWB0 Rated current (A) Short-circuit breakin capacity Icu (ka) Reference code In Manetic protection current settin poles DWB0N - Fixed manetic DWB0N80-MF DWB0N-MF DWB0N-MF DWB0N8-MF DWB0N00-MF DWB0L - Fixed manetic DWB0L80-MF DWB0L-MF DWB0L-MF DWB0L8-MF DWB0L00-MF DWB00 Rated current (A) Short-circuit breakin capacity Icu (ka) Manetic protection Reference code In current settin Minimum Maximum poles DWB00H - Adjustable manetic DWB00H-MA DWB00H8-MA DWB00H0-MA DWB00H0-MA DWM800 Rated current (A) Short-circuit breakin capacity Icu (ka) Manetic protection Reference code In current settin Minimum Maximum poles DWM800H - Adjustable manetic DWM800H DWM800H-00- DWM600 Rated current (A) Short-circuit breakin capacity Icu (ka) Manetic protection Reference code In current settin W Minimum Maximum poles DWM600H - Adjustable manetic DWM600H DWM600H DWM600H-00- Molded Case Circuit Breakers

15 Selection Guide Switch-Disconnectors - No Trip Units IWB60/0/00 and IWA800/600 Rated current (A) Reference code In poles poles IWB60 60 IWB IWB IWB0 0 IWB0-0- IWB0-0- IWB00 0 IWB00-0- IWB IWB IWB IWA IWA IWA IWA IWA IWA IWA IWA IWA600-- IWA IWA IWA Molded Case Circuit Breakers

16 Trip Units WEG breakers have a wide rane of trip units to better fit into the application. Thermomanetic and electronic trip units are available dependin on the frame size. Fixed Thermal and Fixed Manetic Ratins In ºC DWB60_D x x x x x x x x x x x x x x x DWB60_G x x x x x x x Thermal protection Current settin (A) - Ir Fixed Ir = In Manetic protection Im (A) Fixed DWB60_D DWB60_G Adjustable Thermal and Fixed Manetic Ratins In ºC DWB60_DF x x x x x x x DWB0_DF x x x x x DWB60_GF x x x x x x x DWB0_GF x x x x x Thermal protection Current settin (A) - Ir Adjustable from 0.8 to x In Manetic protection Im (A) Fixed DWB60_DF DWB0_DF DWB60_GF DWB0_GF I r Curvas para Catál ( Linha DW 0 ) Adjustable Thermal and Adjustable Manetic Ratins In ºC DWB00_DA x x x x x x x DWA800 x x x x x DWB00_GA x x x x DWG800 x x x x x Thermal protection I r Current settin (A) - Ir Adjustable from 0.8 to x I ) n Manetic protection Im (A) Adjustable from to x I n DWB00_DA DWA ) Im (A) Adjustable from. to x I n DWB00_GA DWG Notes: ) Thermal protection of DWA800 and DWG800 frames is adjustable from 0.7 to x I n. ) Manetic protection of DWA A is adjustable from to 8 x I n. I r I m Ir.9.9 x In. tr at 6xIr (s) Is x Ir at 8xIr (s) I t ON ts..... Ii 8.8 L.7.6 S 6... I t OFF I 6 70% % 6 Molded Case Circuit Breakers

17 Trip Units Fixed Manetic Ratins In ºC DWB60_MF x x x x x x x DWB0_MF x x x x x Thermal protection Current settin (A) - Ir Not available Manetic protection Im (A) Fixed DWB60_MF DWB0_MF Adjustable Manetic Ratins In ºC DWB00_MA x x x x DWM800 x x DWM600 x x x Thermal protection Current settin (A) - Ir Not available Manetic protection Im (A) Adjustable from 7. to x In DWB00_MA DWM DWM I m Electronic LSI Ratins In ºC 600 DWA600 x x Thermal protection Current settin (A) - Ir Adjustable from 0. to x I n Manetic protection Im (A) Adjustable from to x I n DWA I r t r I s t s I i Ir.9.9 x In. tr at 6xIr (s) Is x Ir 6 at 8xIr (s) I t ON ts..... Ii 8 x In.8 L.7.6 S 6... I t OFF I 6 70% % L - Lon time delay trip function (protection aainst overloads). S - Short time delay trip function (protection aainst short-circuit with time delay). I - Instantaneous trip function (instantaneous protection aainst short-circuit). Status Sinalin 70% / %: J J LED ON when the current passin throuh the device reaches 70% of In LED intermittent when the current passin throuh the device reaches % of In Durin circuit breaker reset, LEDs will indicate which protection (L, S or I) was actuated in the last trip, flashin times. The electronic protection of the circuit breaker is self-powered since the protected circuit provides the necessary enery for its operation. Molded Case Circuit Breakers 7

18 Accessories Overview of DWB MCCB DWB60 - Auxiliary contact block BC, alarm block AL, alarm/contact block BCAL - Undervoltae release BS, shunt release BD - DIN rail base BFR DWB60 P - Phase barriers of DWB60 (line side supplied as standard, load side supplied as optional) 6-90 connection extension bars CT DWB60 P 7 - Straiht extension bars BE DWB60 P (terminal tabs) 8 - Escutcheon MP DWB Mechanical interlock BLIM DWB60 P - Padlockin device PL DWB60 P - Panel door rotary operatin handle MR - Panel door rotary operatin handle MR - Terminal lus (supplied as standard) Note: and -pole DWBs use the same accessories of -pole DWBs. 8 Molded Case Circuit Breakers

19 Accessories Overview of DWB MCCB DWB0 - Auxiliary contact block BC, alarm block AL, alarm/contact block BCAL - Undervoltae release BS, shunt release BD - DIN rail base BFR DWB0 P - Terminal lus PC DWB0 P 6-90 connection extension bars CT DWB0 P 7 - Straiht extension bars BE DWB0 P (terminal tabs) 8 - Phase barriers of DWB0 (supplied as standard and as an accessory) 9 - Escutcheon MP DWB0 - Mechanical interlock BLIM DWB0 P - Padlockin device PL DWB0 - Panel door rotary operatin handle MR Note: and -pole DWBs use the same accessories of -pole DWBs. Molded Case Circuit Breakers 9

20 Accessories Overview of DWB MCCB DWB00 - Round cable terminals PC DWB00 P (lus) - Straiht extension bars BE DWB00 P (terminal tabs) - Padlockin device PL DWB00 - Motor operator AM DWB Mechanical interlock BLIM DWB Direct rotary handle MRI DWB Escutcheon MP DWB Panel door rotary operatin handle MR DWB00 - Phase barriers of DWB00 (supplied as standard and as an accessory) - Auxiliary contact block BC, alarm block AL, alarm/contact block BCAL - Undervoltae release BS, shunt release BD Note: and -pole DWBs use the same accessories of -pole DWBs. 0 Molded Case Circuit Breakers

21 Accessories Overview of DWA800 and MCCB DWA800 - MCCB DWA600 - Round cable terminals PC DWA800 (lus) - Round cable terminals PC DWA600 (lus) - Straiht extension bars BE DWA800 (terminal tabs) 6 - Straiht extension bars BE DWA600 (terminal tabs) 7 - Padlockin device PLW Direct rotary handle MRI DWA800 or MRI DWA Mechanical interlock BLIM DWA Escutcheon MP DWA Panel door rotary operatin handle MR DWA800 or MR DWA600 Notes: DWA internal accessories only sold factory-fitted. and -pole DWAs use the same accessories of -pole DWAs. Molded Case Circuit Breakers

22 Internal Accessories Auxiliary Contact and Alarm Contact Blocks The auxiliary contact and alarm blocks have the function to sinal remotely the status of circuit breakers power contacts. There are types of contact blocks available: BC Auxiliary Contact Block Indicates the main contacts status open/closed (ON/OFF) throuh a chaneover contact ( SPDT) AL Alarm Contact Block Indicates circuit breakers trip due to overload or short-circuit condition throuh a chaneover contact (SPDT) BCAL Ensemble comprised of an auxiliary contact block + alarm contact block. The BCAL block makes both functions described above Internal accessory Auxiliary contact block BC Alarm contact block AL Auxiliary contact and alarm block BCAL Number of contacts Reference code DWB60 DWB0 DWB00 DWA800 ) DWA600 ) chaneover BC- DWB BC- DWA800 BC- DWA600 chaneover BC- DWB BC- DWA800 BC- DWA600 chaneover - BC- DWA800 BC- DWA600 chaneover AL- DWB AL- DWA BC + AL BC + AL BCAL- DWB - Electrical characteristics Rated voltae Type of load Switchin capacity ² ) (A) Resistive 6 Inductive 0 Resistive 6 Inductive V dc Resistive Inductive V dc Resistive Inductive Notes: ) Use BCAL blocks when applications require auxiliary contact block and alarm block fitted in the same circuit breaker. ) Not applicable for motor switchin. BCAL- DWA800 BCAL- DWA BCAL- DWA600 BCAL- DWA Usin BC and AL Blocks BC, AL and BCAL blocks already come with built-in terminal blocks. These terminal blocks accept wires of 0. to. mm² (0 to 6 AWG) and tihtenin torque of 0.8 Nm (6.9 lb. inch). Wirin Diarams ON OFF TRIP BC 8 8 AL Molded Case Circuit Breakers

23 Internal Accessories Shunt and Undervoltae Releases Voltae releases function to trip remotely the circuit breaker. They are often used for remote emerency stop purpose. BD Shunt Release When enerized by a pulse or maintained sinal of voltae, the shunt release trips the circuit breaker (trip position). The shunt release works from 70 to % of the rated voltae (0.70 x Un < Ue <. x Un) This release features a device to keep it not enerized after the trippin pulse BS Undervoltae Release Trips the circuit breaker when the voltae drops below % of the rated voltae (Ue < 0. x Un) When voltae is between to 70% of the rate voltae, it may open the circuit breaker (0. x Un < Ue < 0.7 x Un) After the operation of BS release, circuit breaker can only be closed if supply voltae is above 8% of the rated voltae (Ue > 0.8 x Un) The BS undervoltae release alon with an emerency stop push button makes possible the fail-safe operation of the circuit breaker BS undervoltae release Reference code Rated voltae (Ue) Voltae code DWB60 / DWB0 Consumption DWB00 DWA800 DWA600 Consumption /7 D60 BS DWB00 D60 BS D60 DWA800 BS D60 DWA600 VA 0/0 D66 BS DWB00 D66 BS D66 DWA800 BS D66 DWA600 VA 80- D70 BS DWB00 D70 BS D70 DWA800 BS D70 DWA600 VA 0-80 D7 BS DWB00 D7 BS D7 DWA800 BS D7 DWA600 VA V dc C0 BS DWB00 C0 BS C0 DWA800 BS C0 DWA600 W 8 V dc C07 BS DWB00 C07 BS C07 DWA800 BS C07 DWA600 W V dc C BS C DWA800 BS C DWA600 W / V dc E6 BS DWB60-0 E6. VA 8 / V dc E7 BS DWB60-0 E7. VA 60 / V dc E8 BS DWB60-0 E8. VA / / V dc E BS DWB60-0 E. VA 0/0 / V dc E BS DWB60-0 E. VA BD shunt release / V dc E6 BD DWB60-0 E6 VA BD DWB00 E6 BD E6 DWA800 BD E6 DWA600 6 VA 8 / V dc E7 BD DWB60-0 E7 VA BD DWB00 E7 BD E7 DWA800 BD E7 DWA600 6 VA 60 / V dc E8 BD DWB60-0 E8 VA / / V dc E BD DWB60-0 E VA BD DWB00 E BD E DWA800 BD E DWA600 6 VA 0/0 / V dc E BD DWB60-0 E VA BD DWB00 E BD E DWA800 BD E DWA600 6 VA Usin BD and BS Releases BD and BS releases already come with built-in terminal blocks. These terminal blocks accept wires of 0. to. mm² (0 to 6 AWG) and tihtenin torque of 0.8 Nm (6.9 lb.inch). After BD or BS releases have operated, the circuit breaker have to be reset before bein closed aain. Possible Confiurations of Internal Accessories Wirin Diarams Internal accessory DWB60 DWB0 DWB00 DWA800 DWA600 Auxiliary contact Alarm contact Shunt release Undervoltae release BD C C BS BS D D Molded Case Circuit Breakers

24 External Accessories Panel Door Rotary Operatin Handles The MR rotary handles allow external operation of a circuit breaker installed in a electrical panel. WEG has options to better fit accordin to customer needs. MR Deree of protection IP When in ON position, panel door cannot be opened, unless a tool is used to bypass the panel door lockin system, allowin thermometry of the panel Circuit breaker and panel door padlockin in OFF position usin to padlocks. MR allows padlocks with diameters of Ø...8 mm Handle shaft lenth can be adjusted up to 6 mm Available in color versions: black handle/ray backround and red handle/yellow backround MR Hiher deree of protection IP66 When in ON position, panel door cannot be opened, unless a tool is used to bypass the panel door lockin system, allowin thermometry of the panel Circuit breaker and panel door padlockin in OFF position usin to padlocks. MR allows padlocks with diameters of Ø 8 mm Handle shaft lenth can be adjusted up to mm Available in color versions: black handle/ray backround and red handle/yellow backround Rotary operatin handle Thermometry feature Deree of protection Shaft lenht (mm) Handle lenht (mm) Handle color / backround color Reference code DWB60 DWB0 DWB00 DWA800 DWA600 MR es IP MR es IP66 Black / ray MR DWB60 MR DWB0 MR DWB00 / 80 ) Red / yellow MR DWB60 E MR DWB0 E MR DWB00 E 66 Black / ray MR66 DWA800 MR66 DWA600 Red / yellow MR66E DWA800 MR66E DWA600 Black / ray MR DWB60 0 MR DWB0 0 MR DWB / 80 ) Red / yellow MR DWB60 0 E MR DWB0 0 E MR DWB00 0 E 6 Black / ray MR6 DWA800 MR6 DWA600 Red / yellow MR6E DWA800 MR6E DWA600 - Black / ray MR DWB60 Red / yellow MR DWB60 E 0 - Black / ray MR DWB60 0 Red / yellow MR DWB60 0 E Note: ) DWB60 handle lenht of mm / DWB0 and DWB00: handle lenht of 80 mm. Molded Case Circuit Breakers

25 External Accessories Direct Rotary Operatin Handles The MRI direct rotary handles allow direct and rotary operation of circuit breakers. MRI Deree of protection IP0 Padlockin in OFF position usin to padlocks Direct rotary operatin handle Thermometry feature Deree of protection Handle color/ Backround color Reference code DWB00 DWA800 DWA600 MRI No IP0 Black/Gray MRI DWB00 MRI DWA800 MRI DWA600 Motor Operator The AM motor operator makes possible complete remote operation of 00 A circuit breakers or switch-disconnectors. AM Remote operation device Automatic and manual selection throuh front switch In automatic operation, the switchin on and off control is done by electrical sinals usin pushbuttons. The maximum operation frequency is 60 operations/ hour In manual operation, the AM motor operator can be only used locally usin the switchin lever After installin the AM device, the status of the circuit breaker is shown on the front of the motor operator Besides usin the circuit breaker + AM operator for remote switchin of motors and electrical circuits, the confiuration of x MCCB+AM creates an automatic chaneover system (see CTM topic) The AM motor operator can be used in -pole and -pole 00 A frame size circuit breakers External accessory Rated voltae - Ue Consumption (W) Reference code DWB00 V dc AM DWB00 C0 Motor operator AM 8-60 V dc AM DWB00 C /dc AM DWB00 E 0 / 0 V dc AM DWB00 E6 Note: Other voltaes upon request. Usin AM Motor Operator AM device already comes with built-in terminal blocks. These terminal blocks accept tihtenin torque of. Nm (. kf.cm). Wirin Diarams S S S Ue ON OFF Molded Case Circuit Breakers

26 External Accessories Chaneover Devices Manual-operated or automatic chaneovers are used to make safe switchin of two different circuits. BLIM Mechanical Interlock Provides safe operation in a manual-operated chaneover system Makes the mechanical interlock of circuit breakers of the same frame size, preventin both MCCBs to be in ON position at the same time It can be padlocked in positions: MCCB ON and MCCB OFF, MCCB OFF and MCCB ON BLIM allows padlocks with diameters of Ø...8 mm For DWB60 and DWB0, it is possible to interlock MCCBs side-by-side usin BLIMs Also available for -pole circuit breakers External accessory MCCB Reference code DWB60 P BLIM DWB60 P DWB60 P BLIM DWB60 P DWB0 P BLIM DWB0 P Mechanical interlock BLIM DWB0 P BLIM DWB0 P DWB00 P BLIM DWB00 P DWB00 P BLIM DWB00 P DWA800 P / DWA600 P BLIM DWA DWA800 P / DWA600 P BLIM DWA P CTM Automatic Chaneover The most widely used chaneover system, no human-interference is required Remote operation is made by AM motor operators The chaneover system may be built between MCCBs, switch-disconnectors or MCCB and switch-disconnector The CTM ensemble is also comprised AM motor operators + BC contact blocks + mountin plate + rear mechanical interlock device To prevent erroneous manual operation in case of a electrical fault, the CTM features the mechanical interlock Product Selection Type of protection Circuit breaker / Switch-disconnector left Circuit breaker / Switch-disconnector riht Reference V dc /dc 0 / 0 V dc Distribution Generator CTM00- DA GAP-C0-000 CTM00- DA GAP-E-000 CTM00- DA GAP-E6-000 Distribution None¹ ) CTM00- DA IP-C0-000 CTM00- DA IP-E-000 CTM00- DA IP-E6-000 Distribution Distribution CTM00- DA DAP-C0-000 CTM00- DA DAP-E-000 CTM00- DA DAP-E6-000 None¹ ) None¹ ) CTM00- I IP-C0-000 CTM00- I IP-E-000 CTM00- I IP-E6-000 Generator Generator CTM00- GA GAP-C0-000 CTM00- GA GAP-E-000 CTM00- GA GAP-E6-000 Generator None¹ CTM00- GA IP-C0-000 CTM00- GA IP-E-000 CTM00- GA IP-E6-000 Replace by Rated current ¹ ) ¹ ) Replace by N H Short-circuit breakin capacity 80/ ka 6 ka Note: ) The rated currents available for switch-disconnectors (without trip unit) are 0 or 00 A. 6 Molded Case Circuit Breakers

27 External Accessories Accessories for Connection and Installation Dependin on the application and local standards, the MCCB may be installed in several positions in a panel and connected throuh busbars or cables. Given these requirements, the DWA and DWB rane of circuit breakers have the specific connection accessories to comply with. BE Straiht Extension Bars (Terminal Tabs) Extends the MCCB busbars for connection usin busbars or cables with rin terminals Also available for -pole circuit breakers CT 90 Extension Bars (Terminal Tabs) Allows direct connection usin busbars or cables from the back side of the MCCB CT is supplied with pieces Also available for -pole circuit breakers PC Round Cable Terminals (Lus) Allows the MCCB for connection usin cables PC is supplied with pieces Also available for -pole circuit breakers Built-in for DWB60 models BFR DIN Rail Base Quick assembly of DWB60 and DWB0 on mm DIN rails Fast replacement when panel is under maintenance External accessory MCCB Supplied with (units) Maximum cross-section (mm²) Reference code DWB60 P BE DWB60 P DWB60 P BE DWB60 P DWB0 P BE DWB0 P DWB0 P BE DWB0 P DWB00 P BE DWB00 P Straiht extension busbar BE DWB00 P See installation and connections BE DWB00 P DWA800 P on pae 6. BE DWA800 DWA800 P BE DWA800-P DWA600 P (up to A) BE DWA600- DWA600 P (up to A) BE DWA600--P DWA600 BE DWA600 DWA600-P BE DWA600-P DWB60 P CT DWB60 P DWB60 P CT DWB60 P DWB0 P CT DWB0 P 90 extension bar CT DWB0 P See installation and connections CT DWB0 P DWB00 P on pae 6. CT DWB00 P DWB00 P CT DWB00 P DWA800 P / P CT DWA800 DWA600 P / P CT DWA600 DWB0 P ( cable) PC DWB0 P DWB0 P ( cable) PC DWB0 P Round cable terminal PC DWB00 P 0 ( cable) PC DWB00 P DWB00 P 0 ( cable) PC DWB00 P DWA800 P / P 0 ( cables) PC DWA800 DWA600 P / P 0 ( cables) PC DWA600 DWB60 P N/A BFR DWB60 DIN rail base BFR ) DWB0 P N/A BFR DWB0 Note: ) Only for DWB60B, DWB60N, DWB0B and DWB0N. Molded Case Circuit Breakers 7

28 External Accessories Escutcheons, Padlockin devices and Phase Barriers MP Escutcheons J J Escutcheons are frames for cutouts in panel doors J J It makes possible the external switchin of the MCCB throuh the front door when the circuit breakers is installed close to the panel door, maintainin the deree of protection Deree of protection IP0 See section Dimensions for cutout details External accessory MCCB Reference code DWB60 P / P MP DWB60 Escutcheon MP DWB0 P / P MP DWB0 DWB00 P / P MP DWB00 DWA800 / DWA600 - P / P MP DWA PLW Padlockin Device J J The PLW is a fixed-type device that is installed on the front of the MCCB ensurin the MCCB lockin in OFF position J J It can be padlocked usin to padlocks. PLW allows padlocks with diameters of Ø...8 mm External accessory MCCB Reference code DWA60 P PL DWB60 P DWB60 P PL DWB60 P Padlockin device PLW DWB0 P / P PL DWB0 DWB00 P / P PL DWB00 DWA800 / DWA600 - P / P PLW PB Phase Barriers J J The circuit breakers are supplied with phase barriers for the line side, but dependin on the application, additional phase barriers are required on the load side (see pae 0) External accessory MCCB Supplied with (units) Reference code DWB60 P / DWB0 P PB DWB60-0 P Phase Barrier PB DWB60 P / DWB0 P PB DWB60-0 P DWB00 P PB DWB00 P DWB00 P PB DWB00 P 8 Molded Case Circuit Breakers

29 Installation and Connections Minimum Mountin Distances DWB60 DWB0 DWB00 DWA800 DWA600 Recommended mountin distances (mm) A B Recommended distances between circuit breakers for side by side assembly (mm) C D Recommended distances between circuit breakers for vertical assembly (mm) E E E E A B B C D Mountin position 90 Drillin for fixin the circuit breakers F 0 (DWB60B/N) (DWB60L) (DWB0B/N) 9 (DWB0L) DWB60/DWB0 DWB00/DWA800/DWA600 Dimensions of fixin screw to the plate (mm) Surpass of the fixin screw in relation to the circuit breaker (mm) H G Mx70 ( pieces) Mx70 ( pieces) Mx0 ( pieces) Mx60 ( pieces) M8x0 ( pieces) H 8 8 Tihtenin torque - fixin screw (Nm) Molded Case Circuit Breakers 9

30 Installation and Connections Phase Barriers, Terminal Covers and Insulatin Plates H L L Insulatin plate Phase barriers or terminal cover Notes: ) Supplied with the molded case circuit breaker. ) Minimum characteristic requirements of the material to be used as insulatin plate: - Dielectric strenth kv/mm. - Material not propaatin flame. - Recommended material: phenolite, polycarbonate. ) Install as picture on the left. Connection type Insulatin plate Phase barriers or terminals cover W width of the circuit breaker. L lenth of the terminal cover or phase barrier of the circuit breaker. Phase barriers or terminal covers ) Insulatin plates) ) ) Ue < 00 V Ue 00 V Ue < 00 V Ue 00 V Line Load Line Load Line Load Line Load Mandatory Optional Mandatory Optional Mandatory Direct to the circuit breaker terminal Mandatory Optional Mandatory Optional Mandatory Usin lus Mandatory Mandatory Mandatory Mandatory Usin extended lus Mandatory Mandatory Mandatory Mandatory Usin extension bars 0 Molded Case Circuit Breakers

31 Installation and Connections Thermal Dissipation Distribution MCCB Rated current - In A W/pole Power loss DWB60_D DWB60L_D Rated current - In A W/pole DWB0_D Power loss DWB0L_D 7 6 DWB00_D DWA DWA Motor branch circuit protection MCCB Rated current - In A W/pole Power loss DWB60_M DWB60L_M Rated current - In A W/pole DWB0_M. 7. Power loss DWB0L_M DWB00_M 0 9 DWM800 8 DWM600 8 Generator protection MCCB Rated current - In A Power loss W/pole DWB60_G Rated current - In A W/pole DWB0_G Power loss DWB00_G DWG DWA Switch-diconnectors Rated current - In A W/pole IWB60 Power loss IWB0 0 IWB00 0 IWA IWA Deratins Temperature deratin C C 0 C C 0 C C 0 C C 0 C C 60 C DWB DWB0 DWB DWA DWA Altitude deratin 000 m 000 m 000 m 000 m Rated current - In % Rated operational voltae - Ue V 800 ) Note: ) For DWA MCCBs the rated operational voltae is 690 V. Molded Case Circuit Breakers

32 Characteristic Curves Trippin Curves of DWB60 DWB60_D t (s) t (s) 0. 0, 0. 0, 6060A: 6.8 6,8 x xinln A: A: xinx ln 0. 0, A: 7. 7, x xin ln 0A: A: xin x ln A: 8,8 xin 6A: 8,7 xln 0.0 0,0 8.8 x ln 6 A: 8.7 x ln to a A: 8,8 x xinln 0.0 0, ,0., x xin DWB60_G t (s) t (s) 0. 0, A:. x ln 0. 0, 7 to 60 A: x ln 0. 0, 0.0 0, , ,0., x In x In DWB60_M t (s) t (s) 0. 0, 0. 0, 0. 0, 0.0 0,0 x ln 0.0 0, ,0., x xin Molded Case Circuit Breakers

33 Characteristic Curves Trippin Curves of DWB0 DWB0_D t(s) t (s) , 0. 0, x ln 0. 0, 0.0 0, , ,0., x xin DWB0_G t (s) t (s) 0. 0, 0. 0, x ln 0. 0, 0.0 0, , ,0., x In DWB0_M t (s) t(s) , 0. 0, 0. 0, 0.0 0,0 x ln 0.0 0, ,0., x xin Molded Case Circuit Breakers

34 Characteristic Curves Trippin Curves of DWB00 DWB00_D t (s) t (s) DWB00_G t(s) t (s) , 0. 0, 0. 0, 0.0 0,0 Min. man. adj. x In Max. man. adj. x In 0. 0, 0. 0, 0. 0, 0.0 0,0 Max. man. adj. x In Min. man. adj.. x In 0.0 0, ,0., x xin 0.0 0, ,0., x xin DWB00_M t (s) t(s) 0. 0, 0. 0, 0. 0, 0.0 0,0 Min. man. adj. 7. x In Max. man. adj. x In 0.0 0, ,0, x xin Molded Case Circuit Breakers

35 Characteristic Curves Trippin Curves of DW800 DWA DWG t(s) t (s) 0. 0, 0. 0, 800 A: Min. man. adj. x In Up to 60 A: Min. man. adj. x In 800 A: Max. man.. adj. 8 x In Up to 60 A: Max. man. adj. x In t (s) t(s) 0. 0, 0. 0, Max. man. adj. x In 0. 0, 0.0 0,0 0. 0, 0.0 0,0 Min. man. adj.. x In 0.0 0, ,0., x xin 0.0 0, ,0., x In DWM t (s) t(s) , 0. 0, 0. 0, 0.0 0, ,0 Min. man. adj. 7. x In Max. man. adj. x In 0.0 0,0., x In Molded Case Circuit Breakers

36 Characteristic Curves Trippin Curves of DW600 t [s] Tolerance ± 0% Tolerance ±% DWA600 - Lon and Short Protection (h) Ir Ir = 0...xIn 8 (min) 6.6 i²t i t ON i²t i t OFF tr tr =.6...8s at 6xIr at 6xlr ts ts = = s at at 8xlr 8xlr Is =...xir...xlr ,0 x Ir (r.m.s) DWA600 - Instantaneous Protection...xIn=Ii Ii x In In (r.m.s).m.s) DWM t (s) t(s) , 0. 0, 0. 0, 0.0 0,0 Min. man. adj. 7. In Max. man. adj. In 0.0 0, ,0., x In 6 Molded Case Circuit Breakers

37 Characteristic Curves Short-Circuit Limitin 80/ DWB60 B/N DWB60 L Ip (ka) Ip (ka) 0 B N Ip (ka) Ip (ka) Is Is (ka) (ka) Is Is (ka) DWB0 B/N 00 DWB0 L N 0 L Ip (ka) Ip (kâ) 0 B Ip (kâ) Ip (ka) Is (ka) Is Is (ka) (ka) Molded Case Circuit Breakers 7

38 Characteristic Curves Short-Circuit Limitin 80/ DWB00 DWA H N H N Ip (ka) Ip (kâ) 0 Ip (ka) Ip (kâ) Is (ka) Is (ka) DWA S H Ip (kâ) (ka) Is (ka) 8 Molded Case Circuit Breakers

39 Dimensions (mm) Circuit Breakers DWB60 B/N / IWB DWB60 L (P) DWB0 B/N / IWB0 DWB0 L (P) Molded Case Circuit Breakers 9

40 , Dimensions (mm) Circuit Breakers DWB00 / IWB00 7 / (P) 6, 6. 99,6.6 7, 7. DWA800 / DWG800 / DWM800 / IWA DWA600 / DWM600 / IWA ,7, (P) (P) Molded Case Circuit Breakers

41 , Dimensions (mm) Accessories MP - Escutcheons MP DWB60 MP DWB0 MP DWB00 9 MP DWA BE - Extension Bars Frame 60 P + BE DWB60 P Frame 0 P + BE DWB0 P Frame 00 P + BE DWB00 P 99, , ,6 Ø ,6 Ø.6 Ø ,6 Ø ,6 Ø.6 Ø Frame 800 P + BE DWA800 Frame 600 P + BE DWA (600 A) 86 (up (600 to A) A) 8 (up to A) Molded Case Circuit Breakers

42 Accessories MR DWB60 Dimensions (mm) MR - Panel Door Rotary Operatin Handles MR DWB60 MR DWB60,,,, Furação da porta do Painel Furação da porta do Painel Furação da porta do Painel Ø, Ø,,,,, Ø, 8, 8, 8, Ø, 8, Ø Ø Ø... Ø 8 8, 8, Ø... Ø 8 0 Ø Ø 0 8, 8, MR D Ø... Ø Ø... Ø 8 8 Frame 60 P/P + MR DWB60 MRB DWB60 MRB DWB60 MRB DWB60 Frame 60 P/P + MR DWB60 MR DWB60 MR DWB60 MR DWB60 Frame 0 P/P + MR DWB0 MR DWB0 MR DWB MR DWB MR DWB60 MR DWB Furação da porta do Painel Panel Furação Door da porta Cutout do Painel Furação da porta do Painel Furação da porta do Painel 6 Panel Door Cutout Furação da porta do Painel Furação da porta do Painel Furação da porta do Painel 0 Panel Door Furação Cutout da porta do Painel Furação da porta do Painel 8, Furação Furação 7 da da 6 porta porta do Painel do Painel 8. Ø Ø Ø Ø Ø Ø Ø 0 Ø 0 Ø 6 Ø Ø Ø 0 0 Ø Ø Ø Furação da porta do Painel 0 Ø 0 Ø Ø Ø Ø Ø Ø 0 Ø Ø Ø Ø Ø Ø Ø Ø Ø 0 Ø Ø Ø Furação da porta do Painel Ø Ø Ø Ø Ø Ø Ø Ø MR DWA800 MR DWA800 8 MR DWA MR DWA600 MR DWA60 MR DWA MR D Ø Ø,.,. Ø Ø Ø Ø Ø Ø. Ø, Ø Ø 8, 8. Ø... Ø 8 Ø...Ø8 8 6 Ø Ø Ø Molded Case Circuit Breakers

43 99, , Dimensions (mm) Accessories MR - Panel Door Rotary Operatin Handles o ainel ração da porta da porta do Painel do Painel MR DWA00 MR DWA00 MR DWA00 ão da porta do Painel MR DWA00 Furação da porta do Painel o Painel da porta do Painel MR DWA00 8, Frame 8, 00 P/P + MR MR DWB00 DWA00MR DWA00 8, 8, , 8, 8, 0, Ø, l ainel el o Painel l Ø Ø 8, Ø... Ø 8 8, Ø... Ø 8 Ø Ø Ø , Ø 6 Ø... Ø 8 Ø... Ø 8 Ø... Ø... Ø 8 Ø 8 Ø... Ø 8 8, 8, Ø 8, 0 8, 7 (P) Furação da porta Furação do Panel Furação Painel da Door porta da porta do Cutout Painel do Painel 6 Furação da porta do Painel 6 Furação da porta do Painel Furação 6 da porta Furação do Painel da porta do Painel 6 6 Ø Ø 8 8 Ø Ø Ø 0 Ø 8 8 Ø Ø 8 Ø 8 Ø Ø Ø Ø Ø Ø 0 Ø Ø Ø Ø Ø Ø Ø Ø Ø ainel el o Painel l Frame MR 800 DWA800 P/P MR + DWA800 MR DWA800 MR DWA800 MR DWA800 MR DWA800MR DWA Furação da porta Furação do Furação Painel da porta da porta do Painel do Painel Furação Panel da Door porta Cutout do Painel Furação da porta do Painel Furação da porta Furação do Painel da porta do Painel Ø Ø Ø 8 Ø 8 Ø Ø Ø Ø 8 8 Ø Ø 8 8 Ø 8 Ø Ø Ø Ø Ø Ø Ø Ø Ø Ø Ø Ø Ø MR DWA600 MR DWA600 MR DWA600 MR DWA600 MR DWA Frame 600 MR P/P DWA600 + MR DWA Panel Door Cutout Furação 6 da porta Furação do Furação Painel da porta da porta do Painel do Painel Furação da porta do Painel 6 Furação da porta do Painel Furação da porta Furação do Painel da porta do Painel el Ø 6 Ø Ø Ø Ø 6 Ø 6 Ø Ø Ø Ø Ø Ø Ø Ø 6 Ø Ø Ø Ø Ø Ø Ø Ø Ø Ø Molded Case Circuit Breakers

44 99, , Dimensions (mm) Accessories MRI - Direct Rotary Operatin Handles Frame 00 P + MRI DWB00 Frame 800 P + MRI DWA800 Frame 600 P + MRI DWA BLIM - Mechanical Interlock Frame 60 P + BLIM DWB60 P Frame 0 P + BLIM DWB0 P Frame 00 P + BLIM DWB00 P Frame 800 P + BLIM DWA Frame 600 P + BLIM DWA Molded Case Circuit Breakers

45 Dimensions (mm) Accessories PLW - Padlockin Device Frame 60 P + PLW DWB60 P Frame 0 P + PLW DWB0 Frame 00 P + PLW DWB00 Frame PLW Frame PLW AM - Motor Operator Frame 00 P/P + AM DWB00 7, 7. 7 (P) 7 99,6.6 99,6 7, (P) (P) Molded Case Circuit Breakers

46 Industrial systems enhancin productivity. Transformin enery into solutions. 6 Molded Case Circuit breakers

47 The Global Solution with Electric Machines and Automation for Industry and Enery Systems. WEG, one of the larest lobal manufacturers of Electric Motors with Quality and Efficiency reconized in different industrial areas worldwide, is also present in Enery, Transmission and Distribution, Coatins and Industrial Automation sectors, and produces and offers a wide rane of electric components for Motor Control and Protection and Electric Circuit Protection. Motor Protection and Starters Modular contactors up to 800 A (AC-) Compact contactors up to A (AC-) Control relays Motor protective circuit breakers up to 0 A Enclosed starters (plastic or metallic enclosures) Customized starters for OEM applications Overload relays Electrical Circuit Protection Miniature circuit breakers up to A J J Molded case circuit breakers up to 600 A (P and P) Air circuit breakers up to 600 A D L-G fuses up to 6 A NH L-G fuses up to 60 A NH ar fuses up to 00 A J J Switch-disconnectors for door or base mountin up to 60 A J J Residual current circuit breaker up to 0 A (0 or 00 ma) J J Sure supressors Electrical Connections Terminal blocks with screw type connection Terminal block with sprin type connection Terminal blocks for fuses Busbar and busbar connectors Identifiers for terminals and cables Printin system Capacitors Power factor compensation Lihtin Motor-run Pushbuttons and Pilot Lihts IP66 pushbuttons and pilot lihts J J Flush, uarded, extended or mushroom illuminated or non illuminated pushbuttons J J Selector switches lever or knob illuminated or non illuminated or with key Emerency pushbuttons (accordin EN 8) Contact blocks with positive break system Double pushbutton Pilot lihts with LED technoloy Customized descriptions Decentralized control stations - PBW Smart Relay Low voltae electric motor manaement system Compact and modular concept J J Full motor protection and monitorin throuh current and voltae measurements Multiple operatin modes includin PLC functions J J Easy network module chane via exclusive drawer system (Modbus, DeviceNet, Profibus modules) USB communication Free WLP prorammin software Electronic Relays Timin, monitorin and level relays. mm width frame LED for status indication J J Multifunction three-phase monitorin relays and timer relays